Soil Pipe Connection To Closets

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 1

4/19/2017 Principles 

And Practice Of Plumbing | by John Joseph Cosgrove
Requirements Of A Sanitary Closet To be efficient and sanitary, a water closet should be made of porcelain enameled iron or of porcelain, and must
be absolutely free from working mechanism within the...

Siphon­Jet Closets

The best type of water closet yet designed, is the siphon­jet closet shown in section in Fig. 144. This closet is vitreous, smooth, impervious and
contains a large body of water in a receptacle so sha...

Water Closet Seats
Water closets should never be enclosed with woodwork; all except the very cheapest closets are now made with lugs to which seats can be
attached. When not so constructed, the seat can be fastened to t...

Soil Pipe Connection To Closets
The usual method of fastening water closets to the lead soil pipe is to solder a brass floor flange, Fig. 147, to the lead soil­pipe and then secure the
closet to the floor flange by means of brass bo...

Flush Tanks
Water closets should always be flushed with water from a flush tank, or through a specially constructed flush valve of large area that is supplied with
water through a distributing system separate fro...

Flush Valves
A valve for flushing water closets, urinals or slop sinks is shown in section in Fig. 149. It is known as the Vimometer and is operated in the following
manner: When not in operation the parts are all...

Size Of Pipes For Vimometers
Care must be taken when installing vimometer systems to proportion the pipes so each valve will have an adequate supply of water. No pipe in the
system should be smaller than 1 1/2 inches in diameter,...

Ventilation Of Closet Compartments
Rooms in which water closets are situated should be well ventilated to insure a frequent change of air. This requirement is absolute in large toilet
rooms containing many washout or other non­deodoriz...

Bidets
A bidet, Fig. 151, is a form of sitting bath for use after using the closet, and for the administration of injections and treatment of haemorrhoids. They
are made of porcelain enameled iron, and of po...

Slop Sinks
A slop sink at which to draw water for scrubbing and general cleaning and in which to empty soiled scrubbing water and other slops, should be
provided in every building. In a cottage a slop sink on th...

Hospital Slop Sinks
A hospital slop sink is shown in Fig. 155. The bowl of the sink is shaped like a closet bowl converging toward the outlet which is large and
unobstructed by a strainer. The sink is flushed through a f...

Scullery Fixtures Sinks
Kitchen Sinks Sinks may be divided into two classes, kitchen sinks and pantry sinks. Kitchen sinks are located in the kitchen and are used in the
preparation of meals, washing of dishes and other dut...

Pantry Sinks
Copper Pantry Sinks Pantry sinks are made of copper and of porcelain. They are used chiefly in cleaning silverware, cut glass and china, also for
drawing water for table use. Copper sinks are made in...

Laundry Trays
Laundry Trays, Fig. 157, are used to wash clothes in. There are three tubs in a full set, and when properly installed they are supplied with hot and
cold water and are connected by a waste pipe to the...

Laving Fixtures Lavatories
Sanitary Requirements The principal sanitary requirements of lavatories are a smooth, impervious service, large unobstructed outlet, an overflow
channel accessible for cleaning and no crevices for th...

Decimal Fractions Of A Foot
Measurements expressed in fractions of an inch can be converted into decimal fractions of a foot by the following rule : Rule Multiply the
measurement expressed in fractions of an inch by 1/12, and ...

Decimal Equivalents Of An Inch
Measurements that are expressed in fractions of an inch can be converted into decimal fractions by dividing the numerator by the denominator.
Example What is the decimal equivalent of 1/8 of an inch...

Decimals Of A Square Foot
Measurements taken in square inches can be converted into decimals of a square foot by dividing the number of square inches by 144, which is the
number of square inches contained in a square foot. Ex...

Area Of A Circle

http://chestofbooks.com/home­improvement/construction/plumbing/Principle­Practice/index.html 8/11

You might also like