BELLS UNIVERSITY OF TECHNOLOGY
COLLEGE OF ENGINEERING
DEPARTMENT OF MECHANICAL AND BIOMEDICAL ENGINEERING
SECOND SEMESTER EXAMINATION 2014/2015 SESSION
MEE 204/PMT 208 =AUTOCAD 2 Units ‘Time Allowed: 2 hours
Instruction; Attempt question | and any other three (3) questions.
Use of a laptop IS ALLOWED. Copy your files separately unto the DVD you will be Biven
DO NOT dimension or annotate any of your drawings.
Question 1
‘The figure below shows some views of a gearbox cover in first angle orthographic projection. Replicate
all the views shown below. The dimensions are in mm.Question 2:Replicate
the diagrams shown below in fig. 2a and fig. 2b,
(@) The dimen
n che 7
S are ininches.(b) The dimensionsare in mm.
= =
resect
Fig 2a Fig 2b
Question 3:
(a) Draw a circle of radius 7000 feet, mark off 24 equally spaced points and connect each point with
every other point using only straight lines. The finished drawing should look as shown below.Question
4: ‘atethe. i
4: Replicatethe diagram shown below in fig 4, The dimensions are in inches.
Question 5:Replicate the hook shown below in fig 5.
‘The dimensions are in inches.
Fig 5Question 6:Replis i
plicate the diagrams shown below in fig. 6a and fig. 6b. The dimensions are in
Fig. 6a Figéb