iGateway ADSL GAN9.

ET263-4

192.168.1.1/TelPlusAdmin <- go to this page

then input

adminpldt //username
5dPf49f1e6L8f4cD0e0UTTW //password

kung mapapansin nyo parang same lang sila ng password dun sa adsl gan0 model, pero if
you look closely THERE IS A SINGLE CHARACTER DIFFERENCE po.
password po ng gan0 model is 5dPf49F1e6L8f4cD0e0UTTW

to tell the difference po:

gan9 model = 5dPf49f1e6L8f4cD0e0UTTW

gan0 model = 5dPf49F1e6L8f4cD0e0UTTW

Account Password

In this page, you can set a password for accessing the Web management interface. By default, no password
is configured. You are recommended to create a password to keep your new router secure.

You can access the DSL router as one of the three user accounts: admin, support, and user.

admin Password
Enter a password for the "admin" user, who has full access to the Web management interface.
support Password
The "support" user can be used by an ISP technician to access the DSL router for maintenance and to run
diagnosis.
user Password
The "user" user can view settings and statistics, as well as update the firmware of the router.
Services
Allows access to the router via FTP, HTTP, ICMP, SNMP, SSH, TELNET, and TFTP.
LAN
Accesses the DSL router from the local network (LAN) side.
WAN
Accesses the DSL router from the ISP side.
IP Address
If this option is enabled, only specified IP addresses can access the router. This option works
with Services.

My bridge mode setup successful!

PLDT iGateway ADSL gan9 et263-4

Login using above info

-> wireless
disable wireless

-> local network

disable dhcp

-> internet setup

(2 rows)
1. … “DHCP”
2. … “bridge”

change “DHCP” to bridge

1. … “bridge”
2. … “bridge”

change laptop network card to assign ip address dyn

ip address auto changes to public ip pldt 112.x.x.x

Voila! Router now in bridge mode a.k.a. modem mode

Connect now to your favorite commercial routers

REPLY
quasicsays:
April 12, 2017 at 9:11 pm
Typo. Should be bridge mode PLDT iGateway ADSL gan9 et263-4
REPLY