Professional Documents
Culture Documents
MS 400, MS 650: Series Submersible Mixer
MS 400, MS 650: Series Submersible Mixer
MS 400, MS 650: Series Submersible Mixer
The submersible mixers can be installed in all tank shapes and sizes.
Depending on the requested intensity of mixing and flow formation, one or
more mixers may be installed in a single tank.
Features:
Name Description
Specification Material
Motor casing SS304 ( SS316 for optional)
Shaft SS420
Propeller SS304 ( SS316 for optional)
Mechanical seal WuC / SiC or SiC / SiC
Sliding bracket SS304 ( SS316 for optional)
Submersible selection
Installation:
The mixer should be installed as deep as possible.
● If in one tank, 2 or more mixer installed, in order to have good
stirring performance, each mix flow should be continuous to connect
to others, and will not interaction each other.
● Distance between floor and blade's top edge should be more than
400mm,like below figure, HMIN>400mm. If lower than Hmin, the mix
flow will hit the floor, and not stir the water, waste the energy.
● Distance between water level and blade's top edge should be
minimum 1.5 times of blade diameter. Like below figure, HABOVE>1.5
times D ( impeller diameter) , If lower than Habove, the mix flow will
hit above the water level, also waste the energy.
● Distance between wall and top blade should be at least 2 times of
impeller diameter. Lmin > 2 times D ( impeller diameter) If lower
than this distance, there maybe vibration, and easy damage the mixer.