This Arduino code controls a servo motor that acts as a barrier. The setup function attaches the servo to pin 3 and sets pins 13, 11, and 9 as outputs. The loop function then controls the servo barrier and LEDs on pins 13, 11, and 9 by writing positions to the servo, setting pin states high or low, and adding delays to control timing.
This Arduino code controls a servo motor that acts as a barrier. The setup function attaches the servo to pin 3 and sets pins 13, 11, and 9 as outputs. The loop function then controls the servo barrier and LEDs on pins 13, 11, and 9 by writing positions to the servo, setting pin states high or low, and adding delays to control timing.
This Arduino code controls a servo motor that acts as a barrier. The setup function attaches the servo to pin 3 and sets pins 13, 11, and 9 as outputs. The loop function then controls the servo barrier and LEDs on pins 13, 11, and 9 by writing positions to the servo, setting pin states high or low, and adding delays to control timing.