Professional Documents
Culture Documents
WL4000
WL4000
0 50V to 550V
4.1 Programming keys · Press Down To Enter Programming Mode CT Primary 5000C.P 5.000 0.5A - 99KA
· Press UP key to select the Edit Mode
To select Edit Mode and save parameter Blink indicates Edit Mode is ON CT Secondary 5000C.S 5.000 0.5A - 6A
DOWN to decrement value or parameter · Press DOWN to decrement values or Yes/No
to select from available options Reverse lock No If YES it blocks energy accumulation in
case the CT polarity reverse.
4.2 General Programming Guide · Press UP to accept the value of the parameter
· Press UP + Down to enter Programming Mode Method of VA Selection:
· Press DOWN to edit next parameters till end VA Selection UE C.H UA. VEC.Har Arithmetic /Vector harmonics /Vector
· Enter Password (default value 0000) after the configuration of last parameter display
· Blink indicates Edit Mode is ON Parameter options Wh Options: Wh/PF/W/VA
screen will prompt “SAVE”, Display reads “Y” (YES)
· Press DOWN to decrement value · Press DOWN to change to “ ” (NO) Baud rate 9600 2400, 4800, 9600 19.2k
0/9/8/7/6/5/4/3/2/1 · Press UP to save. Parity Even Even/Odd/none
· Press UP to move to the next digit till 4th digit
4.3.Display Slave Id 1000SL 1.000 1 to 247
If Password is correct, meter display reads I First four digit : Parameter value
For Clear Mode move to step 4.2.1 41 5.0 P.P 5th & 6th digit : Parameter to edit PASSWORD 0000 0000 to 9999
For Programming Mode move to step 4.2.2 Energy
Programming Resolution Resolution/Counter
Default Option/Range
4.2.1.Clear Mode Parameter Energy Selection Wh Wh/VAh
· Press UP to Enter Clear Mode Display reads “ I” ConFIG.
· Press UP to clear parameter. Display prompts “ ” (Defines the 3P 4W 4.4. Enabling and Disabling Auto Scrolling
power system Press DOWN for 6 secs
· Press DOWN to change for “y” (yes) to clear values configuration.)
3P 4W 3P 3W
· Press UP to clear 1 Phase Display Shows: EnbL. Au.
Again press DOWN for 6 sec
100V-999kv Display Shows: dSbL. Au.
If password is incorrect, meter will display next To set 11.10kV Set first four digits
parameter but cannot be edited. PT Primary (1110) as explained above press
415 UP/DOWN key to place decimal point
4150P.P
at appropriate location.
M & K both LED will glow for Giga
WL40000501A
90 +2.0 Steps for Mounting
- 0.0
Received (Import) Delivered (Export) Received (Import) Delivered (Export) Received (Import) Delivered (Export) Insert meter to panel CUSTOMER INTERACTION CENTRE (CIC)
1
without clamps TOLL-Free: 1800 233 5858, 1800 200 5858
2 Telephone : 022 6774 5858
Load Line Load Line Load Line Insert both clamps email: cic@LNTEBG.com
2 1 3
+2.0
90 - 0.0