Professional Documents
Culture Documents
Quiz 6
Quiz 6
Quiz 6
se
INSTRUCTION: Select the correct answer for each of the following questions. Mark only one answer for each item by shading the
box corresponding the letter of your choice on the answer sheet provided. STRICTLY NO ERASURES ALLOWED. Use pencil no. 2
only.
SEC Situation 3 – For the welded connection shown below, the welded plate
is 20 mm thick. The welds applied are 8 mm thick with Fu = 485
1. Determine the maximum torque (N-m) that can be applied to a MPa (Fvw = 0.3Fu). Using SMAW weld process (te = 0.707w) unless
hallow circular steel shaft of 100 mm outside diameter and 70 mm otherwise noted, determine the following.
inside diameter without exceeding a shearing stress of 60×106 N/m2 9. The capacity of the connection based on weld shear in kN.
or a twist of 0.5 degree/m. Use G = 83×109 N/m2 A. 250 B. 249 C. 246 D. 247
A. 5304 B. 5034 C. 5043 D. 5403 10. If the applied P is 370 kN, by how much should each side length be
increased in mm?
2. A flanged bolt coupling consists of eight steel 20 mm diameter bolts A. 69 B. 63 C. 75 D. 79
spaced evenly around a bolt circle 300 mm in diameter. Determine 11. If the applied P is 420 kN and the length is limited to 130 mm on
the torque (N-m) capacity of the coupling if the allowable shearing each side, how thick should the welds be if SAW weld process is
stress in the bolts is 40 MN/m2. used (te = w if w ≤ 10 mm, te = 0.707 w + 3 mm if w > 10 mm).
A. 1.580 B. 15,080 C. 15,800 D. 1.508 A. 8 B. 10 C. 12 D. 11
A C
B
A B