Professional Documents
Culture Documents
JEE ADVANCED-Assignment: Presented by Kailash Sharma
JEE ADVANCED-Assignment: Presented by Kailash Sharma
1. Three small spheres A, B and C of masses 1 kg, 2 kg and 3 kg are rotating with a circular disc with
angular velocity 3 radian/ sec and are connected with strings to O as shown in figure. Coefficient of
friction between spheres A, B, C and disc is 0.4, 0.3 and 0.2 respectively.
2. A wedge of height ‘h’ is released from rest with a light particle P placed on it as shown. The wedge
slides down an incline which makes an angle θ with the horizontal. All the surfaces are smooth, P
will reach the surface of the incline in time:
2h 2h 2h 2h
(A) (B) (C) (D)
g sin 2 θ gsin θ cosθ g tan θ g cos 2 θ
F F 2F 4F
(A) (B) (C) (D)
mg 3mg 3mg 3mg
KAILASH SHARMA (REF-KAILASH10) 2|Page
4. A particle is moving with tangential acceleration argon a circle of radius R in such a way that at any
instant the magnitude of centripetal and tangential acceleration are equal. If at t = 0 the speed was
‘v0’, then the time to complete the first revolution is-
R R R R −2π
(A) (B) (1 + e−2π ) (C) (1 − e−2π ) (D) (e )
v0 v0 v0 v0
5. Two blocks of mass m and 2m are kept on a smooth horizontal surface. They are connected by an
ideal spring of force constant k. Initially the spring is unstretched. A constant force is applied to the
heavier block in the direction shown in figure. Suppose at time t displacement of smaller block is x,
then displacement of the heavier block at this moment would be
x Ft 2 x x Ft 2 x
(A) (B) + (C) (D) −
2 6m 3 3 4m 2
6. An L shaped rod of mass M is free to rotate in a vertical plane about the axis AA’. It is released from
the position shown in the figure. The maximum angular acceleration of the rod during motion is
3g 9g 9g 6g
(A) (B) (C) (D)
10 l 10 l 5l 5 2l
7. A thick walled hollow sphere has outer radius R. It rolls down an incline without slipping and its
speed at bottom is v0. Now the incline is waxed so that the friction is absent. The sphere is observed
5v0
to slide down without rolling and the speed is now . The radius gyration of the hollow sphere
4
about the axis through its centre is
3 3 2
(A) R (B) R (C) R (D) None of these
4 4 3
Section-B
More than one Correct type Qus from 9 to 12
9. The figure shows a plank of mass M kept on a smooth inclined plane of inclination θ with the
horizontal. A man (mass m) starts running on the rough surface of the plank such that the plank
remains stationary with respect to the ground.
(M + m)g sin θ
(A) The acceleration of the man will be .
m
Mg sin θ
(B) The acceleration of the man will be .
m
(C) The man has to move down the incline to keep the plank stationary.
(D) The man has to move up the incline to keep the plank stationary.
10. A model rocket fired from the ground ascends with a constant upward acceleration. A small bolt is
dropped from the rocket 1.0 s after the firing and fuel of the rocket is finished 4.0 s after the bolt is
dropped. Air-time of the both is 2.0 s. Acceleration of free fall is 10 m/s2. Which of the following
statement is/are correct ?
(A) Acceleration of the rocket while ascending on its fuel is 8.0 m/s2.
(B) Fuel of the rocket was finished at a height 100 m above the ground.
(C) Maximum speed of the rocket during its upward flight is 40 m/s
(D) Total air – time of the rocket is 15 s.
12. The figure shows the velocity as a function of time for an object with mass 10 kg being pushed along
a frictionless surface by external force. At t = 3s, the force stops pushing and the object moves freely.
It then collides head-on and sticks to another object of mass 25 kg.
13. If the lower block is held fixed and force is applied to P, minimum force required to slide P on Q is
12N. Now if Q is free to move on frictionless surface and force is applied to Q then the minimum
force F required to slide P on Q is ____________.
14. At a particular instant, a particle moving with a constant velocity is approaching a fixed point with a
velocity u = 3 m/s and after a time interval Δt = 6s the particle passes the position closest to the fixed
point with a velocity v = 5 m/s. Find the closest distance between the fixed point and the particle.
15. Two blocks of masses m1 and m2 connected by a light spring of stiffness k, are kept on a smooth
horizontal surface as shown in the figure. What should be the initial compression (in cm) of the spring
so that the system will be about to break off the surface, after releasing the block m1?
(If m1 = 2kg, m2 = 1 kg, k = 10 N/cm)