Professional Documents
Culture Documents
RCPA Report Update 2021
RCPA Report Update 2021
An explanation of what is populated in the table columns in the example provided below.
Measurand: All measurands that are performed by the participant are presented in the summary
table.
Expected Result: The expected result lists the target result for the measurand. The target result is
based on the type of target source used – these are listed below.
1. Calculated ‘All method median’
2. Calculated ‘Category median’, using the main variable of the test method. This could be the
analytical principle, measurement system, reagent or calibrator. The target source is
highlighted on the result page of the measurand.
3. Specific target – A sample with a known quantity of the measurand. A specific target is
usually assigned to samples that have been tested using a reference method or have been
tested by a reference laboratory.
The Summary of Performance also provides participants with their overall performance, and indicates what
measurands are marked for review.
Result Review
1. Summary of results – Indicates what targets are used to compare results (the BNP example above
shows results assessed against the instrument category). The table columns represent the Sample
ID, Measurement System category assigned for result comparison, median result, participant’s
result, H/L review flag (W= Within, no review required), Z-score and the APS score.
2. Your Linearity – compared to the target source – Linear regression analysis is based against the
target source of each sample, which could be the “median of all results”, “median of the assessment
category” (measurement system) or the median of a “specified target”.When performing linear
regression, the following rules of assessment are applied:
Minimum of 6 samples are required for linear regression analysis (applies to all target sources)
If the target source is “median of the assessment category”, there must be a minimum of 6
results in your peer group, for all survey samples, otherwise linear regression is based against
the “median of all results”.
If there is a change of any method category, linear regression is based on the sample range
from when the change occurred (applies to all target sources).
3. Your slope and intercept – Provides the slope and intercept calculated from the linear regression
analysis. Also provides the target low and high level, with your corresponding low and high levels
determined from the “line of best fit”.
4. Your Linearity – compared to the All and subgroup – To provide a comparison of all methods,
linear regression is performed against the same data source (all results or specific target). The
slopes represent the bias obtained from all laboratories, illustrating the slopes from all labs in ‘grey’,
the slope from participants using the same assessment category in ‘navy blue’ and highlighting your
slope in ‘light blue’.
5. Your Imprecision compared to All & Subgroup – This histogram represents the imprecision
(CV%) obtained from all laboratories. It is calculated from the scatter around the target source linear
regression line of best. The histogram illustrates all labs in ‘grey’, participants using the same
assessment category in ‘navy blue’ and highlighting your CV% as a ‘light blue’ dot.
6. Your Precision and Accuracy – Provides participants with the SD, CV and Bias calculated from
linear regression and how your results ranked against all laboratories that participated. Ranking
(from 0 or best to 100, worst) is illustrated on the top row of the scale provided under the bar.
7. Your Stats and Ranking – Provides participants with a table summarising their SD, CV, Bias, MPS
and the performance ranking.
8. Additional notes – provides participants with information, such as the target source used for linear
regression and lists any method category changes made across the survey sample range being
analysed.
Method Comparison
The method comparison provides a breakdown of all the methods (assessment category) used by
participants, listing the latest survey results obtained (left) as well as the Precision and Accuracy results
calculated from the linear regression analysis on the sample range used, facilitating peer group
comparison. The method assessment category will usually be the analytical principle, or the measurement
system. The full set of statistics are seen only when there are 4 or more users within a group, 3 users still
illustrates the median value obtained and method categories with 2 or less users do not present any
statistical data.