Professional Documents
Culture Documents
Safety Data Sheet: 1. Identification of The Substance/Preparation and of The Company/Undertaking
Safety Data Sheet: 1. Identification of The Substance/Preparation and of The Company/Undertaking
Safety Data Sheet: 1. Identification of The Substance/Preparation and of The Company/Undertaking
_____________________________________________________________________________________________
The supplier identified below generated this SDS using the UL SDS template. UL did not test, certify, or approve the substance described in this SDS, and
all information in this SDS was provided by the supplier or was reproduced from publically available regulatory data sources. UL makes no representations
or warranties regarding the completeness or accuracy of the information in this SDS and disclaims all liability in connection with the use of this information
or the substance described in this SDS. The layout, appearance and format of this SDS is © 2014 UL LLC. All rights reserved.
_____________________________________________________________________________________________
Synonyms None
Size 4 lb
Recommended use of the chemical and restrictions on use
2. HAZARDS IDENTIFICATION
Classification
This chemical is considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200)
_____________________________________________________________________________________________
Page 1 / 13
DT364
1077025Dr. T'sT's
- Dr Snake-A-Way
Snake A WaySnake
4lb Repelling Granules
_____________________________________________________________________________________________
Emergency Overview
Signal word Danger
Hazard Statements
Causes skin irritation
May cause genetic defects
May cause cancer
May form combustible dust concentrations in air
Skin
IF ON SKIN: Wash with plenty of soap and water
If skin irritation occurs: Get medical advice/attention
Take off contaminated clothing and wash before reuse
Not applicable
Unknown Toxicity
61.9% of the mixture consists of ingredient(s) of unknown toxicity
Other information
_____________________________________________________________________________________________
Page 2 / 13
DT364 - Dr
1077025Dr. T'sT's
Snake-A-Way
Snake A WaySnake
4lb Repelling Granules
_____________________________________________________________________________________________
3. COMPOSITION/INFORMATION ON INGREDIENTS
.
General Advice Show this safety data sheet to the doctor in attendance.
Eye Contact Rinse immediately with plenty of water, also under the eyelids, for at least 15
minutes. Keep eye wide open while rinsing. Remove contact lenses, if present and
easy to do. Continue rinsing. Get medical attention if irritation develops and
persists.
Skin Contact Wash off immediately with soap and plenty of water for at least 15 minutes. Get
medical attention if irritation develops and persists.
Inhalation Remove to fresh air. Get medical attention immediately if symptoms occur.
Ingestion Rinse mouth immediately and drink plenty of water. Never give anything by mouth
to an unconscious person. Do NOT induce vomiting. Call a physician.
Self-protection of the first aider Avoid contact with skin, eyes or clothing. Use personal protective equipment as
required. Wear personal protective clothing (see section 8).
_____________________________________________________________________________________________
Page 3 / 13
DT364
1077025Dr. T'sT's
- Dr Snake-A-Way
Snake A WaySnake
4lb Repelling Granules
_____________________________________________________________________________________________
5. FIRE-FIGHTING MEASURES
Suitable Extinguishing Media
Use extinguishing measures that are appropriate to local circumstances and the surrounding environment.
Explosion Data
Sensitivity to Mechanical Impact No.
Personal Precautions Avoid contact with skin, eyes or clothing. Ensure adequate ventilation. Use personal
protective equipment as required. Avoid generation of dust. Do not breathe dust.
ELIMINATE all ignition sources (no smoking, flares, sparks or flames in immediate area).
Take precautionary measures against static discharges.
Environmental Precautions
Environmental Precautions Refer to protective measures listed in Sections 7 and 8. Prevent further leakage or spillage
if safe to do so.
Methods for Containment Prevent further leakage or spillage if safe to do so. Prevent dust cloud.
Methods for cleaning up Take up with inert, damp, non-combustible material using clean non-sparking tools and
place into loosely covered plastic containers for later disposal.
_____________________________________________________________________________________________
Page 4 / 13
DT364
1077025Dr. T'sT's
- Dr Snake-A-Way
Snake A WaySnake
4lb Repelling Granules
_____________________________________________________________________________________________
Handling
PESTICIDE STORAGE: Store only in original Handlecontainer,
in accordance with good
in a cool, industrial
dry, and hygiene and
well-ventilated safety
location practice. Avoid
inaccessible contact
to children with
and
pets. skin, eyes or clothing. Do not eat, drink or smoke when using this product. Take off
contaminated clothing and wash before reuse. Ensure adequate ventilation. Avoid
PESTICIDE DISPOSAL AND CONTAINER generation of dust.Non-refillable
HANDLING: Do not breathe dust. Avoid
container. contact
Do not reusewith eyes.
or refill Keep
this away from
container. If Empty:
heat/sparks/open flames/hot surfaces. - No smoking. Use spark-proof tools and
Place in trash or offer for recycling if available. If Partly Filled: Call your local solid waste agency for disposal instructions. Never
explosion-proof equipment. Take precautionary measures against static discharges.
place unused product down any indoor or outdoor drain.
Conditions for safe storage, including any incompatibilities
Storage Keep containers tightly closed in a dry, cool and well-ventilated place. Store locked up.
Keep out of the reach of children.
Exposure Guidelines
Other Exposure Guidelines Vacated limits revoked by the Court of Appeals decision in AFL-CIO v. OSHA, 965 F.2d 962
(11th Cir., 1992) See section 15 for national exposure control parameters
Eye/Face Protection Wear safety glasses with side shields (or goggles).
Skin and Body Protection Wear protective gloves and protective clothing. Long sleeved clothing. Impervious gloves.
Respiratory Protection No protective equipment is needed under normal use conditions. If exposure limits are
exceeded or irritation is experienced, ventilation and evacuation may be required.
Hygiene Measures Handle in accordance with good industrial hygiene and safety practice. Avoid contact with
skin, eyes or clothing. Wear suitable gloves and eye/face protection. Do not eat, drink or
smoke when using this product. Wash hands before breaks and immediately after handling
the product. Do not breathe dust.
_____________________________________________________________________________________________
Page 5 / 13
DT364 - Dr
1077025Dr. T'sT's
Snake-A-Way
Snake A WaySnake
4lb Repelling Granules
_____________________________________________________________________________________________
Other Information
_____________________________________________________________________________________________
Page 6 / 13
DT364
1077025Dr. T'sT's
- Dr Snake-A-Way
Snake A WaySnake
4lb Repelling Granules
_____________________________________________________________________________________________
No data available.
Chemical stability
Stable under recommended storage conditions.
Hazardous Polymerization
Hazardous polymerization does not occur.
Conditions to avoid
Excessive heat. Heating in air. Dust formation.
Incompatible materials
Strong acids. Strong oxidizing agents. Strong bases.
Product Information .
Inhalation Specific test data for the substance or mixture is not available. May cause irritation of
respiratory tract.
Eye Contact Specific test data for the substance or mixture is not available. Expected to be an irritant
based on components. Irritating to eyes. May cause redness, itching, and pain.
Skin Contact Specific test data for the substance or mixture is not available. Expected to be an irritant
based on components. Irritating to skin.
Ingestion Specific test data for the substance or mixture is not available. Ingestion may cause
irritation to mucous membranes. Ingestion may cause gastrointestinal irritation, nausea,
vomiting and diarrhea.
Component Information
Symptoms Erythema (skin redness). May cause redness and tearing of the eyes.
_____________________________________________________________________________________________
Page 7 / 13
DT364
1077025Dr. T'sT's
- Dr Snake-A-Way
Snake A WaySnake
4l Repelling Granules
_____________________________________________________________________________________________
Delayed and immediate effects as well as chronic effects from short and long-term exposure
Carcinogenicity The table below indicates whether each agency has listed any ingredient as a carcinogen.
Chronic Toxicity Contains a known or suspected mutagen. Possible risk of irreversible effects. Contains a
known or suspected carcinogen. May cause adverse effects on the bone marrow and
blood-forming system. May cause adverse liver effects.
Target Organ Effects Respiratory system. Eyes. Skin. May affect the genetic material in germ cells (sperm and
eggs). Gastrointestinal tract (GI). Blood. Central Nervous System (CNS). Kidney. Liver.
Nasal cavities.
The following values are calculated based on chapter 3.1 of the GHS document
ATEmix (oral)
2,721.00 mg/kg
_____________________________________________________________________________________________
Page 8 / 13
DT364 - Dr
1077025Dr. T'sT's
Snake-A-Way
Snake A WaySnake
4lb Repelling Granules
_____________________________________________________________________________________________
Chemical Name Toxicity to Algae Toxicity to Fish Toxicity to Daphnia Magna (Water
Microorganisms Flea)
Sulfur 96h LC50: = 866 mg/L
7704-34-9 (Brachydanio rerio) 96h
LC50: < 14 mg/L (Lepomis
macrochirus) 96h LC50: >
180 mg/L (Oncorhynchus
mykiss)
Naphthalene 72h EC50: = 0.4 mg/L 96h LC50: 5.74 - 6.44 mg/L EC50 = 0.93 mg/L 30 min 48h LC50: = 2.16 mg/L 48h
91-20-3 (Skeletonema costatum) (Pimephales promelas) 96h EC50 > 20 mg/L 18 h EC50: = 1.96 mg/L 48h
LC50: = 1.6 mg/L EC50: 1.09 - 3.4 mg/L
(Oncorhynchus mykiss) 96h
LC50: 0.91 - 2.82 mg/L
(Oncorhynchus mykiss) 96h
LC50: = 1.99 mg/L
(Pimephales promelas) 96h
LC50: = 31.0265 mg/L
(Lepomis macrochirus)
Bioaccumulation
_____________________________________________________________________________________________
Page 9 / 13
1077025 - Dr
DT364 Dr. T'sT's
Snake-A-Way
Snake A Way Snake
4lb Repelling Granules
_____________________________________________________________________________________________
Disposal methods This material, as supplied, is not a hazardous waste according to Federal regulations (40
CFR 261). This material could become a hazardous waste if it is mixed with or otherwise
comes in contact with a hazardous waste, if chemical additions are made to this material, or
if the material is processed or otherwise altered. Consult 40 CFR 261 to determine whether
the altered material is a hazardous waste. Consult the appropriate state, regional, or local
regulations for additional requirements.
Chemical Name RCRA RCRA - Basis for Listing RCRA - D Series Wastes RCRA - U Series Wastes
Naphthalene U165 Included in waste streams: U165
91-20-3 F024, F025, F034, F039,
K001, K035, K060, K087,
K145
Chemical Name RCRA - Halogenated RCRA - P Series Wastes RCRA - F Series Wastes RCRA - K Series Wastes
Organic Compounds
Naphthalene Toxic waste
91-20-3 waste number F025
Waste description:
Condensed light ends, spent
filters and filter aids, and
spent desiccant wastes from
the production of certain
chlorinated aliphatic
hydrocarbons, by free
radical catalyzed processes.
These chlorinated aliphatic
hydrocarbons are those
having carbon chain lengths
ranging from one to and
including five, with varying
amounts and positions of
chlorine substitution.
This product contains one or more substances that are listed with the State of California as a hazardous waste.
Page 10 / 13
DT364
1077025Dr. T'sT's
- Dr Snake-A-Way
Snake A WaySnake
4lb Repelling Granules
_____________________________________________________________________________________________
IMDG/IMO
Not Regulated
UN3077
UN-No.
Proper Shipping Name ENVIONMENTALLY HAZARDOUS SUBTANCE, SOLID, N.O.S.
Hazard Class N/A
Marine Pollutant Product is a marine pollutant according to the criteria set by IMDG/IMO
Description UN3077, ENVIRONMENTALLY HAZARDOUS SUBSTANCE, SOLID, N.O.S.
(NAPHTHALENE), 9, III, MARINE POLLUTANT
TSCA Complies
DSL All components are listed either on the DSL or NDSL.
TSCA - United States Toxic Substances Control Act Section 8(b) Inventory
DSL/NDSL - Canadian Domestic Substances List/Non-Domestic Substances List
US Federal Regulations
SARA 313
Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product contains a chemical
or chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372
Chemical Name CWA - Reportable CWA - Toxic Pollutants CWA - Priority Pollutants CWA - Hazardous
Quantities Substances
Naphthalene 100 lb X X X
91-20-3
CERCLA
This material, as supplied, contains one or more substances regulated as a hazardous substance under the Comprehensive
Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302)
_____________________________________________________________________________________________
Page 11 / 13
DT364
1077025Dr. T'sT's
- Dr Snake-A-Way
Snake A WaySnake
4lb Repelling Granules
_____________________________________________________________________________________________
US State Regulations
California Proposition 65
This product contains the following Proposition 65 chemicals.
_____________________________________________________________________________________________
Page 12 / 13
DT364
1077025Dr. T'sT's
- Dr Snake-A-Way
Snake A WaySnake
4lb Repelling Granules
_____________________________________________________________________________________________
Disclaimer
The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at
the date of its publication. The information given is designed only as a guidance for safe handling, use, processing,
storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The
information relates only to the specific material designated and may not be valid for such material used in combination
with any other materials or in any process, unless specified in the text
_____________________________________________________________________________________________
Page 13 / 13