COOPER
INDUSTRIES
ENGINEERING SERVICE BULLETIN
SERVICE BULLETIN #196
REVISED 11/16/92
Type and amount of lubricant to be used during installation
of cylinder liner *o" rings into cylinder block.
This bulletin supersedes the portion of Bulletin #123 covering
applying RTV on “o” rings - liner to block.
ALL SUPERIOR ENGINES
SUPERIOR has found some customers are using excessive amounts
of grease, RTV, or similar materials as a lubricant on the "o"
rings, cylinder to block. Excessive amounts of these materials
can cause distortion of the cylinder liner resulting in piston
to liner seizures during initial operation following an overhaul
or liner o" ring replacement.
There is also some evidence that some oils, greases, etc,
placed on the “o” rings may be altered in composition over
time and contribute to corrosive attack of the "o” rings and
“o” ring grooves.
It is SUPERIOR’s recommendation that a thin coating of mineral
(same as that used in the engine) be applied to the “0” rings
prior to installation on the liner.
Any excess oil should be wiped from the “o" rings prior to
insertion of the liners in the block.
(Liquid soaps previousty recommended may contain constituents
which can cause corrosion/rusting in the "o” ring area.)
SUPERIOR FIELD ENGINEERING
12/1/92