Professional Documents
Culture Documents
Jetter Nano Series PLC Delta A. Hmi Factory Settings: Appendix B Communication - Scredit Software User Manual
Jetter Nano Series PLC Delta A. Hmi Factory Settings: Appendix B Communication - Scredit Software User Manual
Controller station number: 0. (no PLC station number in protocol, therefore, only 1(HMI) to 1 (PLC)
communication is allowed.)
NOTE
1) Please notice that no PLC station number in protocol, therefore, only 1(HMI) to 1 (PLC) communication
is allowed.
3) In general, each register occupies max. 24 Bits. However, some registers occupies 8 Bits only.
4) Because the initial time of this controller is longer, it is recommended to set HMI startup delay time
(Recommended time is 10 seconds).
5) When the register R is used for Double Word device, please set its format as signed format. (The default
format in Screen Editor is signed format)
Registers
Only the first 24 bits are used for Rn registers, the highest 8 bits (Bit 24 ~ 31) are set to 0 by default setting.
(24-bit Integer : If in decimal format, the range is -8388608 ~ +8388607. If in hexadecimal format, the range
is 0x000000 ~ 0xFFFFFF.)
NOTE
y When using devices that the data length is in Word, only Bit 0 ~ 15 are valid for both of WRn and
Rn registers.
y When using devices that the data length is in Double Word,
if the read/write address format is set to WRn, the Bit 0 ~ 15 of WRn register is the low word of a
read/write value, the Bit 0 ~ 15 of WRn+1 register is the high word of a read/write value.
if the read/write address format is set to Rn, only Bit 0 ~ 23 are valid for Rn registers.
(Notice: As the Jetter controller is a 24-bit format controller, the valid setting range is 24 Bits.
If exceeds this range, HMI will stop read/write operation and show “…..Value is Incorrect”
on the screen. So, please do not set any bit on Bit24 ~ Bit31 (Bit24 ~ Bit31 cannot be written).
y When using devices that the data length is in m Words,
if the read/write address format is set to WRn, the Bit 0 ~ 15 of WRn register is the lowest word of a
read/write value and the Bit 0 ~ 15 of WRn+m-1 register is the highest word of a read/write value.
if the read/write address format is set to Rn, the Bit 0 ~ 23 of Rn register is the lowest word of a
read/write value and the Bit 0 ~ 23 of Rn+1 register is the highest word of a read/write value.
Each register is regards as a “Double Word”. The value of Bit24 ~ Bit31 is 0.
Contacts
Read/Write Range
Contact type Format
Word No. Bit No.
Input Relay Inbb n: 1 ~ 32 bb: 01 ~ 08
Output Relay Onbb n: 1 ~ 32 bb: 01 ~ 08
Flag Relay Fn N/A n: 0 ~ 32767
RS-232
¾ The pin definition of the cable of Jetter controller is different than the general cable. Please pay close
attention on it and do not mistake.