Professional Documents
Culture Documents
Sikagard 403W PDS
Sikagard 403W PDS
Sikagard®-403W
PRODUCT INFORMATION
TECHNICAL INFORMATION
APPLICATION INFORMATION
APPLICATION INSTRUCTIONS application use tip sizes from 0.38 to 0.53mm/ angle
Stir product mechanically until a uniform liquid has 40° to 60°.
been achieved.
Use a low speed electrical stirrer (300-400 rpm) to CLEANING OF TOOLS
avoid air entrapment. Clean all tools with water immediately after use.
For roller application use short piled roller. For airless Hardened and/or cured material can only be removed
mechanically
NOTES ON LIMITATIONS storage and disposal of chemical products, users shall
Each type of roller will give a slightly different surface refer to the most recent Material Safety Data Sheet
finish – always use same roller type in same areas containing physical, ecological, toxicological and other
Ensure entire surface is fully dried before over coating safety-related data.
Crazing may occur when over coating un-dried areas LEGAL NOTES
Always ensure good ventilation when application takes
place in a confined space to ensure drying The information contained herein and any other advice
The incorrect treatment of cracks may lead to a are given in good faith based on Sika's current
reduced service life and reflective cracking knowledge and experience of the products when
Do not apply near foodstuffs in unventilated properly stored, handled and applied under normal
conditions, always ensure ventilation conditions in accordance with Sika's recommendations.
Acoustic insulation boards may lose some acoustic The information only applies to the application(s) and
absorption properties product(s) expressly referred to herein. In case of
changes in the parameters of the application, such as
VALUE BASE changes in substrates etc., or in case of a different
All technical data stated in this Product Data Sheet are application, consult Sika's Technical Service prior to
based on laboratory tests. Actual measured data may using Sika products. The information contained herein
vary due to circumstances beyond our control. does not relieve the user of the products from testing
them for the intended application and purpose. All
LOCAL RESTRICTIONS orders are accepted subject to our current terms of
Please note that as a result of specific local regulations sale and delivery. Users must always refer to the most
the performance of this product may vary from country recent issue of the local Product Data Sheet for the
to country. Please consult the local Product Data Sheet product concerned, copies of which will be supplied on
for the exact description of the application fields request.
HEALTH AND SAFETY INFORMATION
For information and advice on the safe handling,