Download as pdf or txt
Download as pdf or txt
You are on page 1of 1

4/19/2017 Principles 

And Practice Of Plumbing | by John Joseph Cosgrove
The body of clean­out ferrules (Fig. 7) is made of brass or cast­iron; fittings of either metal may be used, although cast­iron clean­out ferrules are the
better. They are thicker, heavier, more rigid...

Supports For House Drains

House drains should be firmly supported throughout their entire extent by rests or hangers spaced about ten feet apart and placed near the hubs and
under branch fittings for rising lines. When the hou...

Main Drain Trap
A main drain trap (Fig. 12) should be provided in every house drain connecting with a cesspool, septic tank or public sewer, to cut off sewer air from
the house drainage system. The trap should be loc...

Sewer And Tide Water Traps
Some street sewers are so small that water overflows the manholes in the street during excessive rain storms. When a drainage system is
connected to such a sewer it should be provided with a tide wate...

Floor Drains

In breweries, stables, washrooms, bottling establishments, hotel kitchens or other places where sufficient water is poured or splashed on the floor to
maintain the seal of a trap, floor drains (Fig. 1...

Size Of House Drains
A house drain should be large enough to carry off the greatest probable amount of water or sewage that will be discharged into it, without being too
large to be self­cleaning. It should never be small...

Size Of House Drains. Continued
The per capita consumption of water in many of the New York State hospitals average at present from 150 to 200 gallons of water daily. In the
principal cities throughout the United States the per capi...

Fresh Air Inlets
Definition A fresh air inlet is a pipe connected to the main house drain inside of the main drain trap, and extending to a point outside of the building
where it is open to the atmosphere. Its object...

Rain Leaders
Kinds Of Leaders Rain leaders may be divided into inside leaders and outside leaders. Inside leaders are located within some parts of the building
secure from frost, and are installed by the plumber....

Stacks And Branches
Definitions Soil stacks are those that receive the discharge from water closets and urinals, although they may also receive the discharge from other
fixtures. They connect with the house drain in the...

Examples of Installation

There are two systems of stacks and branches in use at the present time, the two­pipe system and the single­pipe system. In the two­pipe system
siphon traps are used, and their seals are protected fro...

Example Of One­Pipe System
This illustration, Fig. 23, should be compared with the illustration of a two­pipe system, Fig. 18. In the one­pipe system non­siphon traps are used
without vent pipes. This method of piping reduces t...

Outlets To Stacks Above Roof
In cold climates vent stacks should be increased in size where they pass through the roof. If they are less than 4 inches in diameter they should be
increased to 4 inches; and if they are 4 inches or ...

Roof Flashings

Where vent stacks pass through a roof the openings around the pipes should be made perfectly storm­tight, by flashings of sheet lead or copper. A
good method of flashing for use in most climates is sh...

Size Of Soil And Waste Pipes
Soil and waste pipes should always be the full size of the waste outlets from fixtures. The outlets should be sufficiently large to permit the fixtures
being emptied quickly so as to thoroughly flush ...

Supports For Stacks
Soil and waste stacks should be firmly supported at their base by a brick pier or iron pipe rest placed directly under the stack. If the house drain is
suspended from the ceiling beams, a strong iron ...

Fixture Traps

Siphon Traps Traps are fittings used to prevent the passage of air or gas through a pipe without materially affecting the flow of sewage. To
successfully perform the functions for which they are inte...

Self­Siphonage Of Traps
A trap can lose its seal from self­siphonage only when the waste pipe from the trap to the stack is unventilated and extends below the bottom level
of the dip a of the trap so as to form the long leg ...

Trap Ventilation

http://chestofbooks.com/home­improvement/construction/plumbing/Principle­Practice/index.html 2/11

You might also like