Professional Documents
Culture Documents
Valgard 130 3.5 Voc Yellow Epoxy Primer
Valgard 130 3.5 Voc Yellow Epoxy Primer
Viscosity (#3 Zahn @ 77F): 12-16 seconds --- seconds 15-19 seconds
Weight Per Gallon (Theoretical): 12.74 lbs./gal. 8.06 lbs./gal. 12.31 lbs./gal.
Solids by Weight (Theoretical): 71.60% 56.67% 70.71%
Solids by Volume (Theoretical): 49.02% 54.98% 49.57%
VOC (Theoretical): 3.62 lbs./gal. 3.49 lbs./gal. ---
VOC (Actual): --- --- 3.50 lbs./gal max.
HAPs Content (lbs/solid gallon): --- --- .36 lbs.
Mix Ratio: --- --- 10:1 by volume
Pot Life (to Double Viscosity): --- --- Spray within 12 hrs at 70°F
(gels at 48 hrs)
Spray within 6 hrs. at 100°F
(gels at 20 hrs).
Application Recommendations:
Substrate/Pretreatment: --- --- Pretreated Steel
Reduction: --- --- As Needed
Reduction Solvent: --- --- Ketones or Aromatics
Application: --- --- Air spray/air-assisted
airless
Clean-Up Solvent: --- --- Ketones, Aromatics
Cure Schedule: --- --- 20' @ 130°F
Air Dry at 77°F, 1 mil DFT: --- --- 40’ dry to touch
Film Properties:
Dry Film Thickness: --- --- 1.0-1.5 mils
Coverage @ 1 mil DFT: --- --- 795.12 sq. ft./gal.
Material Identification
Product ID: EEY0095
Product Name VALGARD 130 YELLOW EPOXY PRIMER
Product Use: Paint product.
Print date 2005/03/11
Revision Date 2005/02/03
Company Identification
The Valspar Corporation
1101 Third Street South
Minneapolis, MN 55415
Manufacturer's Phone: 1-612-332-7371
If this section is blank there are no hazardous components per OSHA guidelines.
3. HAZARDS IDENTIFICATION
Emergency Overview:
This section not in use.
This product contains ingredients that may contribute to the following potential acute health effects:
Inhalation Effects:
May cause systemic toxicity.
Eye Contact:
May cause eye burns. May cause severe eye irritation. Corneal Injury/eye damage.
Skin Contact:
May cause moderate skin irritation. May cause skin sensitization. May cause dermatitis. May cause an allergic skin
reaction.
Acute Ingestion:
May cause liver and kidney damage. May cause central nervous system depression.
Other Effects:
May cause liver damage.
This product contains ingredients that may contribute to the following potential chronic health effects:
Notice: Reports have associated repeated and prolonged occupational overexposure to solvents with permanent brain
and nervous system damage. Intentional misuse by deliberately concentrating and inhaling the contents may be harmful
or fatal. This product contains ingredients which may produce an allergic respiratory response. Treat as a respiratory
sensitizer.May cause eye damage and pain.Contains a component which is a known or suspected skin sensitizer.Suspect
cancer hazard. Contains ingredients which may cause cancer. Risk of cancer depends upon the duration and level of
exposure. Possible sensitization. Contains formaldehyde which is considered a potential carcinogen by the Occupational
Health and Safety Administration.
See Section 11 for toxicological information about Mutagens, Teratogens and Carcinogens.
Inhalation:
If affected by inhalation, move victim to fresh air. If symptoms persist, seek medical attention. If inhaled, remove to fresh
air. If not breathing give artificial respiration, preferably mouth-to-mouth. If breathing is difficult give oxygen. Get medical
attention.
Eye Contact:
In case of contact, or suspected contact, immediately flush eyes with plenty of water for at least 15 minutes and get
medical attention immediately after flushing. If irritation persists, consult a physician. Flush with plenty of low pressure
water for 15 minutes, occasionally lifting eye lids.
Skin Contact:
In case of contact, immediately flush skin with plenty of soap and water for at least 15 minutes. If irritation persists get
medical attention. Remove contaminated clothing and shoes. Wash clothing before reuse. Thoroughly clean
contaminated shoes. Destroy contaminated leather apparel.
Extinguishing media:
Carbon dioxide, dry chemical, foam and/or water fog.
Skin protection:
Gloves: Neoprene or other nonporous.Neoprene or plastic apron and protective clothing covering exposed skin areas.
Respiratory protection:
If exposure cannot be controlled below applicable limits, use the appropriate NIOSH approved respirator such as an air
purifying respirator with organic vapor cartridge and dust/mist filter. Consult the respirator manufacturer's literature to
ensure that the respirator will provide adequate protection. Read and follow all respirator manufacturer's instructions.
Ventilation
Required when spraying or applying in confined area. Ventilation equipment should be explosion proof.
Exposure Guidelines
Common Name approx. TWA (final) Ceilings limits (final) Skin designations
CAS-No. Weight %
BUTYL ACETATE 10 - 15 710 MGM3 150 ppm
123-86-4
METHYL N-AMYL KETONE 5 - 10 465 MGM3 100 ppm
110-43-0
ZINC OXIDE PIGMENT 5 - 10 5 MGM3 Respirable
1314-13-2 fraction.
15 MGM3 Total dust.
5 MGM3 Fume.
Respirable fraction.
Listed.
Total dust. Listed.
Trade Secret : 5 - 10 5 MGM3 Respirable
PROPRIETARY PIGMENT fraction.
15 MGM3 Total dust.
Respirable fraction.
Listed.
Total dust. Listed.
METHYL PROPYLKETONE 1-5 700 MGM3 200 ppm
107-87-9
NAPHTHALENE .1 - 1 50 MGM3 10 ppm
91-20-3
FORMALDEHYDE 0 - .1 0.75 ppm
50-00-0
9. PHYSICAL PROPERTIES
Stability Stable
Conditions to Avoid: None known.
Incompatibility: Strong oxidizers.
Hazardous Polymerization: None anticipated.
Hazardous Decomposition Products: Carbon monoxide and carbon dioxide. Metal oxide fumes.
Sensitivity to static discharge: Can be sensitive to static discharge hazards. Please see bonding and grounding
information in Section 7.
Mutagens:
Carcinogens:
Possible cancer hazard. Contains ingredients which may cause cancer based on animal data. Risk to your health
depends upon the level and duration of exposure.
Common Name approx. IARC Group 1 - Human IARC Group 2A - IARC Group 2b -
CAS-No. Weight % Evidence limited human data sufficient animal data
NAPHTHALENE .1 - 1 POSSIBLY
91-20-3 CARCINOGENIC IN
HUMANS BASED ON
ANIMAL STUDIES
FORMALDEHYDE 0 - .1 MONOGRAPH 62,
50-00-0 1995
Common Name approx. OSHA Select OSHA Possible select ACGIH Carcinogens
CAS-No. Weight % carcinogens carcinogens
FORMALDEHYDE 0 - .1 Potential cancer Group A2 Suspected
50-00-0 hazard. human carcinogen.
Disposal should be made in accordance with federal, state and local regulations.
TSCA Inventory: All components of this product are in compliance with U.S. TSCA Chemical
Substance Inventory Requirements.
Canada Domestic Substances List: All components of this product are listed on the Domestic Substances List.
HMIS Codes
Health: 3
Flammability: 2
Reactivity: 1
PPE: X - See Section 8 for Personal Protective Equipment (PPE).
Abbreviations:
OSHA - Occupational Safety and Health Administration, IARC - International Agency for Research on Cancer, NIOSH -
National Institute of Occupational Safety and Health, NTP - National Toxicology Program, ACGIH - American Conference
of Governmental Industrial Hygienists, SCAQMD - South Coast Air Quality Management District, TSCA - Toxic
Substances Control Act, IATA - International Air Transport Association, IMO - International Maritime Organization, DOT -
Department of Transportation, NA - Not applicable, NOT ESTAB - Not established, N.A.V. - Not available, RQ -
Reportable quantity, WT - Weight, MG/CU M - Milligrams per cubic meter, G/L - Grams per liter, MM - Millimeters,
MPPCF - Millions of particles per cubic foot, PPM - parts per million, PPT - parts per thousand, TCC/PM - Tag closed
cup / Pensky-Martens, PB - Lead, PEL - Permissible exposure level, TWA - Time Weighted Average, STEL - Short term
exposure limit, C - Celsius, F - Fahrenheit.
Disclaimer:
The data on this sheet represent typical values. Since application variables are a major factor in product performance, this
information should serve only as a general guide. Valspar assumes no obligation or liability for use of this information.
UNLESS VALSPAR AGREES OTHERWISE IN WRITING, VALSPAR MAKES NO WARRANTIES, EXPRESS OR
IMPLIED, AND DISCLAIMS ALL IMPLIED WARRANTIES INCLUDING WARRANTIES OF MERCHANTABILITY OR
FITNESS FOR A PARTICULAR USE OR FREEDOM FROM PATENT INFRINGEMENT. VALSPAR WILL NOT BE
LIABLE FOR ANY SPECIAL, INCIDENTAL OR CONSEQUENTIAL DAMAGES. Your only remedy for any defect in this
product is the replacement of the defective product, or a refund of its purchase price, at our option. This MSDS contains
additional information required by the state of Pennsylvania.
Material Identification
Product ID: CEC0056
Product Name: EPOXY PRIMER CURING AGENT
Product Use: Paint product.
Date Published: 2004/01/30
Revision Date: 2004/01/30
Company Identification
The Valspar Corporation
1101 Third Street South
Minneapolis, MN 55415
Manufacturer's Phone: 1-612-332-7371
If this section is blank there are no hazardous components per OSHA guidelines.
3. HAZARDS IDENTIFICATION
Emergency Overview:
This section not in use.
This product contains ingredients that may contribute to the following potential acute health effects:
Eye Contact:
Corneal Injury/eye damage. May cause eye damage and pain.
Skin Contact:
Contains a component which is a known or suspected skin sensitizer. Harmful if absorbed through the skin. May cause
skin burns.
Acute Ingestion:
May cause burns of the mouth, throat and stomach. Irritation of gastrointestinal tract.
Other Effects:
Contains ingredients which are corrosive.
This product contains ingredients that may contribute to the following potential chronic health effects:
Notice: Reports have associated repeated and prolonged occupational overexposure to solvents with permanent brain
and nervous system damage. Intentional misuse by deliberately concentrating and inhaling the contents may be harmful
or fatal. Effects may be permanent. Overexposure may cause allergic respiratory reaction. This product contains
ingredients which may produce an allergic respiratory response. Treat as a respiratory sensitizer.May cause eye damage
and pain.Contains a component which is a known or suspected skin sensitizer.May cause liver damage. Hearing loss. May
cause kidney damage. Possible sensitization.
See Section 11 for toxicological information about Mutagens, Teratogens and Carcinogens.
Inhalation:
If inhaled, remove to fresh air. If not breathing give artificial respiration, preferably mouth-to-mouth. If breathing is difficult
give oxygen. Get medical attention. If affected by inhalation, move victim to fresh air. If symptoms persist, seek medical
attention.
Eye Contact:
In case of contact, or suspected contact, immediately flush eyes with plenty of water for at least 15 minutes and get
medical attention immediately after flushing.
Skin Contact:
In case of contact, immediately flush skin with plenty of soap and water for at least 15 minutes. If irritation persists get
medical attention. Remove contaminated clothing and launder before reuse. Remove contaminated shoes and discard.
Ingestion:
If swallowed, contact medical personnel immediately to determine best course of action.
Extinguishing media:
Carbon dioxide, dry chemical, foam and/or water fog.
Skin protection:
Gloves: Neoprene or other nonporous.Neoprene or plastic apron and protective clothing covering exposed skin areas.
Respiratory protection:
If exposure cannot be controlled below applicable limits, use the appropriate NIOSH approved respirator such as an air
purifying respirator with organic vapor cartridge and dust/mist filter. Consult the respirator manufacturer's literature to
ensure that the respirator will provide adequate protection. Read and follow all respirator manufacturer's instructions.
Exposure Guidelines
Common Name Approx TWA (final) Ceilings limits (final) Skin designations
CAS # Wt%
N-BUTYL ALCOHOL 20 - 25 100 ppm TWA; 300 50 PPM SKIN, OSHA
71-36-3 mg/m3 TWA
9. PHYSICAL PROPERTIES
Sensitivity to static discharge: Subject to static discharge hazards. Please see bonding and grounding
information in Section 7.
Disposal should be made in accordance with federal, state and local regulations.
Hazard Class: 8
Subsidiary Risk: 3
UN ID Number: UN2920
Packing Group: II
TSCA Inventory: All components of this product are in compliance with U.S. TSCA Chemical
Substance Inventory Requirements.
Canada Domestic Substances List: Not all components in this product are listed on the Domestic Substances List.
HMIS Codes
Health: 3
Flammability: 3
Reactivity: 1
PPE: X - See Section 8 for Personal Protective Equipment (PPE).
Disclaimer:
The data on this sheet represent typical values. Since application variables are a major factor in product performance, this
information should serve only as a general guide. Valspar assumes no obligation or liability for use of this information.
UNLESS VALSPAR AGREES OTHERWISE IN WRITING, VALSPAR MAKES NO WARRANTIES, EXPRESS OR
IMPLIED, AND DISCLAIMS ALL IMPLIED WARRANTIES INCLUDING WARRANTIES OF MERCHANTABILITY OR
FITNESS FOR A PARTICULAR USE OR FREEDOM FROM PATENT INFRINGEMENT. VALSPAR WILL NOT BE
LIABLE FOR ANY SPECIAL, INCIDENTAL OR CONSEQUENTIAL DAMAGES. Your only remedy for any defect in this
product is the replacement of the defective product, or a refund of its purchase price, at our option. This MSDS contains
additional information required by the state of Pennsylvania.