The revised MS1 is a lightweight motorway signal sign with a transparent front surface that is only 21% of the total area, aimed at reducing reflectivity. It uses an 11x13 pixel red and amber LED matrix with a 50mm pitch and can include 4 flashing red and amber lanterns. An I2C address plug contains identification and setup information used to configure the sign. The sign enclosure is made of composite material for light weight and includes a heater and sensors monitored by a single board computer that controls the hardware and communicates via network protocols.
The revised MS1 is a lightweight motorway signal sign with a transparent front surface that is only 21% of the total area, aimed at reducing reflectivity. It uses an 11x13 pixel red and amber LED matrix with a 50mm pitch and can include 4 flashing red and amber lanterns. An I2C address plug contains identification and setup information used to configure the sign. The sign enclosure is made of composite material for light weight and includes a heater and sensors monitored by a single board computer that controls the hardware and communicates via network protocols.
The revised MS1 is a lightweight motorway signal sign with a transparent front surface that is only 21% of the total area, aimed at reducing reflectivity. It uses an 11x13 pixel red and amber LED matrix with a 50mm pitch and can include 4 flashing red and amber lanterns. An I2C address plug contains identification and setup information used to configure the sign. The sign enclosure is made of composite material for light weight and includes a heater and sensors monitored by a single board computer that controls the hardware and communicates via network protocols.
lightweight sign with a front contains a small non-volatile face design based on the memory device which is same principle as the MS4, read by the single board aimed at reducing the computer via the FPGA reflective effect of the front using an industry standard surface. two wire I2C interface.
This transparent surface The address plug is pre
(the only reflecting part) is programmed with MS1 only 21% of the entire area. identification and set-up The sign is made of an information and is used by 11x13 pixel matrix of red the software to configure and amber LEDs, with a the MS1 indicator operation, 50mm pitch. Four red such as the sign address lanterns and four amber which allows the software to lanterns can be added on identify which packets of the X-frame and arranged to information it needs to flash in pairs. In order to respond to. minimise its weight the MS1 enclosure is constructed out of composite material.
The enclosure has a non-
reflective finish, and an anti- condensation heater for the matrix display. Maintenance access is via the front face and there is no need to remove any connectors for access. The fixings for the display board make the Technical Data PCB fixing and alignment with the front face apertures simple. The MS1 includes a Dimensions single board computer Size W x H x D (mm) 700 x 600 x 200 which communicates via the Mass (kgs) (excluding X frame) 20.5 HA NMCS2 RS485 or Specifications NRTS IP network. Power consumption (W) 50W when Lantern voltage is high The single board computer MTBF (hours) 74,256 controls all hardware via a Availability 99.66% parallel port interface and a EN 12966 categories field programmable gate array (FPGA). This provides Colour Class C3 access to various inputs Ingress Protection class P2 dust, P3 water and outputs including the Temperature range class T1 I2C address plug, analogue Luminance L3 to digital converter and Luminance Ratio R3 temperature and humidity Beam Width Class B1 sensors. For use with LED lanterns only
Colas Limited, Wallage Lane, Rowfant, Crawley, West Sussex RH10 4NF. +44 (0) 1342 711000. F +44 (0) 1342 711199. www.colas.co.uk/ids