‘ MAHARASHTRA POLLUTION CONTROL BOARD
Phone : 0251-2310167 /2310212 —
oa Sidhivinayak Sankul 3rd floor,
Fax: 0251-2310192 TA Near Oak Baug, Station Road,
z Kalyan - 421301
rokalyan@mpcb.gov.in a E
| hittp://mpcb.gov.in sy
|
Green/S.S.1 Date: 4/03/2018
Consent No: MPCB/SROK-II/I8/\& 0350.08 13, 65
Consent to Operate under Section 26 of the Water (Prevention & Control of Pollution)
Act, 1974 & under Section 21 of the Air (Prevention & Control of Pollution) Agt, 1981
and Authorization / Renewal of Authorization under Rule 5 of the Hazardous @>her
P| ‘Wastes (Management & Transboundry Movement) Rules 2016 &
| [To be referred as Water Act, Air Act and HW (M&H) Rules “egg?
| ;
CONSENT is hereby granted to aN
M/s. Arabian Petroleum Ltd, 9S
P.No. 14-B, MIDC Morivali, xy
Tal, Ambernath, Dist. Thane
located in the area declared under the provision 7
« ‘Amendments thereto subject
Authorization under the provisions of HW(M&H) RGjes
to the provisions of the Act and the Rules and the C
subject to the following terms and conditions:
1. The Consent to Operate is granted for
2._ ‘The Consent is valid for the manufactur
St. No. Parnes lem)
(erent
Lubricating Oils,
yducts (only
petroleum bee
opie Wtemprature) _
(Dry process withou ltémical treatment, only blending at normal temperature)
s ER WATER ACT:
iitY’of trade effluent from the factory shall be NIL.
tity of sewage effluent from the factory shall not exceed 2.4 M’.
NA-
\de Pffluent Disposal: Co
Age Effluent ‘Treatment: The applicant shall provide comprehensive treatment
S¥stem as is warranted with reference to influent quality Oand operate and maintain the
same continuously so as to achieve the quality of treated effluent to the following,
standards,
(1) Suspended Solids Not to exceed 100 mg/L.
(2) BOD 3 days 270 C. Not to exceed 100 mg/L
(vi) Sewage Effluent Disposal: ‘The treated domestic effluent shall be soaked in a soak pit,
which shall be got cleaned periodically. Overflow, if any, shall be used on land for
gardening / plantation only.
Go
Sree
Vl
ii) Non-Hazardous Solid Wastes:
‘Type Of Waste Quantity
|
| SRO Kalyan IVGISATA?Nil
(viii) Other Conditions: Industry should monitor effluent quality regularly.
4. The applicant shall comply with the provisions of the Water (Prevention & Control of
Pollution) Cess Act, 1977 (to be referred as Cess Act) and amendment Rules, 2003 thre
under
‘The daily water consumption for the following categories is as under:
(i. Domestic purpose 3.0 CMD
(ii) Water gets Polluted &
Pollutants are Biodegradable 0.00 CMD
(iii) Water gets Polluted, Pollutants
are not Biodegradable & Toxic 0.00 CMD. dS
(iv) Industrial Cooling, spraying
in mine pits or boiler feed 0.00¢)
Gardening
The applicant shall regularly submit to the Board the ost lonsumption in
the prescribed form and pay the Cess as specified under Section 3 of the sabwAAct.
maintain the same continuously so as to ackieve level of pollutants to the
following standards:
a. Control Equipment: . S
Industry shall provide dust collector aaa facity to control the emissions.
6. Standards for Stack Emissions: ~\Y
ONze fuel pattern:-
5, CONDITIONS UNDER AIR ACT
@ The applicant shall install a comprehensive contro} consisting of control
equipments as is warranted with reference to “ex ‘mission and operate and
ime bed
Thermic Fiuid Heater
‘Height in Mers,
20
TRAGdsiine shall provide ports in the chimney/(s) and facilites such as ladder,
‘etc. for monitoring the air emissions and the same shall be open for inspection
SS for use of the Board's Staff. The chimney(s) vents attached to various sources of
ai
ission shall be designated by numbers such as S-1, S-2, etc. and these shall be
‘inted/ displayed to facilitate identification,
(iv) The industry shall take adequate measures for control of noise Ievels from its own
sources within the premises so as to maintain ambient air quality standard in respect of
noise to less than 75 dB(A) during day time and 70 dB(A) during night time. Day time |
is reckoned in between 6 a.m. and 10 p.m. and night time is reckoned between 10 p.m.
and 6 a.m
(¥) Other Conditions:
1, The industry should not cause any nuisance in
SRO Kalyan HUG)7. CONDITIONS UNDER HAZARDOUS & OTHER WASTES( MANAGEMENT,
‘& TRANSBOUNDRY MOVEMENT) RULES, 2016:
i) Treatment: - NIL
8, Industry shall comply with following additional conditions:
i. The applicant shall maintain good housekeeping and take adequate measures for
| control of pollution from all sources so as not to cause nuisance to surroudging area /
inhabitants.
‘The applicant shall bring minimum 33% of the available open
coverage/ tree plantation,
Solid waste - The non hazardous solid waste arising i tory premises,
| sweepings, etc., be disposed of scientifically so as not any nuisance /
pollution. The applicant shall take necessary permissi civic authorities for
disposal to dumping ground. x
ON
‘The applicant shall provide for an alternate Ease Source sufficient to opérate
all pollution control facilites installed by he SS ‘maintain compliance with the
green
terms and conditions of the consent. In the abSgncgthe applicant shall stop, reduce or
otherwise, control production to abide by ¢ nnditions of this consent regarding
pollution levels. * 7
¥. The applicant shall not change SK MMquantity, quality, the rate of discharge,
temperature or the mode of: ght / emissions or hazardous wastes or control
equipments provided for wit reVious written permission of the Board.
vi, The applicant shall pr #elity for collection of environmental samples and.
samples of trade and, se se effluents, air emissions and hazardous wastes to the
Board staff at the e Hhal or designated points and shall pay to the Board for the
services rendgred'fa this Behalf.
vil. The cag ik iake an application for renewal of the consent at least 60 days
before the glafe-Of Yhe expiry of the consent.
vili.The fir sfgi" submit to this office, the 30" day of September every year, the
Ry ital Statement Report for the financial year ending 31* March in the
a
Form-V as pre the provisions of rule 14 of the Environment (Protection)
. vid Amendment) Rules, 1992.
Nai in:
ection book shall be opened and made available to the Board's officers during
'\ their visit to the applicant.
x. The applicant shall install a separate electric meter showing the consumption of energy
for operation of domestic and industrial effluent treatment plants and air pollution
control system. A register showing consumption of chemicals used for treatment shall
be maintained.
xi. Separate drainage system shall be provided for collection of trade and sewage
effluents. Terminal mysieapaaall be provided at the end of collection system with
arrangement for BMW. No effluent shall be admitted in the pipes /
sewers down- str ¥a\\ manholes. No effluent shall find its way other
SRO Kalyan 11i
xii, Neither storm water nor discharge from other premises shall.be allowed to mix with
the effluents from the factory.
| 7
9, The Board reserves the right to review, amend, suspend, revoke ete. this
consent and the same shall be binding on the industry.
10.This consent should not be construed as exemption from obtaining
necessary NOC/permission from any other Government authorities.
|
|
11.The applicant shall apply for renewal of Consent to Ops from |
Maharashtra Pollution Control Board before 60 days of aw f this |
Consent.
12. This consent is issued as per the delegation of power vide ice Order No.
31/2013 dtd.01/03/2013.
9
| 13. The Board reserves its rights to vary all or any of th n in the consent, if
| due to any technological improvement or eles variation (including
01
the change of any control equipment, other in (hole oy In part is necessary).
ee
14, The Capital investment of the indust 3/- Lacs.
ashe
(Mane Jadhav) |
Sub Regional Officer, Kalyan I
To, - .
M/s. Arabian Petr
P.No. 14-B, Mi
Tal. A
Receive fee of -
75000/~ ‘TXN1801003482 | 29.01.2018 -
15000/- ‘TXN1803000066 | 01.03.2018 =
SRO Kalyan WuGesarsi7