Professional Documents
Culture Documents
Chelton: Blade Antenna TYPE 16-434
Chelton: Blade Antenna TYPE 16-434
OVERHAULMANUAL
PUBLICATION No 16-434
BLADE ANTENNA
TYPE 16-434
OVERHAUL MANUAL
Signed/?/d&& c
Retain this record of Temporary Revisions at the front of the manual immediately
following the Record of Permanent Revisions. On receipt of the Temporary Revision,
revise as detailed in the letter of transmittal and record the incorporation of the
revision or amendment on this sheet. The introduction of data by temporary revision
or amendments not certified in accordance with British Civil Airworthiness
Requirements Chapter AS-3. will invalidate the initial certification on the title
page of the manual relative to the part revised. Temporary revisions or amendments
which have been certified by the approved Design Organisation other than that
applicable to the initial certification must be recorded on separate record sheets.
Cancelled
Temporary Revision Insertion
Number Date BY Date
Retain this record of Permanent Revisions at the front of the manual immediately
following the title page. On receipt of the Permanent Revision, revise as detailed
in the letter of transmittal and record the incorporation of the revision or amendment
on this sheet. The introduction of data by permanent revision or amendments not
certified in accordance with British Civil Airworthiness Requirements Chapter A5-
3, will invalidate the initial certification on the title page of the manual relative
to the part revised. Permanent revisions which have been certified by the approved
Design Organisation other than that applicable to the initial certification must be
recorded on separate record sheets.
SERVICE
B%.LETIN US2
Title Page ... ,.. ... ... ... ... Nov l/92
Service Bulletin List .,. ... ... ... Page 1 Nov l/92
Para.
Fits and Clearances ... ... ... ... ... ... ... 7
Special Tool, fixtures and equipment ... ... .., ... ... 11
Illustrated Parts List ... ... ,.. ... ... ... ... 12
Table of Contents
23-l 2-43 NovP%;9i
CBELTON (ELECTROSTATICS) LIMITED
OVERHAULMANUAL
PUBLICATION No. 16-434
Page 2
23-l 2-43 Nov lo/92
CHELTON(ELECTROSTATICS) LIMITED
OVERHAUL MANUAL
PUBLICATION No. 16-434
1. DESCRIPTION OPERATIONDATA
The antenna type 16-434 is a low height passive antenna designed to function
inboth communications and homing applications over the frequency range 118 MHz
to 174 MHZ.
B. Data
234243 Nov%9if
CHELTON (ELECTROSTATICS)LIMITED
OVERHAULMANUAL
PUBLICATION No. 16-434
2. DISASSEMBLY
3. CLEANING
Clean all parts with industrial methylated spirits. any alcohol based cleaning
solvent or recognised printed circuit board cleaning agent.
4. INSPECTION/CHECK
(1) Cleanliness
(2) Corrosion
(3) Distortion
(4) Denting
(5) Cracks
5. REPAIR
8. TESTING
The following test procedure requires the use of the following test equipment.
Prior to each test and at intervals of not more than 30 minutes during the test,
calibrate the test equipment in accordance with the test set manual.
A. VSWRMeasurement Procedure
(1) Mount the Unit Under Test (IJUT) centrally on the ground plane which should
be situated clear of any conducting projections.
(2) Set up the test equipment in accordance with the QB8 Test Set manual.
(3) Measure the VSWRrelative to 50 ohms at frequencies over the range 118 MHz
to 174 MHz.
(4) Verify that the VSWRmeasurements do not exceed the ratio stated below.
9. TROUBLESHOOTING
No trouble shooting is required since the unit cannot be dismantled.
10. STORAGEINSTRUCTIONS
A. When available, use the manufacturers packing materials. If these are not
available, pack the unit as follows:
(2) Place the unit in a suitable moisture resistant pack and seal.
(3) Attach a label to the storage pack providing the following information:
A. There are no special tools. fixtures or test equipment required to service this
equipment.
ILLUSTRATEDPARTS LIST
BLADE ANTENNA
TYPE 16-434
NOTE: There is no spares support for the type 16-434 blade antenna
apart from the installation kit and RF gasket. No repairs
are permissible excepttotheprotective paint finish. Units
that fail to complywiththe performance as specified in this
Overhaul Manualmustbe returned to Chelton for evaluation.
TABLE 1