Professional Documents
Culture Documents
# Task Steps Potential Hazards Mitigation Controls: Inspect Insulation, Cables, Connectors,, and PPE
# Task Steps Potential Hazards Mitigation Controls: Inspect Insulation, Cables, Connectors,, and PPE
Hazards controls
Preparation for
sand blasting Unauthorized work Inspect insulation, cables, connectors, , and PPE
& work start-
A certified PTW applicant shall obtain PTW
1 up Conflicting activities
from the concerned authorities
Make sure that there are no conflicting
activities near the worksite before starting
the job
Use regulator to control supply.
Change filter at the advised frequency.
Insufficient air for breathing Monitoring the air and ensure good quality of
Air contaminated. (Breathing air.
Ensure dead man’s device is always in good
Blasting in Operation problem)
operating condition.
2 Improper supply of air. Do not allow workers to play with the sand
Ineffective filters blasting machine
Sand blasting on body part/ Body Make sure sand blasting is done only by trained
injury Locking of dead man’s device personnel
for intermediate inspection Barricade the area to prevent unauthorized entry
Put ‘OFF’ machine first.
3 . Changing the position to Sand blasting on body part (body Always keep the dead man’s device in
cover other area injury) good operating condition.
Trip/fall Machine remain ‘ON’ After work completion of work make sure
all the equipment & tool are properly taken
Locking of dead man’s device back to their storage are
Maintain good housekeeping
Poor housekeeping