Professional Documents
Culture Documents
Ceragon Microwave Configuration Multi Carrier ABC 2+0
Ceragon Microwave Configuration Multi Carrier ABC 2+0
Ceragon Microwave Configuration Multi Carrier ABC 2+0
Configuration
Multi Carrier ABC 2+0
Note:
1、 This file is suitable for Ceragon 2+0 configuration, and only use ETH RJ-45 as traffic transmission. When
using, please make corresponding changes according to the actual configuration.
2、 In order to prevent the device from being unable to connect, please set remote first.
Before connection over the radio hop is established, it is of high importance to assign the IP-
20 unit a dedicated IP address, by default, a new IP-20 unit has the following IP settings:
IP address: 192.168.1.1
Subnet mask: 255.255.255.0
1 Select Control Panel > All Control Panel Items > Network and Sharing Center.
2 Click Change the adapter settings.
3 Select Local Area Connection > Properties > Internet Protocol Version 4 (TCP/IP), and set
the following parameters:
IP address: 192.168.1.10
Subnet mask 255.255.255.0
No default gateway
4 Click OK to apply the settings.
2. Logging on
1 Open an Internet browser (Internet Explorer or Mozilla Firefox).
2 Enter the default IP address “192.168.1.1” in the Address Bar. The
Login page opens.
3 In the Login window, enter the following:
User Name: admin
Password: admin
4 Click Apply
4. Configuring IP Address
1. Select Platform > Management > Networking > Local. The local Networking
Configuration page opens.
2. Set IPv4 Address: 10.80.1.67
3. IPv4 Subnet Mask: 255.255.255.192
4. Ipv4 Default Gateway: 10.80.1.65
5. Click Apply
1. Select the carrier in the Radio table and click Edit. A separate Radio Parameters page
opens. (Please refer to the site specific frequency license)
4. Select the carrier in the Radio table and click Edit. A separate Radio Parameters page
opens. (Please refer to the site specific frequency license)
2. Select Ethernet: Slot 1, Port 1 and click Edit. Select Admin status: Up
3. Click Appy
2. Click Create Group. The first page of the Create ABC Group wizard opens.
Select Radio > Groups > Multi Carrier ABC. The Multi Carrier ABC page opens.
FiberHome Telkominfra MTD
Address: 30th floor, Suite 7, APL Tower. Jl. LetJend. S.Parman, Kav. 28. West Jakarta 11470
* Repeat Configuring the Multi-Carrier ABC on the FE
2. In the Ethernet Services page, click Add. The Ethernet Services – Add page opens.
3. Service ID: 1
4. Service Type: MP
5. Admin: Operational
6. MAC table size: 131072
7. Default CoS: 0
8. CoS Mode: Preserve-SP-COS-Decision
9. Click Apply
1. Select Service ID 1 MP and then click edit, the Ethernet Services page opens:
Check the setting below:
2. Select Interface location: Ethernet Slot 1, Port 1
3. Attached interface type: Bundle-C
1. Select Ethernet Slot 1 Port 1 and then click Attached VLAN. The Ethernet Services
page opens.
2. Add C-Vlan Encapsulation: 100, 160, 220, 500, 600, 700
1. Select Multi Carrier ABC (Unit Group#1) and then click Attached VLAN. The Ethernet
Services page opens
2. Add C-Vlan Encapsulation: 100, 160, 220, 500, 600, 700