The Roadtec RX-50 specifications document can be summarized as follows:
1) The RX-50 is powered by a 600 hp Cummins diesel engine and has mechanical and hydrostatic drive systems to power its cutter drum, conveyors, and propulsion.
2) It has a 6'6" or 7'2" wide cutter that can cut up to 12" deep, along with hydraulic grade and slope controls to adjust cutting depth.
3) Additional key specs include a shipping weight of around 68,000 lbs, fuel and water capacities of 400 and 1,100 gallons respectively, and travel speeds up to 4.2 mph.
The Roadtec RX-50 specifications document can be summarized as follows:
1) The RX-50 is powered by a 600 hp Cummins diesel engine and has mechanical and hydrostatic drive systems to power its cutter drum, conveyors, and propulsion.
2) It has a 6'6" or 7'2" wide cutter that can cut up to 12" deep, along with hydraulic grade and slope controls to adjust cutting depth.
3) Additional key specs include a shipping weight of around 68,000 lbs, fuel and water capacities of 400 and 1,100 gallons respectively, and travel speeds up to 4.2 mph.
The Roadtec RX-50 specifications document can be summarized as follows:
1) The RX-50 is powered by a 600 hp Cummins diesel engine and has mechanical and hydrostatic drive systems to power its cutter drum, conveyors, and propulsion.
2) It has a 6'6" or 7'2" wide cutter that can cut up to 12" deep, along with hydraulic grade and slope controls to adjust cutting depth.
3) Additional key specs include a shipping weight of around 68,000 lbs, fuel and water capacities of 400 and 1,100 gallons respectively, and travel speeds up to 4.2 mph.
Cummins KTA-19, 600 hp @ 2100 Hydraulically driven water pump w/ 42" wide primary feed belt and 36" rpm. 24 volt charging system. shut off for spray bars located on secondary load out belt both with Emergency shutdown. front and rear of cutter housing. High variable speed control. Conveyor pressure wash down system. swings 45 degrees to either side. DRIVE SYSTEM Mechanical V-belt drive to cutter CUTTER SERVICE CAPACITY drum planetary. Hydrostatic drive for Cutting width …………………..6'6" Fuel ………………….……400 gal propulsion and conveyor system. …………………..7'2" Water ………………………1100 gal Cutting depth …………………...12" Hydraulic system ………………80 gal SUSPENSION Tip diameter ……………………44" Three-point suspension operated Tooth spacing …………………..5/8" WEIGHTS(approximate) hydraulically adjusts either manually Shipping weight …………..68,000 lbs or automatically by grade controls. GRADE CONTROLS Operating weight …………79,000 lbs Standard hydromechanical system TRACKS with sensors on both sides of Three D-5 track drives with 15" wide machine. Electric over hydraulic grousers. Travel speed 0-4.2mph. slope control. Working speed 0-160 fpm. GRADE SYSTEM STEERING Grade is set by two averaging ski Two front track steering, three track assemblies on either side of machine crab steering. and can be used in conjunction with the slope control unit.