Professional Documents
Culture Documents
Relugan GT 50 Low Methanol
Relugan GT 50 Low Methanol
2. Hazards Identification
Emergency overview
CAUTION:
Toxic by inhalation, in contact with skin and if swallowed.
Causes burns.
May cause sensitization by inhalation.
Wear protective clothing.
Wear full face shield if splashing hazard exists.
Avoid inhalation of mists/vapours.
Wear a NIOSH-certified (or equivalent) acid gas/organic vapour respirator.
Ensure adequate ventilation.
Acute toxicity:
Of high toxicity after short-term inhalation. Of high toxicity after single ingestion. Of low toxicity after short-term
skin contact.
Irritation / corrosion:
Corrosive! Damages skin and eyes.
Safety Data Sheet
Relugan® GT 50 low Methanol content
Revision date : 2011/06/01 Page: 2/9
Version: 1.0 (30045852/SDS_LEA_US/EN)
Assessment other acute effects:
Based on the available information there is no specific target organ toxicity to be expected after a single
exposure.
Sensitization:
Sensitization after skin contact possible. The substance may cause sensitization of the respiratory tract.
Chronic toxicity:
Carcinogenicity: In long-term animal studies in which the substance was given in the drinking water in high
concentrations, a carcinogenic effect was not observed. In long-term animal studies in which the substance was
given by inhalation, a carcinogenic effect was not observed.
Repeated dose toxicity: After repeated exposure the prominent effect is local irritation. The substance may
cause damage to the upper respiratory tract even after repeated inhalation, as shown in animal studies.
Reproductive toxicity: The results of animal studies gave no indication of a fertility impairing effect.
Teratogenicity: No indications of a developmental toxic / teratogenic effect were seen in animal studies.
Genotoxicity: The substance was mutagenic in various test systems with bacterias and cell cultures; however,
these results could not be confirmed in tests with mammals.
Aquatic toxicity:
The product has not been tested. The data have been deduced from values for a preparation or mixture with a
lower substance concentration.
4. First-Aid Measures
General advice:
Immediately remove contaminated clothing. If the patient is likely to become unconscious, place and transport in
stable sideways position (recovery position). First aid personnel should pay attention to their own safety.
If inhaled:
Remove the affected individual into fresh air and keep the person calm. Assist in breathing if necessary.
Immediate medical attention required.
If on skin:
Wash affected areas with water while removing contaminated clothing. Seek medical attention.
Safety Data Sheet
Relugan® GT 50 low Methanol content
Revision date : 2011/06/01 Page: 3/9
Version: 1.0 (30045852/SDS_LEA_US/EN)
If in eyes:
In case of contact with the eyes, rinse immediately for at least 15 minutes with plenty of water. Immediate
medical attention required.
If swallowed:
Rinse mouth and then drink plenty of water. Do not induce vomiting. Never induce vomiting or give anything by
mouth if the victim is unconscious or having convulsions. Immediate medical attention required.
Note to physician
Treatment: Treat according to symptoms (decontamination, vital functions), no known
specific antidote. Pulmonary odema prophylaxis. Medical monitoring for at least
24 hours.
5. Fire-Fighting Measures
Flash point: 95 °C (50 %(m)) (closed cup) No flash point -
Measurement made up to the indicated
temperature, pilot light extinguishes.
Autoignition: 395 °C (50 %(m)) (Directive 92/69/EEC, A.15)
Lower explosion limit: 1.5 %(V) Product not examined: Value is calculated
from the data of the components.
Upper explosion limit: 50 %(V) Product not examined: Value is calculated
from the data of the components.
Flammability: does not ignite
Self-ignition temperature: (other) not self-igniting
Further information:
Dispose of fire debris and contaminated extinguishing water in accordance with official regulations.
Impact Sensitivity:
Impact Weight: 10 kg
Height of Fall: 0.4 m
Method: Explosive properties
Environmental precautions:
Do not discharge into drains/surface waters/groundwater.
Cleanup:
Spills should be contained, solidified, and placed in suitable containers for disposal.
Safety Data Sheet
Relugan® GT 50 low Methanol content
Revision date : 2011/06/01 Page: 4/9
Version: 1.0 (30045852/SDS_LEA_US/EN)
7. Handling and Storage
Handling
General advice:
Ensure thorough ventilation of stores and work areas. Avoid aerosol formation.
Storage
General advice:
Keep container tightly closed in a cool, well-ventilated place.
Hand protection:
Chemical resistant protective gloves
Eye protection:
Tightly fitting safety goggles (chemical goggles). Wear face shield if splashing hazard exists.
Body protection:
Body protection must be chosen depending on activity and possible exposure, e.g. apron, protecting boots,
chemical-protection suit (according to EN 14605 in case of splashes or EN ISO 13982 in case of dust).
Conditions to avoid:
Avoid all sources of ignition: heat, sparks, open flame. See MSDS section 7 - Handling and storage.
Substances to avoid:
acids, bases
Hazardous reactions:
The product is chemically stable.
Decomposition products:
Thermal decomposition products: carbon monoxide, carbon dioxide
Thermal decomposition:
< 110 °C
No exothermic decomposition within the mentioned temperature range. No decomposition if used as directed. It
is not a self-decompositionable substance.
Corrosion to metals:
Corrosive effect on metals.
Oxidizing properties:
Based on its structural properties the product is not classified as oxidizing.
Acute toxicity
Oral:
Type of value: LD50
Species: rat (male/female)
Value: approx. 158 mg/kg (OECD Guideline 401)
Inhalation:
Type of value: LC50
Species: rat (male/female)
Value: 0.48 mg/l (OECD Guideline 403)
Exposure time: 4 h
An aerosol was tested.
Dermal:
Type of value: LD50
Species: rat (male/female)
Value: > 2,000 mg/kg (OECD Guideline 402)
The data refer to a diluted watery solution of the substance.
Irritation / corrosion
Skin:
Species: rabbit
Result: Corrosive.
Method: OECD Guideline 404
The data refer to a diluted watery solution of the substance.
Safety Data Sheet
Relugan® GT 50 low Methanol content
Revision date : 2011/06/01 Page: 6/9
Version: 1.0 (30045852/SDS_LEA_US/EN)
Eye:
Species: rabbit
Result: Risk of serious damage to eyes.
Method: Draize test
The data refer to a diluted watery solution of the substance.
Sensitization:
Open epicutaneous test (OET)
Species: guinea pig
Result: sensitizing
The data refer to a diluted watery solution of the substance.
Other Information:
Acute:
Fish test acute static
Cyprinodon variegatus/LC50 (96 h): 39 mg/l
The details of the toxic effect relate to the nominal concentration.
Fish test acute static
Lepomis macrochirus/LC50 (96 h): 9.4 mg/l
The details of the toxic effect relate to the nominal concentration.
Chronic:
See user defined text. Flow through.
Oncorhynchus mykiss /NOEC (97 d): 1.6 mg/l
The details of the toxic effect relate to the nominal concentration.
Aquatic invertebrates
Acute:
Daphnia test acute static
Daphnia magna/EC50 (48 h): 5.75 mg/l
The details of the toxic effect relate to the nominal concentration.
Chronic:
OECD Guideline 202, part 2 semistatic Daphnia magna (NOEC) 21 d 2.5 mg/l
The statement of the toxic effect relates to the analytically determined concentration.
Aquatic plants
Microorganisms
Toxicity to microorganisms:
OECD Guideline 209 aerobic
activated sludge, domestic/EC20 (30 min): approx. 15 mg/l
The details of the toxic effect relate to the nominal concentration.
Non-Mammals
Plant
Degradability / Persistence
Biological / Abiological Degradation
Test method: OECD 301 A (new version) (aerobic), activated sludge, domestic
Method of analysis: DOC reduction
Degree of elimination: 90 - 100 % (28 d)
Evaluation: Readily biodegradable (according to OECD criteria).
Readily biodegradable (according to OECD criteria).
Hydrolysis
Test method: Directive 92/69/EEC, C.7 (abiotic)
pH7
Half-life: > 1 a (50 °C)
In contact with water the substance will hydrolyse slowly.
Bioaccumulation
Because of the n-octanol/water distribution coefficient (log Pow) accumulation in organisms is not to be
expected.
Environmental mobility:
Transport between environmental compartments:
other adsorption/water - soil
log KOC: 0.76
Container disposal:
Dispose of in a licensed facility. Recommend crushing, puncturing or other means to prevent unauthorized use
of used containers.
RCRA: D002
Safety Data Sheet
Relugan® GT 50 low Methanol content
Revision date : 2011/06/01 Page: 8/9
Version: 1.0 (30045852/SDS_LEA_US/EN)
Land transport
USDOT
Hazard class: 8
Packing group: II
ID number: UN 2922
Hazard label: 8, 6.1, EHSM
Proper shipping name: CORROSIVE LIQUID, TOXIC, N.O.S. (contains GLUTARALDEHYDE)
Sea transport
IMDG
Hazard class: 8
Packing group: II
ID number: UN 2922
Hazard label: 8, 6.1, EHSM
Marine pollutant: YES
Proper shipping name: CORROSIVE LIQUID, TOXIC, N.O.S. (contains GLUTARALDEHYDE)
Air transport
IATA/ICAO
Hazard class: 8
Packing group: II
ID number: UN 2922
Hazard label: 8, 6.1
Proper shipping name: CORROSIVE LIQUID, TOXIC, N.O.S. (contains GLUTARALDEHYDE)
Federal Regulations
Registration status:
Chemical TSCA, US released / listed
OSHA hazard category: Acute target organ effects reported; Toxic - oral; Highly toxic - inhalation
State regulations
NFPA and HMIS use a numbering scale ranging from 0 to 4 to indicate the degree of hazard. A value of zero means that the
substance possesses essentially no hazard; a rating of four indicates extreme danger. Although similar, the two rating
systems are intended for different purposes, and use different criteria. The NFPA system was developed to provide an
on-the-spot alert to the hazards of a material, and their severity, to emergency responders. The HMIS system was designed
to communicate workplace hazard information to employees who handle hazardous chemicals.
We support worldwide Responsible Care® initiatives. We value the health and safety of our employees,
customers, suppliers and neighbors, and the protection of the environment. Our commitment to Responsible
Care is integral to conducting our business and operating our facilities in a safe and environmentally responsible
fashion, supporting our customers and suppliers in ensuring the safe and environmentally sound handling of our
products, and minimizing the impact of our operations on society and the environment during production,
storage, transport, use and disposal of our products.