Professional Documents
Culture Documents
Safety Data Sheet Cleaner & Degreaser
Safety Data Sheet Cleaner & Degreaser
Danger
Hazard statements:
H314 Causes severe skin burns and eye damage.
Precautionary statements:
P280 Wear eye protection.
P301+P330+P331 IF SWALLOWED: rinse mouth. Do NOT induce vomiting.
P303+P361+P353 IF ON SKIN (or hair): Take off immediately all contaminated clothing.
Rinse skin with water/ shower.
P304+P340 IF INHALED: Remove person to fresh air and keep comfortable for breathing.
P305+P351+P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove
contact lenses, if present and easy to do. Continue rinsing.
P310 Immediately call a POISON CENTER or doctor/physician.
56201CLP/1
Page n. 1 of15
Safety Data Sheet
CLEANER & DEGREASER
Special Provisions:
EUH210 Only for professional use. Safety data sheet available on request.
Contains
SODIUM DODECYLBENZENE SULFONATE
SODIUM METASILICATE PENTAHYDRATE
ISOTRIDECANOL ETHOXYLATED
Product contents:
soap, anionic surfactants, phosphates, non-ionic surfactants <5%
Special provisions according to Annex XVII of REACH and subsequent amendments:
None
56201CLP/1
Page n. 2 of15
Safety Data Sheet
CLEANER & DEGREASER
56201CLP/1
Page n. 3 of15
Safety Data Sheet
CLEANER & DEGREASER
The mixture does not contain ingredients classified as explosive according to EC Regulation
1272/2008 (CLP).
56201CLP/1
Page n. 4 of15
Safety Data Sheet
CLEANER & DEGREASER
56201CLP/1
Page n. 5 of15
Safety Data Sheet
CLEANER & DEGREASER
Use protective gloves that provides comprehensive protection, e.g. P.V.C., neoprene or
rubber. (EN 388 - EN 374 protection factor 6, corresponding to a breakthrough time >480
minutes).
Due to great diversity of types, observe the operating instructions of the manufacturer with
respect to substances listed in paragraph 3.2.
Respiratory protection:
Not needed for normal use.
Thermal Hazards:
The product is not flammable or explosive - see paragraph 2.1. The product contains no
explosive components.
Until the revision date of this document, no adverse effects and symptoms to exposure of the
product are known, including chemical reactivity and instability.
Environmental exposure controls:
Until the revision date of this document, no adverse effects and symptoms to exposure of the
product are known, including chemical reactivity and instability.
See also section 6.2.
Appropriate engineering controls:
No further technical checks suitable for your product under normal conditions.
See also section 1.2, section 7 and Exposure Scenario - Annex I of this document.
56201CLP/1
Page n. 6 of15
Safety Data Sheet
CLEANER & DEGREASER
56201CLP/1
Page n. 7 of15
Safety Data Sheet
CLEANER & DEGREASER
Until the revision date of this document, no adverse effects and symptoms to exposure of the
product are known, including chemical reactivity and instability.
56201CLP/1
Page n. 8 of15
Safety Data Sheet
CLEANER & DEGREASER
a) acute toxicity:
Test: LD50 - Route: Oral - Species: Rat > 300 mg/kg - Source: OECD 423
Test: LD50 - Route: Skin - Species: Rat > 2000 mg/kg - Source: OECD 402
b) skin corrosion/irritation:
Test: Skin Irritant - Route: Skin - Species: Rabbit Negative - Source: OECD 404
c) serious eye damage/irritation:
Test: Eye Corrosive - Species: Rabbit Positive - Source: OECD 405
ETHOXYLATED FATTY ALCOHOL PHOSPHORIC ESTER - CAS: 68071-35-2
a) acute toxicity:
Test: LD50 - Route: Oral > 2000 mg/kg
b) skin corrosion/irritation:
Test: Skin Irritant - Route: Skin Positive
c) serious eye damage/irritation:
Test: Eye Irritant Positive
2-(2-BUTOXYETHOXY)ETHANOL - CAS: 112-34-5
a) acute toxicity:
Test: LD50 - Route: Oral - Species: Mouse = 2410 mg/kg
Test: LD50 - Route: Skin - Species: Rabbit = 2764 mg/kg
Test: LC50 - Route: Inhalation Vapour - Species: Rat > 29 ppm - Duration: 2h
b) skin corrosion/irritation:
Test: Skin Irritant No - Source: OECD 404
c) serious eye damage/irritation:
Test: Eye Irritant Yes - Source: OECD 405
d) respiratory or skin sensitisation:
Test: Skin or Resp. Sensitization Negative
e) germ cell mutagenicity:
Test: Mutagenesis Negative
f) carcinogenicity:
Test: Carcinogenicity Negative
g) reproductive toxicity:
Test: Reproductive Toxicity Negative
56201CLP/1
Page n. 9 of15
Safety Data Sheet
CLEANER & DEGREASER
The surfactant(s) contained in this preparation complies with the biodegradability criteria laid
down in Regulation (EC) No 648/2004 on detergents. All supporting data are kept available to
the competent authorities of the Member States and will be provided to those authorities if
they so request or at the request of a detergent manufacturer.
12.3. Bioaccumulative potential
Until the revision date of this document, are not available experimental data on the mixture.
Below are reported, if available, the eco-toxicological information of the components listed in
paragraph 3.2.
ISOTRIDECANOL ETHOXYLATED - CAS: 69011-36-5
Bioaccumulation: Not bioaccumulative
2-(2-BUTOXYETHOXY)ETHANOL - CAS: 112-34-5
Bioaccumulation: Not bioaccumulative - Test: Kow - Partition coefficient 0.56
12.4. Mobility in soil
Until the revision date of this document, are not available experimental data on the mixture.
Below are reported, if available, the eco-toxicological information of the components listed in
paragraph 3.2.
Not applicable
12.5. Results of PBT and vPvB assessment
vPvB Substances: None - PBT Substances: None
12.6. Other adverse effects
Until the revision date of this document, unknown adverse effects and symptoms towards the
environment.
56201CLP/1
Page n. 10 of15
Safety Data Sheet
CLEANER & DEGREASER
14.1. UN number
ADR-UN Number: 1760
IATA-UN Number: 1760
IMDG-UN Number: 1760
14.2. UN proper shipping name
ADR-Shipping Name: CORROSIVE LIQUID, N.O.S. (sodium metasilicate
pentahydrate)
IATA-Shipping Name: CORROSIVE LIQUID, N.O.S. (sodium metasilicate
pentahydrate)
IMDG-Shipping Name: CORROSIVE LIQUID, N.O.S. (sodium metasilicate
pentahydrate)
14.3. Transport hazard class(es)
ADR-Class: 8
ADR - Hazard identification number: 80
IATA-Class: 8
ADR/IMDG/IATA-Label: 8
IMDG-Class: 8
14.4. Packing group
ADR-Packing Group: III
IATA-Packing group: III
IMDG-Packing group: III
14.5. Environmental hazards
ADR-Enviromental Pollutant: No
IMDG-Marine pollutant: No
14.6. Special precautions for user
ADR-Subsidiary risks: -
ADR-S.P.: 274
ADR-Transport category (Tunnel restriction code): E
IATA-Passenger Aircraft: 852
IATA-Subsidiary risks: -
IATA-Cargo Aircraft: 856
IATA-S.P.: -
IATA-ERG: 8L
IMDG-S.P.: 223 274
IMDG-EmS: F-A , S-B
IMDG-Subsidiary risks: -
IMDG-Stowage and handling: Category A
IMDG-Segregation: SW2
56201CLP/1
Page n. 11 of15
Safety Data Sheet
CLEANER & DEGREASER
14.7. Transport in bulk according to Annex II of Marpol and the IBC Code
Not applicable
56201CLP/1
Page n. 12 of15
Safety Data Sheet
CLEANER & DEGREASER
Classification and procedure used to derive the classification for mixtures according to Regulation
(EC) 1272/2008 [CLP]:
This document was prepared by a competent person who has received appropriate training.
Main bibliographic sources:
ECDIN - Environmental Chemicals Data and Information Network - Joint Research Centre,
Commission of the European Communities
SAX's DANGEROUS PROPERTIES OF INDUSTRIAL MATERIALS - Eight Edition - Van
Nostrand Reinold
The information contained herein is based on our state of knowledge at the above-specified date. It
refers solely to the product indicated and constitutes no guarantee of particular quality.
It is the duty of the user to ensure that this information is appropriate and complete with respect to
the specific use intended.
This MSDS cancels and replaces any preceding release.
56201CLP/1
Page n. 13 of15
Safety Data Sheet
CLEANER & DEGREASER
56201CLP/1
Page n. 14 of15
Safety Data Sheet
CLEANER & DEGREASER
ANNEX I
PROFESSIONAL PRODUCT – DETERGENT FOR HARD SURFACES
Note:
56201CLP/1
Page n. 15 of15