1. How do you place the counterweight damper properly?
The counterweight is held by counterweight pins and counterweight plate holds the pins a secured by a snap ring 2. In the assembly, what is the important procedure so that the full firing position is achieved, such that the rest of the engine will be sequenced as you proceed. The number one piston is extended to what we call top dead center so that the rest of the engine will be sequenced as you proceed. 3. In the procedure of installing the front main bearing into the front main crankcase journal, how do you position them to align correctly? If the front main bearing is two piece it must line up with the dowel posts in the crankcase when positioned mark the spot on the bearing where it must meet the dowels so that when placing in crankshaft journal, we can visualize knowing that the crankcase will go there the bearing will go there with the pencil mark we will be able to line up the dowel 4. Where do you find the proper torque value used in tightening the bolts on the gear? The bolts torque value can be found in the manufacture manual 5. Why is the crankshaft mounted vertically? Crankshaft is vertically mounted for convenience it helps with holding parts and tools, when the engine is rotated by hand to position the Pistons and perform other timing operations, we can visualize the placement of the engines parts and understand that this is where the number one cylinder will be the number two cylinder and so forth this allows us to further visualize the relationship between parts 6. What is the function for the timing gear? Timing gear drives the magneto and has an eccentric a cam which drives the fuel pump 7. What is that part that cannot be adjusted and will be thrown out if no longer working? The verna therm bypass valve is a thermostatically self- operated valve that exposes a hole to the oil cooling system when the Verna therm heats up it expands and covers the hole allowing oil to flow through the oil cooling system this is a simple mechanical system which cannot be worked on or adjusted when it no longer works it's thrown out 8. What is the silk thread used for? The silk is like a gasket that fills the space between two or more mating surface to prevent leaks from or into the mated surface 9. What does it mean by "Go - No go"? The dry tappet clearance is check by "Go - No go gauge to meet the specification in the manufacturer manual the minimum side go should fit and the maximum side should not fit if it does not the rod must be changed until it satisfies the Go / No-go