This document contains instructions for three exercises: designing the crankshaft of an engine piston with dimensions in inches, designing the center piece of a rock climbing ascender tool with dimensions in centimeters and a 0.2 cm fillet radius, and designing an air cylinder model with dimensions in inches. The exercises are due before 11:59 PM on September 29, 2021.
This document contains instructions for three exercises: designing the crankshaft of an engine piston with dimensions in inches, designing the center piece of a rock climbing ascender tool with dimensions in centimeters and a 0.2 cm fillet radius, and designing an air cylinder model with dimensions in inches. The exercises are due before 11:59 PM on September 29, 2021.
This document contains instructions for three exercises: designing the crankshaft of an engine piston with dimensions in inches, designing the center piece of a rock climbing ascender tool with dimensions in centimeters and a 0.2 cm fillet radius, and designing an air cylinder model with dimensions in inches. The exercises are due before 11:59 PM on September 29, 2021.
Part 1 – Crankshaft of an engine piston. All dimensions are in inches.
Part 2 – Center piece of a rock climbing ascender tool. Use fillet radius of 0.2 cm for all edges except the top hole as shown below. All dimensions are in centimeters. Part 2 – Air cylinder model. All dimensions are in inches.