Seed Germination and Storage Of: Cycas Taitungensis (Cycadaceae)

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 11

Taiwan J For Sci 27(1): 1-11, 2012 1

Research paper

Seed Germination and Storage of


Cycas taitungensis (Cycadaceae)
Ching-Te Chien,1,2) Shun-Ying Chen,1) Shu-Hwa Chang,1) Jeng-Der Chung1)

ȪSummaryȫ
Cycas taitungensis is endemic to an area of about 290 ha in Taitung County, eastern Taiwan.
However, this species has been attacked by a scale insect (Aulacaspis yasumatsui) and larvae of the
butterfly, cycad blue (Chilades pandara peripatria), and many plants have died in the last 20 yr. To
establish ex situ conservation of C. taitungensis, seeds were collected from a managed plantation
and the Cycas taitungensis Nature Reserve for germination. Some of the seeds from the plantation
were stored at 5ʨ for 8 and 16 mo and germinated at 30/20ʨ to test germinability. The embryo
length was measured during seed incubation at 25/15 and 30/20ʨ. Germination of seeds from
2007 from the plantation began in weeks 17~18, and final germination was about 58~60L at 30/20,
25/15, and 25ʨ incubation. Germination of seeds from 2008 from the same plantation began in
week 18, and final germination percentages were 13, 64, 75, and 84L at 20/10, 25/15, 30/20, and
25ʨ incubation temperatures, respectively. Thus, favorable germination temperatures were 30/20
and 25ʨ. Initial germination of seeds from 7 individual plants from the Nature Reserve extended
from weeks 3 to 18, and final germination ranged 30~88L. These differences may have been due
to the wide range in time of pollination in the Nature Reserve, thus resulting in different degrees of
seed maturity. Fresh seeds air-dried for 24 h and stored at 5ʨ for 16 mo retained their original ger-
mination, whereas seeds stored with moist moss at 5ʨ for 16 mo showed decreased germination
from 73L (fresh seeds) to 50L. Cold storage at 5ʨ shortened the time to begin seed germination
regardless of the storage conditions with or without moist moss. The underdeveloped embryo of C.
taitungensis seeds must increase in length by about 117L before seed germination can occur. We
concluded that seeds of C. taitungensis exhibit morphophysiological dormancy, a high temperature
at 30/20 or 25ʨ increases seed germination, and air-dried seeds can be stored at 5ʨ for at least 16
mo.
Key words: Cycas taitungensis, morphophysiological dormancy, seed germination, seed storage, un-
derdeveloped embryo.
Chien CT, Chen SY, Chang SH, Chung JD. 2012. Seed germination and storage of Cycas taitun-
gensis (Cycadaceae). Taiwan J For Sci 27(1):1-11.

1)
Silviculture Division, Taiwan Forestry Research Institute, 53 Nanhai Rd., Taipei 10066, Taiwan. ‫ݔ‬
ཿၑᡜ‫ݔيܛ‬ಣȂ10066ѯіҀࠓ੖ၰ53ဵȄ
2)
Corresponding author, e-mail:chien@tfri.gov.tw ೾ଊձ޲Ȅ
Received July 2011, Accepted November 2011. 2011Ԓ7Уଛቸ 2011Ԓ11У೾ႇȄ
2 Chien et al.˕Germination and storage of Cycas seeds

ः‫ف‬ൣ֚

ѯ‫ݎ‬ង២ᆎφึ߄ᇅᓾᙡ
ᙐኋ኉ 1,2) ച๴ऽ 1) ஼ు๽1) ᗪਐ኉ 1)
ᄣ ्

ѯ‫ݎ‬ង២࢑ѯᢋ੬ԥᆎෛ‫ޑ‬Ȃ༊ϸҁӶѯ‫ݎ‬ᑫᗓୣȂ८ᑗङ290ϵധȄႇџ20Ԓ໣೩Ӽ‫ޠ‬ѯ‫ݎ‬ង
២ӱ᎐‫ڨ‬ҪᎉࣾϮ෧ᙬ‫ݎڸ‬ହង២ϊԹፇ҃ᙬ࣐ড়ԬκȄ࣐࡛Ҵѯ‫ݎ‬ង២ୣѵߴ‫ي‬Ȃ௵Ս‫ݔ‬ଡ଼‫׌‬೪ဋ
‫ޠ‬ѯ‫ݎ‬ង២Սดߴ੽ୣ‫ڸ‬ѯ‫ݎ‬τ‫ݢ‬໑Κ೏‫ؾ‬΢စᕋ‫ޠ‬ѯ‫ݎ‬ង២਼ᆎୣ‫ޠ‬ᆎφȂϸրໍ՘ϛӤྤ࡚‫ޠ‬ᆎ
φึ߄ၑᡜȄѫѵȂ௵Ս‫ؾ‬΢਼ᆎୣ‫ޠ‬ᆎφഌӌܼ5ʨᓾᙡ8ঐУ‫ڸ‬16ঐУȂ‫ڦ‬яࡤӶ30/20ʨίึ߄Ȃ
пᕤ၍ѯ‫ݎ‬ង២ᆎφᓾᙡࡤϟึ߄૗ΩȄᆎφथߞ࡚໕ขҼӶᆎφክᆎࡤӤਣໍ՘Ȅ2007Ԓ௵Ս‫ؾ‬
΢਼ᆎୣᆎφ໡ۗึ߄ਣ໣࢑Ӷಒ17~18໋Ȃึ߄౦Ӷ30/20ȃ25/15‫ڸ‬25ʨίႁ58~60 L ȇ௵ՍӤӵୣ
2008Ԓᆎφ໡ۗึ߄ਣ໣࢑Ӷಒ18໋Ȃึ߄౦Ӷ25ʨίഷାႁ84 L ȂӶ30/20ȃ25/15‫ڸ‬20/10ʨίϸր
࣐75ȃ64‫ڸ‬13 L ȄӱԫȂᎍӬѯ‫ݎ‬ង២ᆎφึ߄ྤ࡚࣐30/20‫ڸ‬25ʨȄ௵Սѯ‫ݎ‬ង២Սดߴ੽ୣ7ੂѯ
‫ݎ‬ង២ᆎφȂ໡ۗึ߄ਣ໣௄ಒ3໋Վಒ18໋ϛ๊Ȃйึ߄౦௄30 L Վ88 L ϛ๊Ȃ೼‫ٳ‬ৰ౵Ѡ૗࢑ߴ੽
ୣҕੂ໣‫ڨ‬લਣ໣ϛΚȂᏳयᆎφԚዤ࡚ϛӤ‫ܛ‬Жକ‫ޠ‬Ȅѯ‫ݎ‬ង២ᆎφစࡊϲޫ੊ୂᕎ24ϊਣȂܼ5ʨ
ᓾᙡ16ঐУࡤϬ૗ߴࡼ঩ԥུᘁᆎφ‫߄ึޠ‬౦ȂկᆎφᇅᕇЬीెӬܼ5ʨᓾᙡ16ঐУȂึ߄౦௄ུᘁ
ᆎφ73 L ७Վ50 L ȂᡘұᆎφୂᙡЩᕇᙡ‫ٺ‬Ȅୂȃᕇᆎφᓾᙡܼմྤ5ʨࣲ૗ᕼ฼໡ۗึ߄‫ޠ‬ਣ໣Ȅѯ
‫ݎ‬ង២ᆎφԥึ‫ي‬ϛ‫׈‬ӓथȂथߞ࡚҇໹ቩђङ1.17ॼȂथ਴Ϙཽऐખᆎҫึ߄Ȅ๗፤ѯ‫ݎ‬ង២ᆎφ
ԥ‫ם‬ᄙҢ౪‫ޠ‬ӅએȂାྤ30/20ʨ‫ڸ‬25ʨቩђᆎφึ߄౦Ȃᆎφജୂ24ϊਣࡤѠᓾᙡ5ʨՎЎ16ঐУȄ
ᜱᗥມȈѯ‫ݎ‬ង២ȃ‫ם‬ᄙҢ౪‫ޠ‬Ӆએȃᆎφึ߄ȃᆎφᓾᙡȃึ‫ي‬ϛ‫׈‬ӓथȄ
ᙐኋ኉ȃച๴ऽȃ஼ు๽ȃᗪਐ኉Ȅ2012Ȅѯ‫ݎ‬ង២ᆎφึ߄ᇅᓾᙡȄѯᢋ‫ݔ‬ཿऌᏱ27(1):1-11Ȅ

INTRODUCTION
Cycas taitungensis Shen, Hill, Tsou & Euphorbiaceae (Tzeng et al. 2005). The plant
Chen, previously misidentified as C. taiwani- communities in the Nature Reserve were clas-
ana, is endemic to a specific area of about sified into 9 types by a matrix cluster analysis
290 ha in Taitung County, eastern Taiwan and the dominant tree species were Cyclo-
(22°51’30”~22°52’30”N, 120°57’30”~ balanopsis glauca, Zelkova serrata, Liq-
121°01’00”E) (Shen et al. 1994). The Cycas uidambar formosana, Fraxinus formosana,
taitungensis Nature Reserve was established Cinnamomum philippinense, Lagerstroemia
by the Forestry Bureau, Council of Agricul- subcostata, etc. (Tzeng et al. 2005). Cycas
ture, Executive Yuan, Taiwan in 1970 and taitungensis has been attacked by cycad scale
announced in accordance with the Cultural insects (Aulacaspis yasumatsui Takagi) and
Heritage Preservation Act of Taiwan in 1986. larvae of the butterfly, cycad blue (Chilades
The flora in the Cycas taitungensis Nature pandara peripatria), and many Cycad plants
Reserve was studied, and 293 species were have died in the last 20 yr (Hsu 1989, Lan
found with the 5 largest families being the Fa- 1998, Bailey et al. 2010). Investigations in
baceae, Asteraceae, Poaceae, Lauraceae, and the Nature Reserve showed that many scale
Taiwan J For Sci 27(1): 1-11, 2012 3

insects were found year-round on leaves, in the world are threatened, and some of
twigs, and rachides, but larvae of cycad them are in danger of extinction (Donaldson
blue were found in spring when new leaves 2003). This paper provides information on
occurred. the storage of Cycad seeds and propagation
Depending on the species, germination of the taxon from seeds for plantation use to
of Cycas seeds can extend for 4~12 mo after increase populations in the future.
sowing, and there is no need to scarify the
hard seed coat (Broome 2011). Field seed MATERIALS AND METHODS
collection of several Australian Cycas spe-
cies germinated with no treatment, and they Seed collection and handling
can germinate only after the embryo is fully Mature reddish-orange to vermilion
developed (Dehgan and Schutzman 1989). seeds of C. taitungensis were collected both
Thus, one objective of our study was to deter- from the Cycas taitungensis Nature Reserve,
mine the best temperature to germinate seeds Taitung County on 19 December 2007 and
of C. taitungensis. from a managed plantation in Tawu (22°22’N,
Cycas seeds generally are large, the 120°54’E), Taitung County, Taiwan on 8~10
weight per seed is 6.3~13.7 g (Zheng 2000), December 2007 and 2008 (Fig. 1). Seeds from
and seeds cannot be dried when they are the Nature Reserve were collected and indi-
stored, otherwise germination decreases (De- vidually numbered for the germination test.
hgan 1999, Broome 2011). The optimum stor- Seeds from > 20 plants of the the managed
age conditions to extend Cycas seed longevity plantation each year were mixed as a seed lot
and reduce storage costs must be determined. for the germination test. The seed consists of
Thus, our second objective was to find the an embryo surrounded by a large megagame-
best way to store the seeds for more than 1 yr tophyte, a stony sclerotesta, and a fleshy outer
without loss of germinability. sarcotesta. Seeds without the fleshy sarcotesta
A seed that does not have the capacity to collected from managed plantation in 2008
germinate in 30 d under suitable environmen- were 49.79ɲ2.55 mm long, 32.32ɲ1.69 mm
tal conditions such as temperature, light, and wide, and 24.08ɲ1.17 mm thick (n = 20) (Fig.
water is termed dormant (Baskin and Baskin 2). There are 35 seeds L-1 and 52 seeds kg-1.
1998, 2004). Five classes of seed dormancy Due to scale insects and fungi present
are recognized, i.e., morphological dormancy, on the seed surfaces, all seeds were treated
physiological dormancy, morphophysiologi- with 2000 ppm Benomyl (a fungicide and
cal dormancy, physical dormancy, and com- pesticide) for 1 h and air-dried in the labora-
bined dormancy (physical + physiological tory for 24 h before using them in subsequent
dormancy) (Baskin and Baskin 2004). Seeds experiments.
exhibiting both morphological and morpho-
physiological dormancy have underdeveloped Effect of temperature regimes on seed
embryos that must grow inside the seeds germination
before the radicle emerges. Thus, our third Fresh seeds with dried sarcotesta collect-
objective was to determine if the seeds of C. ed from the managed plantation in 2007 and
taitungensis exhibit morphological or mor- 2008 and mixed with moist sphagnum moss
phophysiological dormancy. (cut into small pieces) were placed in sealable
Approximately 82L of Cycad species polyethylene (PE) bags and incubated at 12
4 Chien et al.˕Germination and storage of Cycas seeds

A B

C D

Fig. 1. Cycas taitungensis in a managed plantation from which old leaves are pruned in
winter (A), in the Cycas taitungensis Nature Reserve (B) with many cycad scale insects on
the leaves, twigs, and rachides (C), and a cycad blue butterfly laying eggs on growing leaves
(D).

A B

C D

Fig. 2. Intact seed of Cycas taitungensis with a reddish-orange sarcotesta (A), longitudinal
section of a fresh seed with an underdeveloped embryo (B), seed with a fully grown embryo
before root emergence (C), and a seed after radicle emergence (D). The scale marks are
millimeters.
Taiwan J For Sci 27(1): 1-11, 2012 5

h/12 h of alternating temperature regimes of above for the germination test. Growth of em-
30/20, 25/15, and 20/10ʨ and at a constant bryos was measured at 4-wk intervals. Seeds
temperature of 25ʨ. Likewise, fresh seeds were sectioned longitudinally using a mini
collected from the Nature Reserve in 2007 electric saw, and lengths of 5 embryos from
and mixed with moist sphagnum moss in the above 2 incubation temperatures were
PE bags were tested at 30/20ʨ for germi- measured.
nation. The water content of the sphagnum
moss inside the PE bags was about 400L Effect of 5ʨ storage on seed germination
of the dry mass. The daily photoperiod of Fresh seeds (with the sarcotesta intact)
12 h in the incubators (60~80 μmole m-2 s-1, collected from the managed plantation in
400~700 nm) was at the high temperature. 2008 were treated with Benomyl solution
Each treatment consisted of 3 replications of and air-dried in the laboratory for 24 h (as
25 seeds each, except seeds from the Nature described above) and then separated into 2
Reserve which consisted of 2 replications of portions: 1 portion of seeds mixed with moist
10~28 seeds each depending on the collection sphagnum moss was placed in sealable PE
number. The outer sarcotesta was removed bags and stored at 5ʨ in darkness for 8 and
after several weeks of incubation. Germina- 16 mo. The moist moss-stored seeds at 5ʨ
tion, i.e., a radicle at least 2 mm long, was were opened each month to allow the seeds to
recorded weekly for 32~60 wk. Results are breathe. The other portion of seeds in sealed
expressed as a germination percentage (L). PE bags was directly stored at 5ʨ for 8 and
Due to the coarse nature of the sphagnum, 16 mo without moist sphagnum moss. These
most seeds received some light, but at any stored seeds were incubated at 30/20ʨ for a
given point in time a few may have been in germination test. Water contents in the sclero-
darkness. However, at weekly intervals the testa and megagametophyte + embryo of the
contents of each bag were poured out on a fresh seeds were 12.9 and 43.5L on a fresh-
table to facilitate examination of seeds for weight (FW) basis, respectively, as deter-
germination. After germination was moni- mined by oven drying for 17 h at 103ʨ (ISTA
tored, seeds and the sphagnum moss were 1999).
returned to the bag, resulting in a re-shuffling
of seeds with regard to their position in the Statistical analysis
sphagnum and thus the light they received. Means (3 replicates) and standard errors
Consequently, all seeds were in light part of the germination percentage were calculated
(or all) of the time the lights were on in the based on treated seeds. Means of the percent
incubator. germination were compared by an analysis of
variance (ANOVA) and the least significance
Embryo growth measurement difference (LSD) test at the 0.05 level of sig-
To monitor embryo growth, seeds of C. nificance (SAS Institute, Cary, NC). Percent-
taitungensis collected from the managed plan- age data were arcsine square-root-transformed
tation in 2007 with the sarcotesta removed before analysis, but only non-transformed
were mixed with moist sphagnum moss, data are shown in the figures. Embryo length
placed in sealable PE bags, and incubated data based on 5 seeds of an incubation time
at 30/20 and 25/15ʨ for 8 mo. Incubation at 30/20 and 25/15ʨ were measured, and
conditions were the same as these described means and standard errors were calculated.
6 Chien et al.˕Germination and storage of Cycas seeds

RESULTS 5). For example, seeds from a plant began to


germinate in week 3, and seeds of other plants
Effect of temperature regimes on seed began to germinate in weeks 7, 10, and 18.
germination
Germination of seeds collected from the Embryo growth measurement
managed plantation in 2007 began in weeks The mean (ɲS.E.) length of embryos
17~18, and final germination was 58~60L of fresh seeds collected from the managed
after incubation at 30/20, 25/15, and 25ʨ plantation in 2008 was 8.50ɲ0.45 mm, and
for 56 wk (Fig. 3). However, the germination the critical embryo length just before the seed
rate was lower at 25/15ʨ than at 30/20 and germinated was 18.42ɲ1.06 mm (Figs. 2,
25ʨ. Seeds from the same plantation in 2008 6). Thus, embryo length increased 117L be-
incubated at 30/20, 25/15, 20/10, and 25ʨ fore seeds germinated. After 16 wk, embryo
for 59 wk germinated to 75, 64, 13, and 84L, growth in seeds was faster at 30/20ʨ than at
respectively (Fig. 4). The optimum tempera- 25/15ʨ (Fig. 6).
tures for seed germination were 30/20 and
25ʨ. Effect of 5ʨ storage on seed germination
Seeds collected from 7 plants of the Germination of air-dried seeds stored at
Cycas taitungensis Nature Reserve in 2007 5ʨ for 8 and 16 mo retained the same per-
germinated to 30~88L, and the time to begin- centages compared to seeds without storage,
ning of germination was in weeks 3~18 (Fig. but those mixed with moist sphagnum at 5ʨ

Fig. 3. Effect of temperature on the germination of Cycas taitungensis seeds collected from
a managed plantation in 2007. Seeds mixed with sphagnum moss were incubated at 30/20,
25/15 and 25ʨ for germination. Vertical bars areɲthe standard error.
Taiwan J For Sci 27(1): 1-11, 2012 7

Fig. 4. Effect of temperature on the germination of Cycas taitungensis seeds collected from
a managed plantation in 2008. Seeds mixed with sphagnum moss were incubated at 30/20,
25/15, 20/10 and 25ʨ for germination. Vertical bars areɲthe standard error. Points with
different letters significantly differ at 59 wk of incubation (LSD, p = 0.05).

Fig. 5. Cumulative germination percentages of Cycas taitungensis seeds collected from the
Nature Reserve in 2007. Seeds mixed with sphagnum moss were incubated at 30/20ʨ for
germination. Each number represents a single female plant.
8 Chien et al.˕Germination and storage of Cycas seeds

Fig. 6. Effect of temperature on embryo growth of Cycas taitungensis seeds collected from a
managed plantation in 2007. Seeds mixed with sphagnum moss were incubated at 30/20 and
25/15ʨ, respectively, and embryo length was measured at 4-wk intervals. Vertical bars are
ɲthe standard error.

decreased by about 18L after 8 and 16 mo of DISCUSSION


storage (Fig. 7). Final germination percent-
ages between dry-stored seeds and moist- The optimal temperatures for maximum
sphagnum-stored seeds significantly differed germination percentage and rate in seeds of
after 50 wk of incubation, but the final germi- C. taitungensis were 30/20 and 25ʨ. Seeds
nation percentages of seeds stored for 8 and from the managed plantation began to germi-
16 mo within the same storage treatment did nate at these 2 temperature regimes in weeks
not significantly differ. Storage shortened the 17~18, and final germination ranged 58~60L
time to initiate seed germination from week in 2007 and 75~84L in 2008, whereas seeds
20 of fresh seeds to week 14 of 16-mo air- from 7 individual plants at the Nature Reserve
dried stored seeds, or to week 10 of 16-mo began to germinate at 30/20ʨ from weeks 3
moist-sphagnum-stored seeds (Fig. 7). After to 18, and final germination ranged 30~88L.
16 mo of storage, water contents in the sclero- These differences in seed germination from
testa and megagametophyte + embryo of the the Nature Reserve may have been due to the
moist-sphagnum-stored seeds were 28.9 and wide range in times of pollination and thus to
45.1L, respectively; water contents in the different degrees of seed maturity and embryo
sclerotesta and megagametophyte + embryo sizes (5~22 mm in length) of seeds. In the
of dry-stored seeds were 14.9 and 44.5L, re- managed Cycas plantation, old leaves are cut
spectively. off after seeds are harvested and before new
Taiwan J For Sci 27(1): 1-11, 2012 9

Fig. 7. Effect of storage at 5ʨ on germination of Cycas taitungensis seeds collected from a


managed plantation in 2008. Stored seeds mixed with sphagnum moss were incubated at
30/20ʨ for germination. Vertical bars areɲthe standard error. Points with different letters
significantly differ at 50 wk of incubation (LSD, p = 0.05).

buds emerge in January to reduce the amount er, Cycas seeds do not exhibit epicotyl mor-
of scale insects and avoid cycad blue laying phophysiological dormancy because shoots
eggs. Thus, C. taitungensis plants in the man- emerged in 2 wk.
aged plantation flower at the same time, and There are 9 levels of morphophysiologi-
seeds ripen in October through November and cal dormancy, i.e., non-deep simple, interme-
are dispersed in December. diate simple, deep simple, non-deep simple
Fresh seeds of C. taitungensis have a dif- epicotyl, deep simple epicotyl, deep simple
ferentiated (root and shoot can be observed) double, non-deep complex, intermediate com-
embryo, and the length of the small underde- plex, and deep complex (Baskin and Baskin
veloped embryo had increased about 1.2-fold 2004, Baskin et al. 2008, 2009). Which one of
inside the mature seed before the root and the 9 levels of morphophysiological dorman-
shoot emerge (Figs. 2, 6). Therefore, Cycas cy do seeds of C. taitungensis exhibit? Based
seeds exhibit morphological dormancy. Since on the temperature requirements for embryo
the seeds also required > 30 d for germina- growth and breaking physiological dormancy,
tion, we concluded that seeds exhibit both seeds of C. taitungensis do not require cold
morphological and physiological dormancy, stratification for germination, and embryo
i.e., morphophysiological dormancy. Howev- growth occurs at warm temperatures, leading
10 Chien et al.˕Germination and storage of Cycas seeds

to the conclusion that the seeds exhibit non- seeds (which produces a rattling sound when
deep simple morphophysiological dormancy. shaken) was recognized as indicating that the
Seeds without moist sphagnum stored seeds are inviable. In the present study, we
dry at 5ʨ for 16 mo retained their high ger- determined that wet storage of seeds of C.
minability, and the final germination percent- taitungensis can extend seed longevity, but
age was nearly the same as those of fresh further study is needed to find the optimal
seeds. Meanwhile, dry-stored seeds at 5ʨ seed storage conditions.
germinated rapidly, and the time to initiate Seed dispersal of C. taitungensis occurs
germination was shortened. However, seeds in winter. However, newly dispersed seeds re-
mixed with moist sphagnum stored at 5ʨ quire higher temperatures, e.g., 30/20 or 25ʨ
showed a decreased germination percentage, for germination. We speculated that dispersed
although the time to initiate seed germination seeds may germinate in summer or fall if suit-
was also shortened, indicating that these seeds able environmental factors such as water and
may have become too wet during cold storage light are available. To propagate C. taitungen-
with moist sphagnum. We actually measured sis plants, seeds can be air-dried and stored
the water content of seeds after 16 mo of cold at 5ʨ for several months until the next warm
storage and found that the water content in the season. Under this air-dried storage condition,
sclerotesta had increased from 12.9L of fresh seeds can be stored for at least 16 mo, which
seeds to 28.9L of seeds mixed with moist not only extends the storage time but also
sphagnum, but the water contents of the mega- increases the germination rate (by decreasing
gametophyte + embryo were similar. Thus, we the incubation time).
recommend that Cycas seeds be air-dried for
24 h after harvest and sterilized, placed in seal- ACKNOWLEDGEMENTS
able PE bags, and stored at 5ʨ. If water drops
in inner PE bag are found during storage, these The authors thank Yen-Wei Chang,
seeds need to be air-dried again overnight. Chang-Yen Chen, Wen-Yu Hsu, Ta-Yuan
Seeds are mainly divided into 2 catego- Chien, and Cheng-Yu Yeh, Taiwan Forestry
ries on the basis of storage behavior: ortho- Research Institute, for technical assistance.
dox and recalcitrant (Roberts 1973, Hong We also thank personnel from the Taiwan
and Ellis 1996). Orthodox seeds have a low Forestry Bureau, Council of Agriculture,
water content following maturation, and can Executive Yuan, Taiwan for helping with
be dried to 5L and stored at subzero tempera- seed collection of Cycas taitungensis. This
tures for long periods of time without a loss research was supported by 2 grants (96AS-
of viability, whereas recalcitrant seeds shed 11.2.3-F1-e4 and 97AS-11.2.4-F1-G1) from
their high water contents and lose viability the Council of Agriculture, Executive Yuan,
rapidly if they are dried to a water content of Taiwan. The paper is dedicated to our good
< 20~30L. Cycas seeds were described as ex- colleague the late Dr. Yu-Pin Cheng for
hibiting recalcitrant storage behavior because partaking in the C. taitungensis program. A
seeds cannot be dehydrated to a water content portion of these data was presented at Seed
below a critical minimum (Dehgan 1999, Ecology III, the Third International Society
Broome 2011). Dehgan and Yuen (1983) also for Seed Science Meeting on Seeds and the
indicated that a complete separation between Environment, which was held at Salt Lake
the megagametophyte and sclerotesta in City, UT on 20~24 June 2010.
Taiwan J For Sci 27(1): 1-11, 2012 11

LITERATURE CITED cad Specialist Group. Gland, Switzerland and


Cambridge, UK: IUCN. 86 p.
Bailey R, Chang NT, Lai PY, Hsu TC. 2010. Hong TD, Ellis RH. 1996. A protocol to de-
Life table of cycad, Aulacaspis yasumatsui termine seed storage behaviour. Rome, Italy:
(Hemiptera: Diaspididae), reared on Cycas in International Plant Genetic Resources Institute.
Taiwan. J Asia-Pacific Entomol 13:183-7. 62 p.
Baskin CC, Baskin JM. 1998. Seeds: ecol- Hsu YF. 1989. Systematic position and de-
ogy, biogeography, and evolution of dormancy scription of Chilades peripatria sp. nov. (Lepi-
and germination. San Diego, CA: Academic doptera: Lycaenidae). Bull Inst Zool Acad Sin
Press. 666 p. 28:55-62.
Baskin CC, Chien CT, Chen SY, Baskin JM. ISTA (International Seed Testing Associa-
2008. Germination of Viburnum odoratissi- tion). 1999. International rules for seed testing.
mum seeds: a new level of morphophysiologi- Seed Sci Technol 27 (Suppl):1-333.
cal dormancy. Seed Sci Res 18:179-84. Lan PL. 1998. The population biology of Chi-
Baskin CC, Chien CT, Chen SY, Baskin JM. lades pandava peripatria (Lepidoptera: Lycae-
2009. Epicotyl morphophysiological dormancy nidae): the fluctuation of population. Master’s
in seeds of Daphniphyllum glaucescens, a thesis. Taipei, Taiwan: National Taiwan Nor-
woody member of the Saxifragales. Int J Plant mal Univ. 60 p.
Sci 170:174-81. Roberts EH. 1973. Predicting the storage life
Baskin JM, Baskin CC. 2004. A classifica- of seeds. Seed Sci Technol 1:499-514.
tion system for seed dormancy. Seed Sci Res Shen CF, Hill KD, Tsou CH, Chen CJ. 1994.
14:1-16. Cycas taitungensis C. F. Shen, K. D. Hill, C.
Broome T. 2011. Optimizing cycad seed ger- H. Tsou & C. J. Chen, sp. nov. (Cycadaceae),
mination. Available at: http://cycadjungle.8m. a new name for the widely known cycad spe-
com. Accessed 12 March 2011. cies endemic in Taiwan. Bot Bull Acad Sinica
Dehgan B. 1999. Propagation and culture of 35:133-40.
cycads: a practical approach. Acta Hortic 486: Tzeng HY, Chiu CA, Sheu JK, Wang CC,
123-31. Ou CH, Lu KC. 2005. Study on the flora of
Dehgan B, Schutzman B. 1989. Embryo de- Cycas taitungensis Nature Reserve, Taiwan. Q
velopment and germination of Cycas seeds. J J For Res 27(4):1-22.
Am Soc Hort Sci 114(1):125-9. Zheng YS. 2000. Cycas L. (Cycadaceae). In:
Dehgan B, Yuen CKKH. 1983. Seed mor- the National Service Center for State-Owned
phology in relation to dispersal, evolution, and Forest Farms and Forest Seed and Seedling Af-
propagation of Cycas L. Bot Gaz 144:412-8. fairs of the Forestry Ministry, editor. Seeds of
Donaldson JS. 2003. Cycads: status survey woody plants in China. Beijing, China: China
and conservation action plan. IUCN/SSC Cy- Forestry Publishing House. p 1-4. [in Chinese].

You might also like