Professional Documents
Culture Documents
Soal Plo Nokia
Soal Plo Nokia
2). Issues with 4G MIMO mode control can cause by following statement, except:
4). In the 3GPP evolved release 10, transmission modes are support to:
1. 0db
2. 1db
3. 2.db
4. 4db
2. PDCCH occupies the REs not used by PCFICH and PHICH and Reference Signals within the first 1, 2 or 3
symbols of each TTI
8). When is the best timing to get measurement of UL RSSI Interference that possible indicate internal
hardware problem?
1. 128 QAM UL
2. 256 QAM UL
3. 256 QAM DL
4. 64 QAM DL
2. Tx2relocation timer
3. X2 issue
4. 2 MIB + 9 SIB
12). Which event that The non-contention based random access are applicable to ?
1. All Event
2. RRC re-establishment
4. Initial Access
1. 16
2. 32
3. 8
4. 24
2. TA list ensures that the location of UE is available to the MME at all instants of time
4. Increase latency
19). Is there any relation between low 2G CSSR and high capacity ?
20). Which of the following that you will not do if you find 2G TBF Downlink Success Rate is not pass the
target baseline ?
4. Downtilt from 4 to 10
3. Frequency synchronization
24). When throughput test shows low throughput value for TCP, but UDP throughput is high, what could
be the cause?
2. Shaping is enabled in the transport path between the core and eNodeB
3. upgrade BW to 20 Mhz
4. change dlMimoMode to 43
26). what is below is not correct condition that cell reselection will trigger in 4G inter-frequency?
27). what is below is not correct condition that cell reselection will trigger in 4G intra frequency?
1. riEnable (rank indication reporting enables). 2. periodicCqFeedback Type (periodic CQI feedback type)
3. cqPerSbCycK (Periodic CQI sub-bands cycles) 4. caShecFairFact (carrier aggregation scheduling fairness
control).
1. 1), 2) and 4)
3. 2), 3) and 4)
4. 1), 3) and 4)
1. Transfer of an ongoing call/data session from a cell to another without call interruption
3. Transfer of an ongoing call/data session from a cell to another, but requires connection release prior
to the transfer the ongoing call
4. Procedure dedicated for call transfer from LTE to GSM; it requires connection release
1. PUSCH
2. PDCCH
3. PDSCH
4. PBCH
32). 4G Coverage Based Handover will be only performed under what condition?
1. RSRP at serving cell > threshold3 and RSRP at target < threshold3a
2. RSRP at serving cell > threshold3 and RSRP at target > threshold3a
3. Support of PDCCH-less component carriers for purpose of improved interverence management, for
example in heterogenous network deployments (Ie. ICIC for PDCCH)
4. Avoiding PDCCH transmission on DL CCs that are close in frequency to UL CCs to avoid desensing the
receiver.
35). How many carrier per pipe maximum for AHHB Nokia AirScale RRH 4T4R ?
1. Up to 16
2. Up to 8
3. Up to 12
4 Up to 4
1. If RSRP of neighbor cell is lower than threshold1, only neighbor cell is measured
2. If RSRP of serving cell is greater than threshold1, only serving cell is measured
3. if RSRP of neighbor cell is greater than threshold1, only serving cell is measured
4. If RSRP of serving cell is lower than threshold1, only serving cell is measured
1. 4db
2. In typical TDD deployments, the number of CCs and the bandwidth of each CC in UL an DL is the same.
3. d.CCs originating from the same eNB need not provide the some coverage
4.The number of DL/UL CCs that can be configured epends on the DL/UL aggregation capability of the UE
38). What is the first thing you do when you find degradation on KPI?
39). For Volte services, which QCI will be use as resources bearer ?
41). The CQI is defined as a table containing 16 entries with modulation and coding schemes (MCSs).
Which one is correct for representing the modulation ?
4. T301 defines the validity time of dedicated priorities defined in IdleModeMobilityCon trollnfo.
43). What is the parameter you will change if you want to decide the absolute priority of the 4G serving
cell
1. cellReSelPrio (This is the priority of the own cell. It depends on the layering plan. The cell reselection
priority parameter defines the absolute priority of the serving layer. 0 means the lowest priority. Equal
priorities between RATs are not supported according to [3GPP 36.304].)
2. uCelResPrio (Depends on layering plan. LTE prio > 3G prio > GSM prio. Absolute priority of the UTRA
carrier frequency. Equal priorities between RATs are not supported according to [3GPP 36.304].
3. gcelResPrio (LTE prio > 3G prio > GSM prio. Its value depends on layering plan of the operator. Usually
GERAN would be the last resort coverage layer and low priority is used. Absolute priority of the GERAN
carrier frequency. Equal priorities between RATs are not supported according to [3GPP 36.304].
4. eutCelResPrio (Depends on layering plan. Absolute priority of the EUTRA carrier frequency. Equal
priorities between RATs are not supported according to [3GPP 36.304].
44). There is 4 types on preamble, what is the significant difference between this 4 types ?
1. PRB Number
2. Reference Signal
3. Cell Range
4. Guard Time
2. S1 Release
3. PGW Selection
4. Service request
2. PUSCH RLF
3. TA Expiry
48). Which network element of NOKIA's LTE solution performs the E2E monitoring and reporting
functions?
1. Flexi NG
2. Charge@once
3. PCS-5000
4. Netact
49). What parameter to define the maximum numbers of preambles allowed in one preamble ramping
cycle ?
1. PowerRampStepPRACHpreamble (“The power ramping step size parameter defines the power
increment step size for Random Access preamble transmission.”)
2. PRACHRequired ReceivedCI
3. PRACH_Preamble_retrans
4. UETxPowerMax PRACH
50). Which network element always triggers the user network authentication process
1. S-GW
2. MME
3. P-GW
4. eNodeB
51). A new site is on air with condition low revenue sites. What will you NOT do ?
52). What is the bad impact on applying Closed Loop Power Control in 4G ?
3. No bad Impact
54. Select the factor that does NOT improve the Spectral Efficiency In Massive MIMO ?
1. Multiuser gain
2. UL interference cancellation
3. 3D beamforming
1. eNodeB
2. S-GW
3. HSS
4. MME
57. Without this feature VOLTE call will drop when it leaves the LTE coverage ?
1. 12
2. 24
3. 48
4. 36
60. Which of the following options does NOT improve the latency as part of the Radio Network
Optimization Procedures?
1. 5MHz
2. 2MHz
3. 10 MHz
4. 20 MHz
66. What air interface technology has been defined for LTE uplink ?
1. SC_FDMA
2. WCDMA
3. GSMK
4. OFDMA
67. Which type of handovers are support in LTE?
68. what is below is correct condition that cell re-selection will trigger measurement in 4G intra-
frequency?
69. what is below is correct condition that cell reselection will trigger in 4G inter-frequency?
70.You are in optimizing 1 new site, you see 2G TCH Blocking is not Pass the target KPI. What will you
do ?
1. Disable the Halfrate so the cell can go full rate to accomade full service
2. Tx2relocation timer
3. X2 issue
72. What will you do if find cell with high PRB Utilization ?
3. Downtilt from 2 to 10
74. in Mapinfo you can map the entire site in region to get information
visually. What is the function if highlighted yellow in picture ?
75. After check MDT, you find that low SNIR happen across the main street. What is the best will you
do?
2. Switch off all sites, except one site to cover the street
3. Uptilt all cells that cover the main street to get best coverage
4. Downtilt all cells that cover the main street to get best coverage
77. Which factors can NOT be a cause for bad KPI for HOSR ?
1. IMSI
2. X2 quality
3. Layer Priority
4. UL RSSI
1. RTWP
2. PRB Utilization
3. Intracell Handover
4. CQI
5. All options are incorrect
79. You are in optimizing 4G New Site, but you find that the Packet Loss Rate is high. What will you do
first?
80. You are optimizing 1 new site and 4G Payload suddenly increase and impact to your CSSR KPI, what
will you not do immediately?
81. From Drive Test Result, to check coverage of the cells, What plotting will you used ?