Professional Documents
Culture Documents
EE Question
EE Question
EE Question
3. Find the current that will follow in a series circuit containing a 5 kohm
resistor, a 470 picoF capacitor, a 150- mH inductor, and a 0.001 microfarad if
the exciting voltage is 65 volts at 25kHz.
A. 6.32 +j8.46mA C. 8.46+j6.22mA
B. 6.22-8.46mA D. 8.46-j6.22mA
4. Two impedances, Z1=0.8+j5.6 and zZ2=8-j16 and the single phrase motor are
connected in parallel across 200 Vrms. 60Hz supply. The motor draws 5 kVA at
80% power factor lagging. Find the complex power of impedance Z2?
A. -1-j2kVA C. 2+ j1kVA
B. 1-j2kVA D. -2-j1kVA
5. What are the two elements in a series circuit connection having a current and
voltage i= 13.42 sin (500t-53.4degrees) A and v= 150sin (500t+10degrees) V?
A. R= 8.8 ohms and L=35mH C. R= 6.3 ohms and L=25mH
B. R= 7.5 ohms and L=30mH D. R= 5.0 ohms and L=20mH
6. The impedance Z3 in series to the two impedances Z1= 10+ j10 ohms and Z2= 20-
j30 ohms that are connected in parallel. What is the value of the impedance Z3
in ohms that will produce resonant circuit?
A. –j13.1 C. j13.1
B. j5.4 D. –j5.4
11. A balanced delta connected load of 4 – j3 ohms per phase is fed by a 380 V,
three-phase system. Find the reactive power.
A. 52 kVARS C. 69 kVARS
B. 29 kVARS D. 87 kVARS
14. A balanced three-phase wye connected source has using positive phase
sequence. Van = 220 V rms with 30 degrees angle. Determine Vbc.
A. 190.5 + j330 V C. -190.5 – j330 V
B. 190.5 – j330 V D. – j381 V
16. Given the following phase currents, Ia = 3.5 + j3.5, Ib = 0 – j3 and Ic = -2.6
+ j1.6. determine the negative sequence current for phase A.
A. 0.333 + j0.678 C. 0.424 + j0.571
B. -0.333 – j0.678 D. -0.333 + j0.678
17. Given the following sets of symmetrical components currents, determine the
phase B current.
Current Magnitude Angle, degrees
Ia0 1.0 75
La1 1.0 15
La2 1.0 -45
A. 0.259 + j0.966 C. 1.932 + j0.518
B. 0.516 + j1.931 D. 1.414 + j1.414
18. A transformer having a 360 turn primary winding takes 150 W in power and 1.4
A in current at an input voltage of 230 volts. Determine the no-load power
factor.
A. 0.606 C. 0.466
B. 0.866 D. 0.523
21. The open circuit and short circuit tests were performed on the primary side
of the 25 kVA, 7620/240, 60 Hz transformer and the following data were
obtained, open circuit test; Eoc = 7620 V, Ioc = 0.30 A and Poc = 500 W. Short
circuit test Esc = 450 V, Isc = 3.5 A and Psc = 220 W. Determine the shunt and
series impedances refer to the primary of the transformer.
A. 116 + j26 k & 17.97 + j130 C. 112 + j22 k & 15.95 + j128
B. 124 + j14 k & 21.85 + j134 D. 120 + j10 k & 19.95 + j132
22. An induction motor is rated 240 V, 150 A and 0.707 power factor. What is the
size of the capacitor in kVAR which must be place in parallel with the circuit
to improve the power factor to 95% lagging?
A. 17.1 C. 41.9
B. 24.3 D. 26.9