Professional Documents
Culture Documents
Two Port
Two Port
Two Port
If z-parameters are z11 = 40, z22 = 50 and z12 = z21 = 20, what would be the value of y22 in the matrix f
of y-parameters given below?
a. 4 / 160
b. 5 / 160
c. 10 / 160
d. 15 / 150
ANSWER: 4 / 160
!
2) If the two ports are connected in cascade configuration, then which arithmetic operation should be
performed between the individual transmission parameters in order to determine overall transmission
parameters?
a. Addition
b. Subtraction
c. Multiplication
d. Division
ANSWER: Multiplication
3) Which among the following represents the precise condition of reciprocity for transmission parame
a. AB - CD = 1
b. AD – BC = 1
c. AC – BD = 1
d. None of the above
ANSWER: AD – BC = 1
5) An open circuit reverse voltage gain in h-parameters is a unitless quantity and generally equivalent
to ________
6) How is the short circuit reverse transfer admittance (y12) calculated in terms of current and voltage
7) Which among the below mentioned cases are responsible for generating the oscillations with increa
amplitude in time domain response of system function?
a. A & C
b. B & D
c. B & C
d. A & D
ANSWER: A & C
8) Which oscillations will be generated in the time domain response, if complex conjugate poles are pr
with negative real part?
a. Damped oscillations
b. Undamped oscillations
c. Sustained oscillations
d. None of the above
ANSWER: Damped oscillations
9) For the pole-zero plot given below, what would be the value of system function H(s), if the d.c. gain
system is 20?
a. -2.125 e-1t A
b. -4.125 e-2t A
c. -8 e-4t A
d. -10 e-5t A
ANSWER: -2.125 e-1t A
11) Consider the RC circuit shown below. What will be the value of time constant for RC circuit?
a. 0.25 sec
b. 0.50 sec
c. 1 sec
d. 2 sec
ANSWER: 1 sec
12) What will be the driving point impedance of Laplace domain network shown below?
13) If the value of (P1 / P2) in power ratio expressed in terms of dB is greater than unity,
a. Power loss
b. Power gain
c. Power stability
d. Power saving
14) In accordance to the circuit configuration of bridged 'T' variable attenuator below,
b. Two
c. Three
d. Four
ANSWER: Two
a. Input impedance
b. Output impedance
c. Both a and b
a cascade configuration?
a. Zero
b. Unity
c. Infinity
d. Unpredictable
ANSWER: Zero
a. One-fourth sections
b. Half sections
d. Full sections
18) Suppose that a network consists of purely resistive elements, what will be the value
of propagation constant (generated output) in terms of attenuation constant and phase constant
a. γ = α + j0
b. γ = 0 + jβ
c. γ = 0 – jβ
d. γ = α - j0
ANSWER: γ = α + j0
19) What would be the value of attenuation constant especially for the network consisting
a. 0
b. 1
c. -1
d. Infinity
ANSWER: 0
20) If the value of resonant frequency is 50 kHz in a series RLC circuit along with the bandwidth
a. 5
b. 50
c. 100
d. 500
ANSWER: 50
21) What will be the nature of impedance at a frequency below the antiresonant frequency?
a. Capacitive
b. Inductive
c. Reactive
d. Resistive
ANSWER: Inductive
22) What will be the value of the time required by the response to reach 50% of its steady state
value for second order system?
a. π – θ /ωd
b. π / ωd
c. 4 / ξ ωn
d. (1+ 0.7 ξ) /ωn
23) What would be the nature of roots for undamped type of circuits with sustained oscillations?
a. Purely imaginary
b. Real, equal & negative
c. Complex conjugate with negative real part
d. Real, unequal & negative
24) According to the graph theory of loop analysis, how many equilibrium equations are required
at a minimum level in terms of number of branches (b) and number of nodes (n) in the graph?
a. n-1
b. b+(n-1)
c. b-(n-1)
d. b/ n-1
ANSWER: b-(n-1)
!
25) What would be an order of branch impedance matrix for the below stated KVL equilibrium
Equation on the basis of loop or mesh analysis?
E = B (Vs – Zb Is)
a. b x 1
b. b x b
c. b-n+1) x 1
d. (b-n+1) x b
ANSWER: b x b
a. Subtraction
b. Combination
c. Differentiation
d. Integration
ANSWER: Combination
28) If innumerable branches are present in parallel configuration in a network, which method
approves to be extensively beneficial for network analysis?
a. Node method
b. Mesh method
c. Both a and b
d. None of the above
29) Under which conditions does the source transformation technique remain directly unapplicable?
30) Which among the following is regarded as short circuit forward transfer admittance?
a. y11
b. y12
c. y21
d. y22
ANSWER: y21