Professional Documents
Culture Documents
2x4-Banco de Pallet
2x4-Banco de Pallet
com
Legal:
The content of this guide may not be sold, modified, or distributed in anyway without the expressed
written consent of the publisher. Reprinting, copying, or any other form of distribution for commercial
or non-commercial purposes is strictly prohibited and will be prosecuted.
Disclaimer:
Every attempt has been made to provide the most accurate information as possible. However, the
publisher accepts no liability for any wrong information as a result of purchasing and / or reading this
guide.
You can follow this guide at your own risk the publisher accepts no responsibility for any injury to any
person.
Copyright © www.Construct101.com
ISBN-13:
ISBN-10:
Cut two 2×4’s to 1′ 6 1/2″ long, rip the 2×4 to 1 1/2″, cut a 15-degree angle cut on one end (B).
Cut two 2×4’s to 1′ 7 1/16″ long, cut 15-degree angle cut on both end in the same direction (C).
Drill pilot holes and install as shown in illustration above using 2 3/4″ deck screws.
Drill pilot holes and install as shown in illustration above using 2 3/4″ deck screws.
Cut two 2×4’s to 1′ 11 1/8″ long, cut a 15-degree angle cut on one end (E).
Drill pilot holes and install as shown in illustration above using 2 3/4″ deck screws.
Cut a 2×4 to 3′ 9″ long, cut a 15-degree bevel cut along the edge (F).
Drill pilot holes and install as shown in illustration above using 2 3/4″ deck screws.
Drill pilot holes and install as shown in illustration above using 2 3/4″ deck screws.
Cut four 2×4’s to 4′ long (H). Cut three 2×4’s to 4′ long (I). Cut one 2×4 to 3′ 9″ long (J).
Drill pilot holes and install as shown in illustration above using 2 3/4″ deck screws.