Download as pdf or txt
Download as pdf or txt
You are on page 1of 16

Cashline™ / e-motion™

Suzo STC Hopper

Rev. 2.0
www.atronic.com
September 2003
RELEASE INFO

Suzo STC Hopper

Cashline™ / e-motion™
Suzo STC Hopper

Rev. 2.0

Rel. September 2003

© 1999 - 2005 Atronic. All rights reserved.


September 2003 2
INTRODUCTION

SUZO STC Hopper

This section describes how to adjust and test the


Suzo STC Hopper of a Atronic Cashline or e-motion
machine.

Suzo STC Hopper


SUZO Hopper
with extended
cup (Cashline)

SUZO Hopper
with Jumbo cup
(e-motion)
Note: Never use oil, grease or
any other lubricant in the coin
handling area.

Note: After service or repair,


the Hopper should be
thoroughly checked in the
Hopper out test routine of the
machine.

Technical specifications

• Suitable for coins or tokens from 18mm - 40mm


• Counts approx. 450 coins (US 0.25c) per minute
• Capacity of 1000 coins (US 0.25c) - standard cup
• Capacity of 1600 coins (US 0.25c) - extended cup
• Capacity of 2100 coins (US 0.25c) - Jumbo cup
• Operating voltage: 24 V DC

September 2003 Hopper_Suzo_STC_rev_2-00.pdf 3


OPERATING PROCEDURES

Hopper removal Warning:


The hopper may be heavy!

Procedure for Cashline

1. Open the main door.


2. Switch off the machine.
3. Remove the coin bowl assy.
4. Grip the Hopper handle with the left hand and with
the thumb pointing downwards, press the Hopper
securing clip and slide the Hopper outwards.

Procedure for e-motion

Suzo STC Hopper


1. Unlock and open the main door.
2. Switch off the machine.
3. Close the main door.
4. Unlock the Hopper Drawer and slide it to the
left.Then pull out the Hopper drawer.
5. Lift the coin bowl retaining lever on the right side
of the Hopper drawer (a).
6. Hold the coin bowl to prevent it from falling open
and release the coin bowl retaining lever on the
left side of the Hopper drawer (b).
7. Gently lower the coin bowl until it stops (c).
8. Slide the Hopper out of the Hopper support guide.

Note: If the (optional) Lock Ang-


le (1) is used it is not possible
to pull out the hopper drawer
without opening the Main Door!

September 2003 4
OPERATING PROCEDURES

High level sensor adjustment

The coin bowl of the Suzo Hopper is spring mounted.


The weight of the coins determines at which point
the level switch is activated.

Suzo STC Hopper


Adjusting the high level sensor

1. Fill the bowl with the appropriate amount of coins.

2. Move down the tension clip.

3. Slowly turn the adjustment screw clockwise until


the level switch is activated in the down position.

4. Fasten the lock nut.

5. Move tension clip back to the adjustment screw.

For a wider adjustment range, adjust the tension of


the coin bowl's spring mount by loosen or tighten
the set screw.

September 2003 5
OPERATING PROCEDURES

Hopper switches test

Testing the coin switch and the highlevel switch can


be done in the service menu.

push

pull

Suzo STC Hopper


Operating the switches by hand.

1. Enter "Service menu".


(Open maindoor and press Service button).

2. Enter switch test menu.

• For e-motion:
Select "Other tests / Switch".

• For Cashline:
Select "Selftest / Switch test".

4. The current status of the switches can be seen on


the monitor.

5. Operating the switches by hand should change the


status on the monitor.

September 2003 6
OPERATING PROCEDURES

Coin switch adjustment

The coin switch (or count switch) is activated by the


paid out coins and sends the switching operation to
the Masterboard.

Suzo STC Hopper


Note: Always perform a
Hopper out test after adjusting
the Hopper coin switch to avoid
wrong payouts.
Adjusting the coin switch

1. When the roller is in the neutral position (no coin


touching the roller), the coin switch should be open.

2. Place a coin on the pin wheel underneath the roller.


The count switch should close when the roller mo-
ves upwards.

3. Move the coin to the coin out channel. The switch


should close again as the coin leaves the roller.

September 2003 7
OPERATING PROCEDURES

Hopper out test routine

With the Hopper out test routine the proper adjust-


ment of the coin switch can be tested.

Suzo STC Hopper


The Hopper out menu for e-motion (left) and Cashline (right)

1. Enter "Service menu".

2. Run "Hopper out" test.

• For e-motion:
Select "Diagnostics / Hopper / Hopper 1 and run
the "Hopper out" test (default 10 coins).

• For Cashline:
Select "Hopper out 1" and run the "Hopper out"
test (default 5 coins) by pressing the middle lit
button for 4 sec.

3. Make sure the exact number of coins are paid out.

4. Run the Hopper switch test.


For Cashline: Press the left lit button for 4 sec.
The Hopper will perform a coin out routine.

5. The switching period values (in msec) will be dis-


played. If any of the values is below 12 msec the
count switch has to be readjusted.

September 2003 8
OPERATING PROCEDURES

Coin wiper adjustment

The coin wiper singles out the coins to prevent coin


jamming.

Suzo STC Hopper


Note: The wiper should guide
and not hold the coin.

Adjusting the coin wiper

1. Lay a coin beneath the wiper.

2. Loosen both screws and adjust the wiper so that


it is lightly brushing the surface of the coin.

3. Tighten alternately both screws checking that the


alignment is still correct.

September 2003 9
OPERATING PROCEDURES

Hopper knife adjustment

The front surface of the Hopper knife should be flush


to the pin wheel and lay gently on the shelf wheel.

Suzo STC Hopper


Note: Do not use oil or grease
in the coin handling area.
Adjusting the hopper knife

1. Loosen the 2 mounting screws.

2. Correct the alignment of the knife. The front sur-


face of the Hopper knife should be flush to the pin
wheel and lay gently on the shelf wheel.

3. Fasten the 2 mounting srews.

4. Check that the alignment of the knife is still cor-


rect.

September 2003 10
SPARE PARTS

Suzo STC Hopper with standard cup

Suzo STC Hopper

September 2003 11
SPARE PARTS

Parts list - Suzo STC Hopper with standard cup

POS Part-No* Nomenclature POS Part-No Nomenclature


1 140-020-220 M4x20 screw Phill. pan hd yello 33 see list H M5 screw
2 1040-050 M4 nut yellow zinc 34 14-0365 spring
3 5070-181 7mm E-washer 35 150-010-223-7 M6x10 screw ph hd 13mm flange
4 14-0455-1 rock and roller assy 36 1050-242 M5 plate nut DIN6923
5 see List A spring rocker and roller 37 see list I hopper liner
6 14-0411 dowel pin with flange 38 14-0350 spring
7 14-0400 pivot rod 39 14-0700 coin cup for hopper
8 5040-191 4mm E-wascher 40 14-0080 inlet slide
9 150-012-700-1 M5x12 tensilock bolt yellow 41 14-0335 spring
10 14-0070 wiper 42 14-0440 mount
11 150-010-120 M5x10 screw Phill. pan hd yellow 43 1051-040 M5 ext. star lockwasher yellow

Suzo STC Hopper


12 1055-160 M5 woodwasher 5.5x18x2 yellow 44 150-025-220 M5x25 screw Phill. pan hd yellow
13 14-0416 bearing pin 45 22-0715 microswitch w. arm Cherry E1300H
14 14-0590 bearing 6x19x6mm 46 250-008-700-7 M5x8 bolt hex hd tapt flange yellow
15 150-012-420 M5x12 screw Phill. flat hd yellow 47 14-0025 right side mount
16 see list B Hopper motor 48 14-0035 pivod bracket
17 14-0560-1 wheel housing 49 235-020-220 M3.5x20 Phd. cross bolt tapt yellow
18 150-025-700 M5x25 bolt hex yellow 50 14-0015 leftside mounting bracket
19 1050-050 M5 nut hex yellow 51 240-008-700-7 M4x8 bolt hex hd tapt flande yellow
20 140-008-420 M4x8 screw Phill. flat hd yellow 52 14-0050-37 handle 37mm
21 14-0095 coin deflector 53 230-016-220 M3x16 screw Phill. pn hd tapt yellow
22 199-025-040 M10x25 screw hex hd imbus yellow 54 1042-140 M4 washer 4.2x20x1.2 yellow
23 see list C hopper knife 55 14-0005 platform bracket
24 see list D outlet cover 56 14-0155 spring plate
25 150-016-700-1 M5x16 tensilock bolt yellow 57 22-0731-2 microswitch Cherry 6.3mm
26 14-0110 driving hub 58 14-0045 spring mount
27 see list E pin wheel 59 14-0330 hopper spring
28 14-0140 spring liner
29 see list F shelf wheel *All part numbers are Suzo part numbers
30 14-0570 agitator
31 14-0435 mounting bushes
32 see list G metal star support wheel

MIN MAX List A List B List C List D List E List F List G List H List I
mm mm Spring Hopper motor Hopper Outlet Pinwheel Shelfwheel M.S.S. M5 screw Hopper liner
R & Roller knife cover wheel

18.0 18.9 14-0370 14-0654-1310 14-0290 14-0065 14-0116 14-0130-1505 N.A. 150-020-931 N.A.
19.0 20.0 14-0370 14-0654-1310 14-0280 14-0065 14-0116 14-0130-1465 N.A. 150-020-931 N.A.
20.1 22.0 14-0370 14-0654-1310 14-0280 14-0065 14-0116 14-0130-1425 N.A. 150-020-931 N.A.
22.1 24.8 14-0370 14-0654-1310 14-0280 14-0065 14-0115 14-0130-1370 N.A. 150-020-931 N.A.
24.9 25.8 14-0370 14-0654-1310 14-0280 14-0065 14-0115 14-0130-1350 N.A. 150-020-931 N.A.
25.9 27.8 14-0370 14-0654-1310 14-0280 14-0065 14-0115 14-0130-1310 N.A. 150-020-931 N.A.
27.9 31.0 14-0370 14-0654-1310 14-0280 14-0066 14-0115 14-0130-1235 N.A. 150-020-931 14-0145
31.1 31.9 14-0370 14-0654-1310 14-0280 14-0066 14-0112 14-0130-1235 N.A. 150-020-931 14-0145
32.0 33.0 14-0370 14-0654-1310 14-0280 14-0066 14-0112 14-0130-1205 N.A. 150-020-931 14-0145
33.1 35.0 14-0340 14-0654-1230 14-0295 14-0067 14-0112 14-0130-1165 14-0580 150-025-522 14-0145
35.1 36.9 14-0340 14-0654-1230 14-0295 14-0067 14-0112 14-0130-1125 14-0580 150-025-522 14-0145
37.0 38.0 14-0340 14-0654-1230 14-0295 14-0067 14-0112 14-0130-1075 14-0580 150-025-522 14-0145

September 2003 12
SPARE PARTS

Suzo STC Hopper with extended cup

Suzo STC Hopper

September 2003 13
SPARE PARTS

Part list - SUZO STC Hopper with extended cup


POS Part-No* Nomenclature POS Part-No Nomenclature
1 140-020-220 M4x20 screw Phill. pan hd yello 33 see list H M5 screw
2 1040-050 M4 nut yellow zinc 34 14-0365 spring
3 5070-181 7mm E-washer 35 150-010-223-7 M6x10 screw ph hd 13mm flange
4 14-0455-1 rock and roller assy 36 see list I hopper liner
5 see List A spring rocker and roller 37 14-0090 coin baffle with bend
6 14-0411 dowel pin with flange 38 1050-242 M5 tensilock nut
7 14-0400 pivot rod 39 14-0345 extension spring
8 5040-191 4mm E-wascher 40 14-0085 coin baffle
9 150-012-700-1 M5x12 tensilock bolt yellow 41 14-0880 scoop extender USD 1,=large
10 14-0070 wiper 42 14-0720 Hopper cup 2 pcs. standard
11 150-010-120 M5x10 screw Phill. pan hd yellow 43 14-0440 mount
12 1055-160 M5 woodwasher 5.5x18x2 yellow 44 1051-040 M5 ext. star lockwasher yellow

Suzo STC Hopper


13 14-0416 bearing pin 45 150-025-220 M5x25 screw Phill. pan hd yellow
14 14-0590 bearing 6x19x6mm 46 150-012-120 M5x12 screw Phill. pan hd yellow
15 150-012-420 M5x12 screw Phill. flat hd yellow 47 150-12-420 M5x12 screw Phill. flat hd yellow
16 see list B Hopper motor 48 14-0335 spring
17 14-0560-1 wheel housing 49 14-0075 scoop support bracket
18 150-025-700 M5x25 bolt hex yellow 50 14-0035 pivot bracket
19 1050-050 M5 nut hex yellow 51 14-0025 right side mount
20 140-008-420 M4x8 screw Phill. flat hd yellow 52 250-008-700-7 M5x8 bolt hex hd tapt flange yellow
21 14-0095 coin deflector 53 22-0715 microswitch w. arm Cherry E1300H
22 199-025-040 M10x25 screw hex hd imbus yellow 54 235-020-220 M3,5x20 screw Phill. pan hd tapt
23 see list C hopper knife 55 14-0015 leftside mounting bracket
24 see list D outlet cover 56 240-008-700-7 M4x8 bolt hex hd tapt flande yellow
25 150-016-700-1 M5x16 tensilock bolt yellow 57 14-0050-37 handle 37mm
26 14-0110 driving hub 58 230-016-220 M3x16 screw Phill. pn hd tapt yellow
27 see list E pin wheel 59 1042-140 M4 washer 4.2x20x1.2 yellow
28 14-0140 spring liner 60 14-0005 platform bracket
29 see list F shelf wheel 61 14-0155 spring plate
30 14-0570 agitator 62 22-0731-2 microswitch Cherry 6.3mm
31 14-0435 mounting bushes 63 14-0045 spring mount
32 see list G metal star support wheel 64 14-0355 compression spring
*All part numbers are Suzo part numbers

MIN MAX List A List B List C List D List E List F List G List H List I
mm mm Spring Hopper motor Hopper Outlet Pinwheel Shelfwheel M.S.S. M5 screw Hopper liner
R & Roller knife cover wheel

18.0 18.9 14-0370 14-0654-1310 14-0290 14-0065 14-0116 14-0130-1505 N.A. 150-020-931 N.A.
19.0 20.0 14-0370 14-0654-1310 14-0280 14-0065 14-0116 14-0130-1465 N.A. 150-020-931 N.A.
20.1 22.0 14-0370 14-0654-1310 14-0280 14-0065 14-0116 14-0130-1425 N.A. 150-020-931 N.A.
22.1 24.8 14-0370 14-0654-1310 14-0280 14-0065 14-0115 14-0130-1370 N.A. 150-020-931 N.A.
24.9 25.8 14-0370 14-0654-1310 14-0280 14-0065 14-0115 14-0130-1350 N.A. 150-020-931 N.A.
25.9 27.8 14-0370 14-0654-1310 14-0280 14-0065 14-0115 14-0130-1310 N.A. 150-020-931 N.A.
27.9 31.0 14-0370 14-0654-1310 14-0280 14-0066 14-0115 14-0130-1235 N.A. 150-020-931 14-0145
31.1 31.9 14-0370 14-0654-1310 14-0280 14-0066 14-0112 14-0130-1235 N.A. 150-020-931 14-0145
32.0 33.0 14-0370 14-0654-1310 14-0280 14-0066 14-0112 14-0130-1205 N.A. 150-020-931 14-0145
33.1 35.0 14-0340 14-0654-1230 14-0295 14-0067 14-0112 14-0130-1165 14-0580 150-025-522 14-0145
35.1 36.9 14-0340 14-0654-1230 14-0295 14-0067 14-0112 14-0130-1125 14-0580 150-025-522 14-0145
37.0 38.0 14-0340 14-0654-1230 14-0295 14-0067 14-0112 14-0130-1075 14-0580 150-025-522 14-0145

September 2003 14
SPARE PARTS

SUZO STC Hopper with Jumbo cup

Suzo STC Hopper

September 2003 15
SPARE PARTS

Part list - SUZO STC Hopper with Jumbo cup


POS Part-No* Nomenclature POS Part-No Nomenclature
1 5070-181 7mm e-washer 35 14-0350 spring
2 14-0455-1 rock and roller assy 36 14-0720-4 Hoppercup
3 see List A spring rocker and roller 37 14-0335 spring
4 14-0411 dowel pin with flange 38 14-0440 mount
5 14-0400 pivot rod 39 1051-040 M5 ext. star lockwasher yellow
6 5040-191 4mm e-wascher 40 150-025-220 M5x25 screw pan hd yellow
7 150-012-700-1 M5x12 tensilock bolt yellow 41 see list J Hopper liner
8 14-0070 wiper 42 14-0830 wiper cover plate
9 150-010-120 M5x10 screw pan hd yellow 43 14-0835-1 cover plate narrow (optional)
10 1055-160 M5 woodwasher 5.5x18x2 yellow 44 240-010-700-1 M4x10 bolt hex hd
11 14-0416 bearing pin tapt flange yellow
12 14-0590 bearing 6x19x6mm 45 14-0840 coin regulator plate
13 150-012-420 M5x12 screw flat hd yellow 46 240-008-700-7 M4x8 bolt hex hd tapt flange

Suzo STC Hopper


14 see list B Hopper motor yellow
15 14-0560-1 wheel housing 47 see list K coin baffle
16 150-025-700 M5x25 bolt hex yellow 48 1030-002 M3 washer
17 1050-050 M5 nut hex yellow 49 140-010-420 M4x10 screw flat hd yellow
18 140-008-420 M4x8 screw flat hd yellow 50 14-0730-1 vacuumcup narrow
19 14-0095 coin deflector 51 1040-242 M4 tensilock nut
20 199-025-040 M10x25 screw hex hd imbus 52 14-0077 cup support bracket high frame
yellow 53 230-016-220 M3x16 screw pan hd yellow
21 see list C hopper knife 54 14-0480 hall sensor N/O
22 see list D outlet cover 55 14-0160 sensor bracket
23 150-016-700-1 M5x16 tensilock bolt yellow 56 250-008-700-7 M5x8 bolt hex hd tapt flange
24 14-0110 driving hub 57 14-0015 leftside mounting bracket
25 see list E pin wheel 58 14-0035 pivot bracket
26 14-0140 spring liner 59 14-0025 right side mount
27 see list F shelf wheel 60 14-0050-37 handle 37mm
28 14-0570 agitator 61 22-0731-2 microwitch Cherry 6.3mm
29 14-0435 mounting bushes 62 14-0005 platform bracket
30 see list G metal star support wheel 63 1042-140 M4 washer 4.2x20x1.2 yellow
31 see list H M5 screw 64 14-0155 spring plate
32 14-0365 spring 65 14-0045 spring mount
33 150-010-223-7 M6x10 screw ph hd 13mm flange 66 14-1355 compression spring
34 see list I blindrivet steel 3.2 *All part numbers are Suzo part numbers

MIN MAX List A List B List C List D List E List F List G List H List I List J List K List L
mm mm Spring Hopper motor Hopper Outlet Pinwheel Shelfwheel M.S.S. M5 screw Blindrivet 3.2 Hopper Coin baffle Coin reg.
R & Roller knife cover wheel liner plate

18.0 18.9 14-0375-5 14-0654-1310 14-0290 14-0065 14-0116 14-0130-1505 N.A. 150-020-931 032-010-909 N.A. 14-0845 Low
19.0 20.0 14-0375-5 14-0654-1310 14-0280 14-0065 14-0116 14-0130-1465 N.A. 150-020-931 032-010-909 N.A. 14-0845 Low
20.1 22.0 14-0375-5 14-0654-1310 14-0280 14-0065 14-0116 14-0130-1425 N.A. 150-020-931 032-010-909 N.A. 14-0845 Low
22.1 24.8 14-0375-5 14-0654-1310 14-0280 14-0065 14-0115 14-0130-1370 N.A. 150-020-931 032-010-909 N.A. 14-0845 Low
24.9 25.8 14-0375-5 14-0654-1310 14-0280 14-0065 14-0115 14-0130-1350 N.A. 150-020-931 032-010-909 N.A. 14-0845 Low
25.9 27.8 14-0375-5 14-0654-1310 14-0280 14-0065 14-0115 14-0130-1310 N.A. 150-020-931 032-010-909 N.A. 14-0845 Low
27.9 31.0 14-0375-5 14-0654-1310 14-0280 14-0067 14-0115 14-0130-1235 N.A. 150-020-931 032-012-909 14-0800 14-0850 High
31.1 31.9 14-0375-5 14-0654-1310 14-0280 14-0067 14-0112 14-0130-1235 N.A. 150-020-931 032-012-909 14-0800 14-0850 High
32.0 33.0 14-0375-5 14-0654-1230 14-0280 14-0067 14-0112 14-0130-1205 N.A. 150-020-931 032-012-909 14-0800 14-0850 High
33.1 35.0 14-0375-6 14-0654-1230 14-0295 14-0067 14-0112 14-0130-1165 14-0580 150-025-522 032-012-909 14-0800 14-0855 High
35.1 36.9 14-0375-6 14-0654-1230 14-0295 14-0067 14-0112 14-0130-1125 14-0580 150-025-522 032-012-909 14-0800 14-0855 High
37.0 38.0 14-0375-6 14-0654-1230 14-0295 14-0067 14-0112 14-0130-1075 14-0580 150-025-522 032-012-909 14-0800 14-0855 High

September 2003 16

You might also like