Professional Documents
Culture Documents
HP 6830 Javítás
HP 6830 Javítás
com/Device/HP_Officejet_Pro_6835
Comments: 4
Favorites: 3
Completions: 13
Difficulty
Moderate
Steps
Time Required
15 minutes
Sections
2
Flags
Introduction
To replace the printhead, you need a thin pair of tweezers to get into some small crevasses
and a screwdriver to remove screws. Make sure to extract all the ink cartridges from the
carriage before starting the disassembly. Check out the troubleshooting page before replacing
the printhead to make sure a replacement is absolutely necessary. Be prepared to get ink on
your hands, as some components may have ink on them.
Tools
Parts
No parts specified.
Step 2
Use a T9 torx screwdriver to remove a total of ten (10) 12mm screws from the main
cover by turning the screwdriver counterclockwise.
The two screws above the screen assembly are deep so you may need a long
screwdriver.
Step 3
Step 4
Grab the base of the white ribbon cable connecting the cover to the base of the printer
and pull it out.
Step 5 Printhead
Using tweezers, pinch the top of the spring located on the right side of the printhead.
Pull the spring up and around the hook of the carriage to remove the spring from the
printhead.
Use the same procedure to remove the left spring.
The springs may fly out of the printer once you remove them.
Step 6
Pinch the left most white cable located on the back of the printhead with your
tweezers.
Pull the cable to remove it from the printhead.
Continue this process to remove all three white cable from the printhead.
Step 7
Lift the printhead off the printer to expose the last white cable.
Pinch the the last cable with the tweezers.
Pull the cable to disconnect it from the printhead.
A nyomtatófej cseréjéhez szükség van egy vékony csipeszre, hogy bekerüljön néhány
apró résbe, és egy csavarhúzóval, a csavarok eltávolításához. A szétszerelés
megkezdése előtt feltétlenül vegyen ki minden tintapatront a kocsiból. Nézze meg a
hibaelhárítási oldalt, mielőtt kicseréli a nyomtatófejet, hogy meggyőződjön arról, hogy
a csere feltétlenül szükséges. Legyen felkészülve arra, hogy tintát kapjon a kezére,
mivel egyes alkatrészekben tinta lehet rajta.
A képernyő csavarja felett található két csavar mély, így hosszú csavarhúzóra lehet
szükség.
Ne húzza túl erősen - van egy kábel, amely összeköti a fedelet a nyomtatóval.
4 Fogja meg a fehér szalagkábel alját, amely a fedelet a nyomtató alapjához köti, és
húzza ki.
5 Csipesszel szorítsa meg a rugó felső részét, amely a nyomtatófej jobb oldalán
található.
Húzza fel a rugót és a kocsi horogja körül, hogy eltávolítsa a rugót a nyomtatófejen.
6 Fogja meg a csipesszel a bal oldali legtöbb fehér kábelt, amely a nyomtatófej
hátulján található.