Professional Documents
Culture Documents
Redundant Menmber Design
Redundant Menmber Design
TECHNOLOGY
BE SEM :-6th
DEPARTMENT OF CIVIL ENGINERING
Active Learning Assignment of
ELEMENTARY STRUCTURAL DESING
(STEEL)
Prepared By:
PRAJAPATI HIMANSU 140120106085
Guided By
Prof. Mohammed Challawala
Introduction
Typical joining of the components is done by two ways
1. Lacing
2. Battening
normally,=45 is taken
F=Vt / 2sin ϴ
F=Vt/4 sin ϴ
Pd = (b x t) x fcd
i.e. pd > F …. OK
(8) Check for Tensile Strength
Or
Whichever is less.
The bolted connection for lacing may be two types as given case.
16 dia. Bolts = 29 kN
(10) Overlap
along either edge of lacing bar shall not be less than , four times
the thickness of the lacing bar (or)
The thickness of the element of main member, whichever is
less.
Battening
Compression member can also be built up intermediate
horizontal connecting plates or angle connecting two or four
elements of column .these horizontal connecting plates are
called battens.
simultaneous
Longitudinal shear
Vb = Vt C / Ns
Moment
M=Vt C / 2N
Where,
(1)