Professional Documents
Culture Documents
Fs Cat 5 Cable
Fs Cat 5 Cable
balanced signal
MIC / SIGNAL CABLE LOW PROFILE MIC CABLE
Ideal for long lasting microphone leads or Miniature version of L-2T2S when small size
heavy application, frequent use powered and light weight is a consideration. Useful for
speaker signal leads. 6.0mm diameter patch cables, hidden lapel microphones or any
2-conductor microphone cable. The high balanced audio installation. 4.8mm OD.
density braided copper shield and two inner In Black. Ask for roll pricing.
conductors (composed of 60 thin strands of
copper wire) allow for maximum flexibility and
reduced handling noise. A special compound
PVC outer jacket resists cracking and tears
even in sub-zero environments.
In Black. Ask for roll pricing.
L2T2S - $3.80/M L2E5 - $2.98/M
A PRACTICAL, 100% FOIL SHIELDED MULTICHANNEL AUDIO SNAKE CABLE FOR GENERAL-PURPOSE STUDIO APPLICATIONS. EACH
INDIVIDUALLY ISOLATED CHANNEL CONSISTS OF 2 TWISTED CONDUCTORS UNDER AN EASY-TO-STRIP PVC JACKET EXTRUDED
OVER A FOIL SHIELD AND DRAIN WIRE. THE COLOUR STRIPED PVC CHANNEL JACKETS ALLEVIATE THE NEED TO USE COSTLY SHRINK
TUBING. VERY FLEXIBLE AND A FAVOURITE AT FACTORY SOUND.
multicore
CANARE
MULTICORE CABLE
MR202-2AT - $4.00/M MR202-16AT - $31.00/M
2 Channel 16 Channel
MR202-4AT - $9.00/M MR202-24AT - $40.00/M
4 Channel 24 Channel
MR202-8AT - $16.00/M MR202-32AT - $55.00/M
8 Channel 32 Channel
MR202-12AT - $27.00/M
12 Channel
M149 - $299
121
FACTORY SOUND PHONE (03) 9690 8344 NATIONAL 1800 816 244
FAX (03) 9690 7077 75-85 YORK STREET, SOUTH MELBOURNE, VIC 3205 www.factorysound.com
CABLE
TYCAB 3X32/0.20
power
SPEAKER CABLE
The importance of good (or appropriate) speaker cable Martin Audio suggest that when connecting loudspeaker Conductor CSA Maximum Cable Run
cannot be underestimated. Inadequate cables will, at systems to an amplifier, the return resistance of the cable 4Ω 8Ω
best, make your PA sound somewhat muted and lifeless used is less than one tenth of the nominal impedance
1.0mm2 11m 22m
and, at worst, damage or short out your amplifier. of the system or systems in parallel. The table below
gives an indication of the maximum permissible cable
1.5mm2 17m 34m
It is therefore essential to use speaker cable of sufficient 2.0mm2 22m 44m
gauge (thickness), taking into consideration the length runs for various conductor cross-sectional areas.
2.5mm2 29m 58m
of cable to be used. If the cable is too thin for the Because of its high copper content and relative low 4.0mm2 44m 88m
distance, the resistance will reduce output power and cost, power cable is also popular for speaker cable use.
motion control of the loudspeakers. One measurement To understand more about how to calculate the appro-
standard used for speaker cables is AWG (American priate wire gauge, visit www.factorysound.com and
Wire Gauge). The smaller the AWG, the bigger the wire. click on ‘useful info’.
PROEL HPC-644BK
SPEAKER CABLE
11 gauge 4 conductor speaker cable (4 x
4mm2)
HPC-644BK - $9.99/M
HPC-660BK - $1.69/M
EUROCABLE DMX-2
HYBRID CABLE
2 x balanced audio + 3 x 1.5mm2 power. For
Powered Speaker & DMX applications.
DMX-2 - $12.50/M
HPC-400 - $2.99/M
122 UNLESS OTHERWISE INDICATED, ALL PRICING IN THIS CATALOGUE IS LISTED AT RRP - THAT IS, THE
RECOMMENDED RETAIL PRICE (INCLUDING GST) AS SUGGESTED BY THE RELEVANT IMPORTER / WHOLESALER.
FOR THE MOST CURRENT BULK, TRADE OR SPECIAL PRICING PLEASE CONTACT FACTORY SOUND.
CABLE
TYCAB DPZ81051
special application
CAT 5 CABLE
CAT 5 network cable, for computer network-
ing. New amplifiers and audio processors are
utilising the CAT 5 standard for communica-
tion and diagnosis.
DPZ81051 - $1.00/M
video
CANARE LV-61S
75 OHM VIDEO CABLE
Factory Sound and Canare’s No. 1 selling coax. A very flexible RG59B/U equivalent that
is perfect for all video facility equipment interfacing as well as video patch cord assem-
blies. Smooth non-glare finish PVC jacket and >95% Braided Copper Shield Coverage.
LV-61S - $2.30/M
CANARE
75 OHM COMPONENT
Heavy-duty component video multicore for extra long cable runs and for hi-res projec-
tion. Stays flexible in even sub-zero temp. <2.2 nano seconds differential delay. Bundled
channels keep cable runs neat, safe and swift.
V3-5C - $14.60/M V5-5C - $21.45/M
3-way Heavy-Duty - 15.5mm O/D 5-way Heavy-Duty - 19.2mm O/D
V4-5C - $17.20/M
4-way Heavy-Duty - 17.1mm O/D
CANARE
75 OHM COMPONENT
Most popular 75 ohm component series. Roughly equivalent to RG59 performance. A
good choice for limited length cable runs where conduit size may be restricted. 3, 4 or 5
channel selection with colour coded channels for easy ID.
123
FACTORY SOUND PHONE (03) 9690 8344 NATIONAL 1800 816 244
FAX (03) 9690 7077 75-85 YORK STREET, SOUTH MELBOURNE, VIC 3205 www.factorysound.com