Professional Documents
Culture Documents
Power: Sharing With Simplicity
Power: Sharing With Simplicity
Power: Sharing With Simplicity
DSEPOWER
®
SHARING
WITH
SIMPLICITY.
DSE7520 SPECIFICATION
AUTO MAINS (UTILITY) FAILURE & INSTRUMENTATION CONTROL MODULE
CRANKING DROPOUTS
Able to survive 0V for 50mS, providing supply
was at least 10V before dropout and supply
recovers to 5V. This is achieved without the
need for internal batteries
bus. Direct and flexible outputs from • Engine history event log card required)
CHARGE FAIL/EXCITATION RANGE
the module are provided to allow • Engine protection • On-site and remote module
0V to 35V
connection to the most commonly • Fault condition notification to a configuration (Modem required)
designated PC • In-built engine diagnostics BUILT-IN GOVERNOR AND AVR CONTROL
used speed governors and
• Front panel mounting removes the requirement for Fully Isolated
automatic voltage regulators (AVRs). Minimum Load Impedance:
• PC configuration service equipment
1000Ω
• Mains (utility) failure detection • Full engine protection & Gain Volts: 0V-10V DC
The module has the ability to • Configurable alarm timers instrumentation without the need Offset Volts: + / - 10V DC
monitor generator under/over • Configurable start & stop timers for additional senders (Electronic
volts, over current, generator • Automatic load transfer engines only) DIMENSIONS
under/over frequency, under • SMS alert messaging • Remote monitoring of the module 240mm x 172mm x 57mm
9.4” x 6.8” x 2.2”
speed, over speed, charge fail, • Multi set communications using comprehensive DSE PC
emergency stop, low oil pressure, • Front panel mounting software PANEL CUTOUT
high engine temperature, fail to • Remote control and monitoring • License free PC software 220mm x 160mm
• Dedicated load test button • No-break return capability 8.7” x 6.3”
start, low/high DC battery volts, fail
to stop, generator short circuit • KW overload alarms ENCLOSURE PROTECTION
protection, reverse power, • Engine temperature alarms IP65 (with optional gasket)
generator phase rotation error, • MV-LV synching IP42 (without gasket)
DSE7520
FROM TO LOAD
AUTOMATIC MCCB
GENERATOR AUTOMATIC ACB TO
MAINS
or CONTACTOR (UTILITY)
CT’s 1 AMP OR 5 AMP
3 or 4 POLE CT’s 1 AMP OR 5 AMP
SECONDARY SECONDARY
PROTECTION CLASS INSTRUMENT CLASS
P1 P2 P2 P1
L1
S1 S2 S2 S1
L2
L3
N
TO MAINS SWITCHING
2 AMP 2 AMP
TO GEN SWITCHING
FUSES FUSES
DEVICE CIRCUITRY
DEVICE CIRCUITRY
MPU
51 52 53 55 54 43 44 45 46 41 42 24 22 23 39 40 56 57 47 48 49 50
B
MODULE 7520
CRANK
157
OIL PRESSURE
FUEL
WATER TEMP
FUEL LEVEL
SCR
3 OUTPUTS
CHG ALT
+VE
B A B A SCR H L
1 2 3 4 5 16 17 18 15 6 60 61 62 63 64 65 66 67 68 8 9 10 7 34 35 36 37 38 27 25 26
USER CONFIGURABLE +VE OUTPUT E
CHARGE ALTERNATOR
FUEL TEMP
HIGH COOLANT TEMP
LOW OIL PRESSURE
TO
MIN 2 AMPS MAX 20 AMP ANTI-SURGE FUSE
TO
CONECT SCREEN AT
CONECT SCREEN AT
GOVERNOR
GENERATOR ONLY
AVR
GENERATOR ONLY
USER CONFIGURABLE -VE INPUT D
SCREEN EARTHED
AT THIS END ONLY
UPTO32 AMPS
TO ENGINE EARTH
FUSE
RELATED MATERIALS
TITLE PART NO’S
DSE7520 Manual 057-089
DSE7520 Installation Instructions 053-053
DSE75xx PC Software Manual 057-078
DSE7510 Data Sheet 055-065
DSE7560 Data Sheet 055-067
DSE123 Data Sheet 055-044
DSE810 Manual 057-052
Load Share Design and Commissioning 057-047
Guide to Synchronising and Load
Sharing 057-045/6
CAN and DSE Wiring Guide 057-004
DSE850 Comms Software Data Sheet 055-072
DEEP SEA ELECTRONICS PLC TELEPHONE EMAIL ®
Highfield House +44 (0)1723 890099 sales@deepseaplc.com
Hunmanby Industrial Estate
Hunmanby, North Yorkshire FACSIMILE WEBSITE
YO14 0PH England +44 (0)1723 893303 www.deepseaplc.com
PENDING
DEEP SEA ELECTRONICS PLC maintains a policy of continuous development and reserves the right to
change the details shown on this data sheet without prior notice. The contents are intended for guidance only.
This data sheet is printed on 9lives 55 Silk, which is produced with 55% recycled fibre
from both pre and post-consumer sources, together with 45% virgin ECF fibre.
055-066/09/08 (2)