Professional Documents
Culture Documents
Test Tool User's Manual Pico Repeater
Test Tool User's Manual Pico Repeater
The software used for test is Repeater equipment network validation tool.
System requires a combination of local maintenance terminal software to achieve its control
function. Directly set, query, and display real-time alarm information to the base tation RF index
and status parameters . You can operate and maintenance of equipment at any time by the way
of locally, wireless data or text messages.
1.3 Instructions
This section introduce the operation of the software specifically, including software's main
interface and how to local and remote connect GSM digital microwave remote radio systems.
1.3.1Operation preparation
Follow these steps for local or remote computer control.
Repeater device supports local and remote control, for different control methods, operation
and maintenance unit should have different configurations.
1.4. 1 Local communications configuration
As shown below, select the correct PC serial port number (the current connection with
the Repeater Serial port)
:
4、COM port property::
After channel types and serial port set up, click "Open" button. As shown below, set COM
port properties, then click "OK" .
After the success, the print will be as follows in the left bottom.
After the above settings, click the button ,TestTool will send "list of
parameters query" command to the device. In the query process, "query parameter list"
button was grayed out, then you can click "terminate the query" button to stop the queries .
TestTool receive the return packet from the device ,and then display the received data in the
data area.
7、Parameter query:
After query parameter list, click the " " button, TestTool default will send
commands to the device parameters for querying the entire list of parameters , at the same
time display the query data on the TestTool .
Query may be 5 to 30 seconds, please be patient.
After the data query , click the 'Device Information ", " network parameters " respectively
to view the corresponding parameter values.
If you want to query the value of a parameter, only check the box next to the
corresponding parameters, and then click the query button; if you want to set a parameter, only
enter the corresponding value to the corresponding parameters "settings", , and then click the
"Settings" command to complete.
8、Extended mode parameter query:
Operation and Maintenance Unit can divided as sub-normal mode and extended mode .
Normal mode contains most of the requirements of the operator control parameters , such as site
information, network parameters can be set / query item; extended mode contains operators
require additional monitoring parameters and allows manufacturers to customize the
monitoring parameters ,such as gain set, part of the switch settings. TestTool default mode is
normal mode.
First select the "System" → "expansion mode." Check the "extended mode" option. As
shown below:.
Then click the button , TestTool would send "query parameter list"
command to the device. In the query process, "query parameter list" button was grayed out,
then you can click "terminate query" button to stop the queries. TestTool receive the return
packet from the device ,and then display the received data in the data area.
After query parameter list, click the " " button, TestTool default will send
commands to the device parameters for querying the entire list of parameters , at the same time
display the query data on the TestTool .
After the data query , click the 'Device Information "," network parameters " respectively to view the
corresponding parameter values.
The current state is "extended mode", re-select the "System" → "expansion mode",
uncheck the extended model, can be restored to the default mode.
1.Using the debug cable to connect devices and computers, turn on the "TestTool",
and set in accordance .
Click the button , TestTool will query the the device current parameter
values according to the monitoring , and then display. Query may be 5 to 30 seconds, please be
patient.
After query, click the different tab page to view different parameter values.
1.5.3 Page of Machine "alarm and status"