Professional Documents
Culture Documents
FFL FFL: Vds 2E 4. Setting Up Machine On Pilot
FFL FFL: Vds 2E 4. Setting Up Machine On Pilot
Safety Instructions.
Safety helmet and safety shoes must be worn to prevent
personal injuries by falling and overturning objects. ffl ffl
4.1 Make sure
the proper adapter head is attached to the feed gear,
the pilot is in vertical position and
the cylinder head is firmly fixed.
If required, change adapter head (see page 15).
4.2 Mount cutting tool.
Clamp cutting insert to insert holder.
Remove clamping screws (8.1.1) from tool slide (8.1) and then use the clamping screws to
attach the cutting tool (C) to the tool slide.
4.3 place machine on the pilot.
Slide machine over the pilot until either the depth stop (1) rests upon the pilot or the cutting
tool (C) contacts the cylinder head.
Caution
The carbide cutting edge is rather brittle.
Take care the cutting edge does not bump against the valve seat or the cylinder head.
4.4 Position cutting edge of cutting tool over the valve seat.
Turn rapid tool adjuster (6) to position cutting edge of cutting tool (C) approximately over
the central portion of the valve seat (S).
Hold machine with one hand and loosen depth stop locking screw (1.1).
Allow machine to slide down until the cutting edge contacts the valve seat lightly.
4.5 Lock depth stop.
Push depth stop (1) downward to ensure proper contact with the pilot and then tighten
depth stop locking screw (1.1)
JL.