Professional Documents
Culture Documents
Bab 1. IP BTLICIN Pendahuluan
Bab 1. IP BTLICIN Pendahuluan
Bab 1. IP BTLICIN Pendahuluan
PENDAHULUAN
1.1 Latar Belakang
This report describes the results of the IP (Induced Polarization) survey in the PT
PUE working area located in Tanah Bumbu Regency, South Kalimantan Province.
The survey was conducted in Teluk Kepayang Village, Kusan Hulu District,
Tanah Bumbu Regency, South Kalimantan Province (Figure 1). The journey to
the survey location was preceded by the team's road trip from Bandung to
Soekarno Hatta Airport (CGK). Then the team made an air trip to Banjarmasin
Airport until it was continued for 6 hours journey to Batulicin
Bab 1. Pendahuluan 1
Bab
1.
Pen
dah
ulu
an
• Obtaining the value of Chargeability and Resistivity using the Time Domain
Induced Polarization (TDIP) method.
IP measurements were carried out using the multi-function IP tool from Zonge
International. The configuration used is Dipole-dipole, the distance between
the electrodes (a) used varies, such as: 25 meters (4 tracks), 50 meters (1
cross) and 100 meters (1 path) for n = 1 to n = 6.
Bab 1. Pendahuluan 3
Figure 2. Map of the TDIP Survey Plan
Bab 1. Pendahuluan 4
Gambar 3. Peta Realisasi Survei TDIP
Bab 1. Pendahuluan 5
1.5 Jadwal Pelaksanaan
Bab 1. Pendahuluan 6
• ZMG-7.5 Motor Generator (Figure 4) is used to generate current to be used. This
generator is a portable engine with an alternator power capacity of up to 7500 VA
with a frequency of 400 Hz and a voltage of 115 V.
• VR-1 (Figure 4.) input voltage stabilizer from the generator to the GGT-10
Transmitter.
Bab 1. Pendahuluan 7
Figure 5. GDP 32-II Measurement Recorder (Receiver)
• The porous-pot contains copper rods that come into contact with a saturated
solution of copper sulfate (CuSO4) as a potential non-polarized electrode
(Figure 6).
• Copper cable with a cross section of 1.5 mm2 to connect the porous pot to the
receiver and 2.5 mm2 cable to connect the current electrode to the transmitter
(Figure 7).
Bab 1. Pendahuluan 8
Figure 7. 2.5 mm2 Current Cable and 2.5 mm2 Receiver Cable
• Aluminum foil, which functions as a current electrode, is placed in a
shallow hole filled with salt water as shown in Figure 8.
• HT radio as a means of communication for the TDIP team and local power,
most HT radios are equipped with long antennas as signal amplifiers in
communicating (Figure 9).
Bab 1. Pendahuluan 9
Figure 9. HT radio means of communication
Bab 1. Pendahuluan 10
Bab 1. Pendahuluan 11