Download as pdf or txt
Download as pdf or txt
You are on page 1of 41

7/9/2020 Arterial blood gases - UpToDate

Official reprint from UpToDate®


www.uptodate.com ©2020 UpToDate, Inc. and/or its affiliates. All Rights Reserved.

Arterial blood gases


Author: Arthur C Theodore, MD
Section Editor: Scott Manaker, MD, PhD
Deputy Editor: Geraldine Finlay, MD

All topics are updated as new evidence becomes available and our peer review process is complete.

Literature review current through: Aug 2020. | This topic last updated: Jan 31, 2020.

INTRODUCTION

An arterial blood gas (ABG) is a test that measures the oxygen tension (PaO2), carbon dioxide
tension (PaCO2), acidity (pH), oxyhemoglobin saturation (SaO2), and bicarbonate (HCO3)
concentration in arterial blood. Some blood gas analyzers also measure the methemoglobin,
carboxyhemoglobin, and hemoglobin levels. Such information is vital when caring for patients with
critical illness, respiratory, or metabolic diseases.

The sites, techniques, and complications of arterial sampling and the interpretation of ABGs are
reviewed here. Interpretation of venous blood gases and detailed discussion of acid-base
disturbances are discussed separately. (See "Simple and mixed acid-base disorders" and "Venous
blood gases and other alternatives to arterial blood gases".)

INDICATIONS AND CONTRAINDICATIONS

ABGs are frequently used for the following:

● Identification and monitoring of acid-base disturbances


● Measurement of the partial pressures of oxygen (PaO2) and carbon dioxide (PaCO2)
● Assessment of the response to therapeutic interventions (eg, insulin in patients with diabetic
ketoacidosis)
● Detection and quantification of the levels of abnormal hemoglobins (eg, carboxyhemoglobin
and methemoglobin)
● Procurement of a blood sample in an acute emergency setting when venous sampling is not
feasible (most tests can be performed from an arterial sample)

Absolute contraindications for ABG sampling include the following [1]:

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage_t… 1/41


7/9/2020 Arterial blood gases - UpToDate

● An abnormal modified Allen's test (see 'Ensure collateral circulation' below)

● Local infection, thrombus, or distorted anatomy at the puncture site (eg, previous surgical
interventions, congenital or acquired malformations, burns, aneurysm, stent, arteriovenous
fistula, vascular graft)

● Severe peripheral vascular disease of the artery selected for sampling

● Active Raynaud's syndrome (particularly sampling at the radial site)

If a contraindication is present, in many cases an alternative site or consideration for using venous
blood should be sought for sampling.

Supra therapeutic coagulopathy and infusion of thrombolytic agents (eg, during streptokinase or
tissue plasminogen activator infusion) are relative contraindications to arterial needle stick and
absolute contraindications to indwelling catheter insertion. Although no cutoff has been suggested
by any international societies, we suggest avoiding repeated arterial needle sticks when the
international normalized ratio is ≥3 and/or the activated partial thromboplastin time is ≥100
seconds.

Similarly, arterial needle stick and catheterization can be performed in patients with
thrombocytopenia a platelet count >50 x 109/L, but is generally avoided in those whose count is
≤30 x 109/L. For those with counts between 30 and 50 x 109/L limited needle stick sampling is
sometimes performed, when necessary, with increased compression time. A platelet count <50 x
109/L is generally a contraindication to arterial catheter insertion.

A history of Raynaud's disease or Raynaud's disease without active spasm, as well as evidence of
poor peripheral perfusion (eg, cyanotic digits), are also considered by most experts as relative
contraindications to radial arterial sampling.

Therapeutic anticoagulation is not a contraindication for arterial needle puncture, although the risk
of bleeding is higher, but it is a relative contraindication for the insertion of an indwelling catheter.
Increased vessel compression is appropriate in such patients. Aspirin or other antiplatelet agents
(eg, clopidogrel) are not a contraindication for arterial vascular sampling in most cases.

TECHNICAL CHALLENGES

ABG sampling may be difficult to perform in patients who are uncooperative or in whom pulses
cannot be easily identified (eg, shock, vasopressor infusion, arteriosclerosis from end-stage
kidney disease, calcification of the vessel wall). Difficulties can also arise when the patient cannot
be positioned appropriately (eg, cannot fully extend the wrists for radial artery access due to
tremor or joint contractures) or in obese or edematous patients with large amounts of
subcutaneous tissue which may obscure the usual anatomic landmarks. In some of these

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage_t… 2/41


7/9/2020 Arterial blood gases - UpToDate

scenarios, ultrasound may be useful to locate the artery and reduce potential complications of
repeated puncture and consequent injury to the target vessel and surrounding tissue.

ARTERIAL SAMPLING

Arterial blood is required for an ABG. It can be obtained by percutaneous needle puncture or from
an indwelling arterial catheter. Written consent is not usually required for arterial needle stick
puncture but is required for the insertion of an indwelling catheter. Regardless, the risks and
benefits of each procedure should be explained to the patient.

Ultrasound is not routinely used but can be used to direct access when sampling by the standard
approach has been unsuccessful or is not feasible (eg, weak pulses, patient on multiple
vasopressors, obese patients). When used, ultrasound-guided access may increase the operator's
ability to enter the vessel and helps minimize injury to the artery and adjacent nerves and veins.

Needle puncture — Percutaneous needle puncture refers to the withdrawal of arterial blood via a
needle stick. It needs to be repeated every time an ABG is performed, since an indwelling catheter
is not inserted. Thus, it is suitable for patients who require a limited number of arterial draws (eg,
daily or less than once daily during an admission to hospital). If recurrent sampling (eg, more than
four draws in 24 hours) is required, clinicians should, at minimum, rotate puncture sites (eg, right
and left radial) or consider placing an indwelling catheter. (See 'Indwelling catheters' below and
"Intra-arterial catheterization for invasive monitoring: Indications, insertion techniques, and
interpretation".)

Site selection — The initial step in percutaneous needle puncture is locating a palpable artery.
Common sites include the radial, femoral, brachial, dorsalis pedis, or axillary artery. There is no
evidence that any site is superior to the others. However, the radial artery is used most often
because it is accessible and more comfortable for the patient than the alternative sites. The radial
artery is also typically used for outpatients, while all sites can be used for inpatients who require
an ABG.

● Radial artery – The radial artery is best palpated between the distal radius and the tendon of
the flexor carpi radialis when the wrist is extended (figure 1 and figure 2). Although
infrequently performed, the arm can be taped (at the level of the forearm and palm) to an
armboard with the palm facing upward; a large roll of gauze also can be placed between the
wrist and the armboard in a position that extends the wrist. Over extension should be avoided
as extension of the overlying flexor tendons may make the pulse difficult to detect.

● Brachial artery – The brachial artery is best palpated medial to the biceps tendon in the
antecubital fossa, when the arm is extended and the palm is facing up (figure 3). The arm is
placed on a firm surface (an armboard can be used similar to that described for the radial
artery above) with the shoulder slightly abducted, the elbow extended, and the forearm in full
https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage_t… 3/41
7/9/2020 Arterial blood gases - UpToDate

supination. The needle should be inserted just above the elbow crease at a 30 degree angle
(figure 4). It is usually harder to access because it runs deeper in the arm than the radial
artery.

● Femoral artery – The femoral artery is best palpated just below the midpoint of the inguinal
ligament, when the lower extremity is extended and the patient is lying supine (figure 5). The
needle should be inserted at a 90 degree angle just below the inguinal ligament (figure 6).

● Axillary artery – The axillary artery is best palpated in the axilla, when the arm is abducted
and externally rotated (figure 7). The needle should be inserted as high into the apex of the
axilla as possible (figure 8).

● Dorsalis pedis – The dorsalis pedis artery can be occluded by the forefinger followed by
compression of the nail bed of the great toe and assessment of the rapidity with which color
returns to the nail bed after pressure is released from the great toe (figure 9). The needle can
be inserted at a 30 degree angle lateral to the extensor tendon at the level of the midfoot.

Ensure collateral circulation — One of the risks associated with arterial puncture is ischemia
distal to the puncture site (see 'Complications' below). Although rarely performed in practice,
identifying collateral flow to the region supplied by the artery can be used by clinicians prior to
puncture. While limited studies have found variable accuracy associated with such evaluations, we
believe that patients, and in particular high risk patients, undergoing radial or dorsalis pedis artery
puncture should have the collateral flow to those vessels evaluated [2,3]. Our belief is based upon
the concept that it avoids potential harm by identifying patients who have impaired collateral
circulation and who are therefore at increased risk of an ischemic complication, and in whom an
alternative site should be sought. In addition, the evaluation can be performed quickly at the
bedside and at no cost.

Radial and dorsalis pedis artery puncture are at highest risk of this complication (because they are
small in diameter). They receive collateral supply from the ulnar and lateral plantar artery,
respectively. It is this collateral supply that is identified by the following tests:

● Radial artery – The Allen's test or modified Allen's test are bedside tests that can be
performed in patients undergoing radial artery puncture to demonstrate collateral flow from
the ulnar artery through the superficial palmar arch (figure 1) [4].

• Modified Allen's test – The patient's hand is initially held high with the fist clenched.
Both the radial and ulnar arteries are compressed firmly by the two thumbs of the
investigator (figure 10). This allows the blood to drain from the hand. The hand is then
lowered and the fist is opened (the palm will appear white). Overextension of the hand or
wide spreading of the fingers should be avoided because it may cause false-normal
results. The pressure is released from the ulnar artery while occlusion is maintained on
the radial artery. A pink color should return to the palm, usually within six seconds,
https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage_t… 4/41
7/9/2020 Arterial blood gases - UpToDate

indicating that the ulnar artery is patent and the superficial palmar arch is intact. Although
the timing of return of circulation to the palm varies considerably, the test is generally
considered abnormal if ten seconds or more elapses before color returns to the hand
(picture 1).

• The Allen's test – The Allen's test (from which the modified Allen's test evolved) is
performed identically, except these steps are executed twice: once with release of
pressure from the ulnar artery while occlusion is maintained on the radial artery, and once
with release of pressure from the radial artery while occlusion is maintained on the ulnar
artery.

• Other – Finger pulse plethysmography, Doppler flow measurements, and measurement


of the arterial systolic pressure of the thumb have been described but are not routinely
used [5].

● Dorsalis pedis artery – An Allen's test to assess the collateral circulation of the posterior
tibialis is performed by elevating the leg until the plantar skin blanches followed by
compression of dorsalis pedis pulse by the clinician's thumb and lowering of leg to
dependency. The foot rapidly resumes its normal color if the posterior tibial artery flow is
adequate.

The risk of ischemic complications is low for the axillary artery because the arm receives good
collateral flow through the thyrocervical trunk and subscapular artery. Thus, no collateral supply
testing is typically performed prior to arterial puncture. However, assessing distal brachial and
radial artery pulses is appropriate in patients who have had anatomic, pathologic abnormalities of
the thoracic outlet; if distal pulses are weak, an alternative site should be sought.

The femoral artery is large such that ischemia is rare. However, the distal pedal pulses of the
lower limb should be assessed first. If pedal pulses are severely diminished or absent, peripheral
arterial disease may be present and an alternative arterial puncture site should be sought.

Similarly, pulses distal to the brachial artery must be assessed prior to the procedure. In patients
with absent pulses at the wrist (ie, in the radial and ulnar arteries), an alternative site for arterial
sampling should be sought.

Equipment — As for all procedures, the equipment necessary should be brought to the
bedside prior to the procedure. This includes:

● Non sterile gloves


● Antiseptic skin solution (eg, chlorhexidine and povidone-iodine are solutions)
● ABG kit OR a pre-heparinized 3 mL ABG syringe with a 22 to 25-gauge needle and syringe
cap
● 2 × 2 inch sterile gauze

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage_t… 5/41


7/9/2020 Arterial blood gases - UpToDate

● Adhesive bandage
● Plastic hazard bag with ice (if not provided in the kit)
● Sharp object container

Lidocaine (eg, 1 or 2 percent) without epinephrine may be required should the clinician feel that
anesthesia is necessary or the patient requests it.

ABG kits (picture 2) are used by clinicians in most institutions to draw arterial blood. Kits contain a
heparinized plastic syringe with the plunger already pulled back to allow for the collection of 2 mL
of blood, a protective needle sleeve, a needle, syringe cap, and ice bag. The sleeve, while
attached to the syringe, locks the needle within itself to prevent direct contact between operator
and needle. It is removed to expose the needle. The prefilled heparin is expelled (incomplete
dismissal of heparin falsely lowers the partial pressure of carbon dioxide), and the plunger is then
repositioned at the 2 mL mark.

Alternatively a heparinized ABG syringe can be used. Approximately 2 mL of lithium heparin


(1000 units/mL) can be aspirated into a syringe through a 22 to 25 gauge needle and then
pushed out; the plunger should be left leaving a small empty volume (eg, usually 2 mL) in the
syringe.

Technique — Once a palpable artery has been located, blood is withdrawn using the following
steps.

● The planned puncture site should be sterilely prepared.

● Local analgesia with injectable 1 to 2 percent lidocaine can be administered but is not usually
performed [6,7]. If local anesthesia is employed (eg, requested by the patient, difficult or
prolonged needle stick is pre-empted), 0.5 to 1 mL of the anesthetic is injected to create a
small dermal papule at the site of puncture; using larger amounts or injecting the anesthetic
into deeper planes may distort the anatomy and hinder identification of the vessel [7].
Traditionally, it was believed that the injection of lidocaine is as painful as the procedure itself
so many clinicians avoid using it for this reason. However, in our experience, when performed
by personnel experienced in arterial draws, no anesthesia is typically needed.

● ABG kits are used by clinicians in most institutions to draw arterial blood. Alternatively, a
heparinized syringe can be used. The kit or syringe is prepared as described above. (See
'Equipment' above.)

● One or two fingers should be used to gently palpate the artery while holding the needle in the
other hand. Both fingers should be proximal to the desired puncture site; placing the
nondominant middle finger distally and the nondominant index finger proximally, with the
needle insertion site in between, is not recommended, because of the increased risk of
needle stick injury. The artery should be punctured with the needle at a 30 to 45 degree angle

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage_t… 6/41


7/9/2020 Arterial blood gases - UpToDate

(radial, brachial, axillary, dorsalis pedis) or at a 90 degree angle (femoral artery) relative to the
skin. The syringe fills on its own (ie, pulling the plunger is usually unnecessary).
Approximately 2 to 3 mL of blood should be removed.

For patients with poor distal perfusion (eg, hypovolemia, shock, vasopressor therapy) who
may exhibit a weak arterial pulse, the operator may need to pull back the syringe plunger,
although this increases the risk of venous blood sampling.

If arterial flow is lost during the arterial draw, the needle may have moved outside the vessel
lumen. The needle may be pulled back slightly and repositioned to a point just below the skin;
subsequent redirection using the maneuver described above should be attempted to re-
access the artery. Multiple blind or stabbing movements of the needle while it is inserted
deeply in the patient's limb should be avoided since this increases the risk of local injury and
pain.

● After withdrawing a sufficient volume of blood, the needle should be removed while
simultaneously applying pressure to the puncture site with sterile gauze until hemostasis is
achieved. This usually takes five minutes in a non-anticoagulated patient; avoid checking the
puncture site until local pressure has been maintained for at least this period as this increases
the risk of hemorrhage or a hematoma. In patients who have a coagulopathy or are on
anticoagulation therapy, it may be necessary to apply local pressure for a longer time. Once
hemostasis is achieved, apply an adhesive bandage over the puncture site.

● When ABG kits are used, apply the needle protective sleeve then untwist the sleeve and
place it in the sharp object container. When an ABG syringe is used, recap, remove, and
discard the needle, being careful to avoid a needle stick injury. After discarding the needle,
remove the excess air in the syringe by holding it upright and gently tapping it, allowing any
air bubbles present to reach the top of the syringe, from where they can then be expelled.
Cap the syringe, roll it between the hands for a few seconds to allow blood to mix with the
heparin (prevents clotting), then place on ice in the hazard bag and send it for analysis.

Postprocedural care — Patients should be monitored for new symptoms such as skin color
changes, persistent or worsening pain, active bleeding, and impaired movement or sensation of
the limb. Monitoring is particularly important in patients who are subsequently supra therapeutic on
anticoagulants or are given thrombolytics, as bleeding may be observed in such patients even
though the needle stick occurred a few hours prior.

Complications — In general, serious complications due to arterial percutaneous needle


puncture are rare.

Common complications of ABG sampling include the following:

● Local pain and paresthesia

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage_t… 7/41


7/9/2020 Arterial blood gases - UpToDate

● Bruising
● Local minor bleeding

Less common complications include:

● Vasovagal response
● Local hematoma from moderate or major bleeding
● Artery vasospasm

Rare complications include:

● Infection at the puncture site


● Arterial occlusion from a local hematoma
● Air or thrombus embolism
● Local anesthetic anaphylactic reaction
● Local nerve injury
● Needle stick injury to health care personnel (limited due to use of ABG kits)
● Pseudoaneurysm formation
● Vessel laceration

Should local bleeding, hematoma, vasospasm, and/or arterial thrombus be severe, compartment
syndrome and limb ischemia can occur. Compartment syndrome may manifest as pain,
paresthesias, pallor, and absence of pulses. Limb skin color changes, absent pulses, and distal
coldness may be seen in ischemic injury. Although unproven, rotating puncture sites and placing
firm pressure on the puncture site for at least five minutes after each arterial draw is thought to
decrease the risk of these complications. (See "Acute compartment syndrome of the extremities"
and "Clinical features and diagnosis of acute lower extremity ischemia".)

While vasopressor use may increase the risk of vasospasm, when indicated (eg, for shock), these
agents should not be adjusted to avoid or treat this complication. (See "Evaluation of and initial
approach to the adult patient with undifferentiated hypotension and shock", section on
'Vasopressors' and "Use of vasopressors and inotropes".)

Persistent pain, paresis, or paresthesia of the limb may indicate nerve injury which generally
resolves spontaneously.

Infection at the puncture site should be considered in the presence of regional erythema and fever,
and treated with antibiotics accordingly.

Indwelling catheters — Arterial blood can also be obtained via an indwelling arterial catheter.
Indwelling catheters provide continuous access to arterial blood, which is helpful when frequent
blood gases are needed (eg, patients in respiratory failure on mechanical ventilation, patients
requiring serial ABGs for monitoring acid-base disorders). The sample preparation and care is the

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage_t… 8/41


7/9/2020 Arterial blood gases - UpToDate

same as for ABGs drawn using a needle, which is described above. (See 'Needle puncture'
above.)

Insertion, complications, and use of an arterial catheter are described separately. (See "Intra-
arterial catheterization for invasive monitoring: Indications, insertion techniques, and
interpretation".)

TRANSPORT AND ANALYSIS

The arterial blood sample should be placed on ice during transport to the lab and then analyzed as
quickly as possible. This reduces oxygen consumption by leukocytes or platelets (ie, leukocyte or
platelet larceny), which can cause a factitiously low partial pressure of arterial oxygen (PaO2) [8,9].
This effect is most pronounced in patients whose leukocytosis or thrombocytosis is profound. In
addition, it reduces the likelihood of error due to gas diffusion through the plastic syringe or the
presence of air bubbles. (See 'Sources of error' below.)

Results are usually available within 5 to 15 minutes. Analysis of arterial blood is usually performed
by automated blood gas analyzers, which automatically transport the specimen to electrochemical
sensors to measure acidity (pH), partial pressure of carbon dioxide (PaCO2), and PaO2:

● The PaCO2 is measured using a chemical reaction that consumes CO2 and produces a
hydrogen ion, which is sensed as a change in pH [10]

● The PaO2 is measured using oxidation-reduction reactions that generate measurable electric
currents [10]

● The pH is measured indirectly with an electrode tip which determines the voltage using a
reference potential, calibrated in pH units, where the voltage is proportional to the
concentration of hydrogen ions

● Bicarbonate is not measured directly, but calculated from measured pH and PaCO2 using the
Henderson-Hasselbalch equation

● Arterial oxygen saturation (SaO2) is based upon the equation developed by Severinghaus
[11]: SO2 = (23,400 * (PaO23 + 150 * PaO2)-1 + 1)-1 or the Oxygen hemoglobin disassociation
curve, which is affected by temperature, pH and levels of 2,3 diphosphoglycerate (DPG).

Automated blood gas analyzers rinse the system, calibrate the sensors, and report the results.
Rigorous quality control by the laboratory is essential for accurate results.

Arterial blood gas measurements by the analyzer are affected by temperature. Specifically, pH
increases and both PaO2 and PaCO2 decrease as temperature declines (table 1) [12,13]. Modern
automated blood gas analyzers can report the pH, PaO2, and PaCO2 at either 37ºC (the

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage_t… 9/41


7/9/2020 Arterial blood gases - UpToDate

temperature at which the values are measured by the blood gas analyzer) or at the patient's body
temperature. Most centers report the values of pH, PaCO2, and PaO2 at 37ºC, even if the patient's
body temperature is different. However, this practice is controversial [12-15].

Co-oximetry is used to measure carboxyhemoglobin and methemoglobin levels in arterial blood,


the details of which are described separately. (See "Pulse oximetry", section on
'Carboxyhemoglobin'.)

INTERPRETATION

Normal values — The range of normal values varies among laboratories. In general, normal
values for acidity (pH), the partial pressure of carbon dioxide (PaCO2) and bicarbonate
concentration (HCO3) are as follows:

● pH – 7.35 to 7.45

● PaCO2 – 35 to 45 mmHg (4.7 to 6 kPa)

● HCO3 – 21 to 27 mEq/L

Normal values for the partial pressure of arterial oxygen (PaO2) and arterial oxygen saturation
(SaO2) have not been defined because a threshold below which tissue hypoxia occurs has not
been identified. In our opinion, it is reasonable to consider a resting PaO2 >80 mmHg (10.7 kPa)
and SaO2 >95 percent normal, unless the new values are substantially different than prior values.
As an example, an SaO2 of 96 percent may be abnormal if the patient's previous SaO2 was 100
percent. (See "Measures of oxygenation and mechanisms of hypoxemia", section on 'Measures of
oxygenation'.)

Nonsmokers may have up to 3 percent carboxyhemoglobin at baseline (ie, 3 percent of total


hemoglobin); smokers may have levels of 10 to 15 percent. Levels above these respective values
are considered abnormal. Normal individuals have approximately 1 percent methemoglobin in
arterial blood. (See "Pulse oximetry", section on 'Carboxyhemoglobin' and "Carbon monoxide
poisoning", section on 'Diagnosis' and "Methemoglobinemia", section on 'How are the levels
regulated?'.)

Oxygenation — Measurement of PaO2 and SaO2 provide data on oxygenation that can also be
used to calculate indices of oxygenation including the alveolar-arterial gradient (A-a gradient),
partial pressure of arterial oxygen/fraction of inspired oxygenation ratio (PaO2/FiO2), and oxygen
delivery (DO2).

Hypoxemia — Oxygen is necessary for aerobic metabolism such that low levels of oxygen
(hypoxemia) are deleterious, the mechanisms of which are discussed separately. (See "Oxygen
delivery and consumption" and "Measures of oxygenation and mechanisms of hypoxemia".)

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 10/41


7/9/2020 Arterial blood gases - UpToDate

Hyperoxia — Too much supplemental oxygen (hyperoxia) also has deleterious effects, the
details of which are discussed separately. (See "Pulmonary consequences of supplemental
oxygen".)

Ventilation — Measurement of pH, PaCO2, and base excess provide sufficient data to accurately
assess patients for the presence of acute and chronic forms of respiratory acidosis and alkalosis
(ie indices of ventilation).

Respiratory acidosis — Respiratory acidosis is a disturbance in acid-base balance usually


due to alveolar hypoventilation that can be acute or chronic. It is characterized by an increased
PaCO2 >45 mmHg (hypercapnia) and a reduction in pH (pH <7.35). The mechanisms, etiologies,
and clinical manifestations, as well as the distinction between acute and chronic hypercapnia and
the approach to patients with hypercapnic respiratory failure are discussed separately (table 2).
(See "Mechanisms, causes, and effects of hypercapnia" and "The evaluation, diagnosis, and
treatment of the adult patient with acute hypercapnic respiratory failure".)

Respiratory alkalosis — Respiratory alkalosis is usually due to alveolar hyperventilation which


leads to a decrease in PaCO2 (hypocapnia) and an increase in the pH. It can also be acute or
chronic. In acute respiratory alkalosis, the PaCO2 level is below the lower limit of normal (<35
mmHg or 4.7 kPa) and the serum pH is appropriately alkalemic (>7.45) (figure 11). In states of
chronic respiratory alkalosis, the PaCO2 level is also below the lower limit of normal (<35 mmHg
or 4.7 kPa), but the pH level is at or close to normal. Calculating the appropriate compensatory
response to acute respiratory alkalosis is described separately. (See "Simple and mixed acid-base
disorders", section on 'Response to respiratory alkalosis'.)

A respiratory alkalosis develops when the lungs are stimulated to remove more carbon
dioxide that is produced metabolically in the tissues. The stimulus to increase respiratory
drive is controlled by central and peripheral factors (algorithm 1). Thus, respiratory alkalosis is
commonly encountered in anxiety, panic, pain, fever, psychosis, and hyperventilation
syndrome. Respiratory alkalosis can also be found in any medical condition that increases
alveolar ventilation including pulmonary embolism, heart failure, or mechanical ventilation, as
well as in stroke, meningitis, high altitude, right-to-left shunts, pregnancy, hyperthyroidism,
and aspirin overdose (table 3 and algorithm 2). Decreased carbon dioxide production from
excessive sedation, skeletal muscle paralysis, hypothermia, or hypothyroidism is a rare
mechanism that may contribute to respiratory alkalosis but is rarely a primary etiology for
hypocapnia.

Acute hypocapnia can induce cerebral vasoconstriction resulting in dizziness and


lightheadedness. Paresthesias of the hands, feet or mouth may also be present due to peripheral
hypocalcemia (from increased binding of calcium to serum albumin). Patients may also complain
of chest pain or dyspnea and severe cases can be associated with carpopedal spasm, tetany,
mental confusion, syncope, and seizures. Acute hypocapnia causes a reduction of serum levels of

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 11/41


7/9/2020 Arterial blood gases - UpToDate

potassium and phosphate secondary to increased intracellular shifts of these ions. Hyponatremia
and hypochloremia are rare. Consequently, severe alkalosis (>7.6) is worrisome for the
development of seizures and cardiac instability. (See "Hyperventilation syndrome in adults",
section on 'Clinical presentation'.)

Respiratory alkalosis is typically managed by treating the underlying cause (eg, reassurance,
anxiolytic, pain control) and using maneuvers to reduce alveolar ventilation (eg, sedation, reduce
respiratory rate and/or tidal volume when on mechanical ventilation).

Acid-base balance — Measurement of pH, PaCO2, and base excess provide sufficient data to
accurately assess simple and mixed acid-base disturbances which are discussed separately in the
following topics:

● Acute and chronic metabolic acidosis (table 4) (see "Approach to the adult with metabolic
acidosis" and "Pathogenesis, consequences, and treatment of metabolic acidosis in chronic
kidney disease")

● Acute and chronic respiratory acidosis (table 2) (see "The evaluation, diagnosis, and
treatment of the adult patient with acute hypercapnic respiratory failure" and "Mechanisms,
causes, and effects of hypercapnia")

● Acute and chronic metabolic alkalosis (table 5) (see "Causes of metabolic alkalosis" and
"Clinical manifestations and evaluation of metabolic alkalosis" and "Pathogenesis of metabolic
alkalosis" and "Treatment of metabolic alkalosis")

● Acute and chronic respiratory alkalosis (table 3) (see 'Ventilation' above)

Abnormal hemoglobins — Measurement of abnormal hemoglobins is rarely indicated. While


some laboratories routinely measure levels of carboxyhemoglobin and methemoglobin, others
require a specific request for testing when abnormally high levels are suspected.

Carboxyhemoglobinemia — Elevated levels of carboxyhemoglobin are most commonly seen


in carbon monoxide poisoning. Carbon monoxide poisoning should be suspected in patients with
neurologic symptoms and a history of exposure (smoke inhalation from a fire, exposure to vehicle
exhaust). Further details regarding the diagnosis and treatment of carbon monoxide poisoning are
discussed separately. (See "Carbon monoxide poisoning" and "Inhalation injury from heat, smoke,
or chemical irritants".)

Methemoglobinemia — Methemoglobinemia can be congenital (eg, cytochrome b5 reductase


or cytochrome b5 deficiency, hemoglobin M disease) or acquired (usually drugs or toxins (table
6)). Methemoglobinemia should be suspected in the appropriate clinical context (eg, following
lidocaine administration) when patients demonstrate a reduction in peripheral saturation and
become cyanotic. It is supported when the oxygen saturation as measured by pulse oximetry
(SpO2) is more than 5 percent lower than the oxygen saturation calculated from arterial blood gas
https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 12/41
7/9/2020 Arterial blood gases - UpToDate

analysis (SaO2) ("saturation gap") and when pulse oximetry shows an oxygen saturation ≤90
percent and the arterial oxygen partial pressure is ≥70 mmHg. A detailed discussion of the
etiology, diagnosis, and treatment of methemoglobinemia is provided separately. (See
"Methemoglobinemia".)

Sources of error — Regardless of the method used to withdraw arterial blood, several sources of
error exist that can typically be easily avoided by good sample care.

● Gas diffusion through the plastic syringe and consumption of oxygen by leukocytes is a
potential source of error that results in a falsely low PaO2 when the sample is left for
prolonged periods at room temperature. However, the clinical significance of this error is
minimal if the sample is placed on ice and analyzed within 15 minutes [16-19]. While using a
glass syringe will prevent gas diffusion, this solution is impractical.

● The heparin that is added to the syringe as an anticoagulant can decrease the pH if acidic
heparin is used and the dismissal of heparin from the syringe is incomplete. It can also dilute
the PaCO2, resulting in a falsely low value [16,20]. When an ABG syringe is used, the amount
of heparin solution used should be minimized and at least 2 mL of blood should be obtained.
Detailed discussion of ABG equipment is discussed above. (See 'Equipment' above.)

● Air bubbles that exceed 1 to 2 percent of the blood volume can cause a falsely high PaO2 and
a falsely low PaCO2 [10]. The magnitude of this error depends upon the difference in gas
tensions between blood and air, the exposure surface area (which is increased by agitation),
and the time from specimen collection to analysis. The clinical significance of this error can be
decreased by gently tapping on the syringe to remove the bubbles after the sample has been
withdrawn and analyzing the sample as soon as possible [17,21]. (See 'Technique' above.)

● Some studies suggest that ABGs estimate the systemic acid-base balance and oxygenation
but do not accurately reflect tissue levels in states of shock [22-24]. As an example, one study
of patients who underwent cardiopulmonary resuscitation compared blood gas values in blood
simultaneously drawn from an arterial catheter and a pulmonary artery catheter (PAC) [22].
Compared with PAC samples, arterial pH was higher (7.42 versus 7.14) and PaCO2 was
lower (32 mmHg versus 74 mmHg). If PAC results more closely reflect the acid-base status at
the tissue level, then the arterial measurements can lead to the mistaken assumption that
acid-base balance in tissues is being maintained. However, measurement of ABGs from
PACs to assess gas exchange is impractical (PACs are rarely placed) and not adequately
validated such that it cannot be routinely recommended.

SOCIETY GUIDELINE LINKS

Links to society and government-sponsored guidelines from selected countries and regions
around the world are provided separately. (See "Society guideline links: Assessment of
https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 13/41
7/9/2020 Arterial blood gases - UpToDate

oxygenation and gas exchange".)

SUMMARY AND RECOMMENDATIONS

● An arterial blood gas (ABG) is a test that measures the oxygen tension (PaO2), carbon
dioxide tension (PaCO2), acidity (pH), oxyhemoglobin saturation (SaO2), and bicarbonate
(HCO3) concentration in arterial blood. Some blood gas analyzers also measure the
methemoglobin, carboxyhemoglobin, and hemoglobin levels. (See 'Introduction' above.)

● ABGs are frequently used to detect and monitor indices of oxygenation, ventilation, and acid-
base balance, as well as quantify levels of carboxyhemoglobin and methemoglobin. Absolute
contraindications include an abnormal modified Allen's test, distorted anatomy, infection, or
severe peripheral vascular disease at the puncture site. Arterial blood draws and in particular
catheter insertion should be avoided in patients with severe coagulopathy or in whom
thrombolytic therapy is being administered as well as in patients with active Raynaud's
disease. Therapeutic anticoagulation and antiplatelet agents including aspirin are not
generally considered as contraindications to ABG needle stick sampling. (See 'Indications and
contraindications' above.)

● Technical challenges arise in patients who are uncooperative or in whom pulses cannot be
easily identified (eg, shock, vasopressor use), as well as in patients who cannot be positioned
appropriately (eg, joint contractures) or in obese or edematous patients when the usual
anatomic landmarks are hard to identify. In such cases, ultrasound may be useful to locate the
artery and reduce potential complications of repeated puncture and consequent injury to the
target vessel. (See 'Technical challenges' above.)

● Percutaneous needle puncture refers to the withdrawal of arterial blood via a needle stick. It
needs to be repeated every time an ABG is performed. Thus, it is suitable for patients who
require a limited number of arterial draws (eg, daily or less than once daily during an
admission to hospital). If recurrent sampling is required, clinicians should at minimum rotate
puncture sites (eg, right and left radial) or consider placing an indwelling catheter (see 'Arterial
sampling' above):

• Common sites include the radial, femoral, brachial, axillary, or dorsalis pedis artery. There
is no evidence that any site is superior to the others. However, the radial artery is used
most often because it is accessible and more comfortable for the patient than the
alternative sites. (See 'Site selection' above.)

• For patients undergoing radial or dorsalis pedis artery puncture, we suggest evaluating
the collateral flow to those vessels prior to puncture (eg, modified Allen's test for radial
artery puncture) (Grade 2C). For other sites, distal pulses can be assessed prior to

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 14/41


7/9/2020 Arterial blood gases - UpToDate

arterial puncture. Poor collateral flow or weak distal pulses should prompt arterial
puncture at an alternate site. (See 'Ensure collateral circulation' above.)

• Once the target artery has been identified, the planned puncture site should be sterilely
prepared. Injectable lidocaine is typically not used. The artery should be punctured with a
small needle and syringe, 2 to 3 mL of blood should be withdrawn, and then the needle
should be removed. Finally, pressure should be applied to the puncture site for five
minutes or longer. (See 'Technique' above.)

• Complications due to percutaneous needle puncture are rare, but include pain, bleeding,
bruising, hematoma, nerve injury, and vasospasm. Infection, limb ischemia, and
compartment syndrome are rare but serious complications. (See 'Complications' above.)

● Indwelling catheters provide continuous access to arterial blood, which is helpful when
frequent blood gases are needed (eg, patients in respiratory failure on mechanical ventilation,
patients requiring serial ABGs for monitoring acid-base disorders). The sample preparation
and care is the same as for ABGs drawn using a needle. (See 'Indwelling catheters' above
and "Intra-arterial catheterization for invasive monitoring: Indications, insertion techniques,
and interpretation".)

● Regardless of the method used to withdraw the arterial blood, the amount of heparin solution
should be minimized, at least 2 mL of blood should be obtained, air bubbles should be
removed, and the specimen should immediately be placed on ice and analyzed as quickly as
possible. Results are usually available within 5 to 15 minutes. (See 'Sources of error' above
and 'Transport and analysis' above.)

● The range of normal values varies among laboratories. In general, the normal pH is 7.35 to
7.45, the normal PaCO2 is 35 to 45 mmHg (4.7 to 6 kPa), and the normal HCO3 concentration
is 21 to 27 mEq/L. Normal PaO2 and SaO2 have not been defined; however, it seems
reasonable to consider a resting PaO2 >80 mmHg (10.7 kPa) and SaO2 >95 percent normal,
unless the new values are substantially different than prior values. (See 'Normal values'
above.)

● Measurement of the PaO2 and SaO2 provide data on oxygenation (hypoxemia or hyperoxia).
Measurement of the pH, PaCO2, and base excess provide sufficient data to accurately assess
ventilation (respiratory acidosis and alkalosis) as well as assess complex and simple acid-
base disturbances (metabolic and respiratory acidosis and alkalosis). Measurement of
carboxyhemoglobin and methemoglobin is rarely indicated but should be assessed when
abnormally high levels are suspected (eg, carbon monoxide poisoning, lidocaine-induced
methemoglobinemia, respectively). (See 'Oxygenation' above and 'Ventilation' above and
'Acid-base balance' above and 'Abnormal hemoglobins' above.)

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 15/41


7/9/2020 Arterial blood gases - UpToDate

● Sources of error include gas diffusion (falsely low PaO2), incomplete dismissal of heparin
(falsely low pH and PaCO2), and air bubbles (falsely high PaO2 and a falsely low PaCO2).
ABGs estimate the systemic acid-base balance but may not reflect the acid-base status at the
tissue level in states of shock. (See 'Sources of error' above.)

Use of UpToDate is subject to the Subscription and License Agreement.

REFERENCES

1. AARC clinical practice guideline. Sampling for arterial blood gas analysis. American
Association for Respiratory Care. Respir Care 1992; 37:913.

2. Kohonen M, Teerenhovi O, Terho T, et al. Is the Allen test reliable enough? Eur J
Cardiothorac Surg 2007; 32:902.

3. Jarvis MA, Jarvis CL, Jones PR, Spyt TJ. Reliability of Allen's test in selection of patients for
radial artery harvest. Ann Thorac Surg 2000; 70:1362.

4. Kaye W. Invasive monitoring techniques. In: Textbook of Advanced Cardiac Life Support, Am
erican Heart Association, Dallas.

5. Asif M, Sarkar PK. Three-digit Allen's test. Ann Thorac Surg 2007; 84:686.

6. Guidelines for the measurement of respiratory function. Recommendations of the British


Thoracic Society and the Association of Respiratory Technicians and Physiologists. Respir
Med 1994; 88:165.

7. Lightowler JV, Elliott MW. Local anaesthetic infiltration prior to arterial puncture for blood gas
analysis: a survey of current practice and a randomised double blind placebo controlled trial.
J R Coll Physicians Lond 1997; 31:645.

8. Hess CE, Nichols AB, Hunt WB, Suratt PM. Pseudohypoxemia secondary to leukemia and
thrombocytosis. N Engl J Med 1979; 301:361.

9. Mehta A, Lichtin AE, Vigg A, Parambil JG. Platelet larceny: spurious hypoxaemia due to
extreme thrombocytosis. Eur Respir J 2008; 31:469.

10. Williams AJ. ABC of oxygen: assessing and interpreting arterial blood gases and acid-base
balance. BMJ 1998; 317:1213.

11. Severinghaus JW. Simple, accurate equations for human blood O2 dissociation
computations. J Appl Physiol Respir Environ Exerc Physiol 1979; 46:599.

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 16/41


7/9/2020 Arterial blood gases - UpToDate

12. Shapiro BA. Temperature correction of blood gas values. Respir Care Clin N Am 1995; 1:69.

13. Hansen JE. Arterial blood gases. Clin Chest Med 1989; 10:227.

14. Bacher A. Effects of body temperature on blood gases. Intensive Care Med 2005; 31:24.

15. Ream AK, Reitz BA, Silverberg G. Temperature correction of PCO2 and pH in estimating
acid-base status: an example of the emperor's new clothes? Anesthesiology 1982; 56:41.

16. Bageant, RA. Variations in arterial blood gas measurements due to sampling techniques.
Respir Care 1975; 20:565.

17. Harsten A, Berg B, Inerot S, Muth L. Importance of correct handling of samples for the
results of blood gas analysis. Acta Anaesthesiol Scand 1988; 32:365.

18. Evers W, Racz GB, Levy AA. A comparative study of plastic (polypropylene) and glass
syringes in blood-gas analysis. Anesth Analg 1972; 51:92.

19. Smeenk FW, Janssen JD, Arends BJ, et al. Effects of four different methods of sampling
arterial blood and storage time on gas tensions and shunt calculation in the 100% oxygen
test. Eur Respir J 1997; 10:910.

20. Hansen JE, Simmons DH. A systematic error in the determination of blood PCO2. Am Rev
Respir Dis 1977; 115:1061.

21. Mueller RG, Lang GE, Beam JM. Bubbles in samples for blood gas determinations. A
potential source of error. Am J Clin Pathol 1976; 65:242.

22. Weil MH, Rackow EC, Trevino R, et al. Difference in acid-base state between venous and
arterial blood during cardiopulmonary resuscitation. N Engl J Med 1986; 315:153.

23. Adrogué HJ, Rashad MN, Gorin AB, et al. Assessing acid-base status in circulatory failure.
Differences between arterial and central venous blood. N Engl J Med 1989; 320:1312.

24. Mathias DW, Clifford PS, Klopfenstein HS. Mixed venous blood gases are superior to arterial
blood gases in assessing acid-base status and oxygenation during acute cardiac tamponade
in dogs. J Clin Invest 1988; 82:833.

Topic 1648 Version 27.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 17/41


7/9/2020 Arterial blood gases - UpToDate

GRAPHICS

Anatomy of the radial artery

Schematic representation of the arterial supply to the ventral surface of the


hand. Collateral circulation to the radial artery is provided by the ulnar artery
through the deep and superficial volar arterial arches.

Graphic 55221 Version 5.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 18/41


7/9/2020 Arterial blood gases - UpToDate

Radial artery cannulation

Technique of radial artery cannulation. The radial artery is palpated between the
distal radius and the tendon of the flexor carpi radialis.

Redrawn from American Heart Association. Textbook of Advanced Cardiac Life


Support, 1994.

Graphic 82119 Version 1.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 19/41


7/9/2020 Arterial blood gases - UpToDate

Brachial artery anatomy

Schematic representation of the relationship of the brachial artery to the


antecubital crease and the median nerve. The artery should be entered just
above the antecubital crease.

Graphic 57543 Version 1.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 20/41


7/9/2020 Arterial blood gases - UpToDate

Brachial artery puncture

Technique of brachial artery puncture. The brachial artery is palpable in the


antecubital fossa just medial to the biceps tendon. The needle should enter the
brachial artery just above the antecubital crease.

Redrawn from American Heart Association. Textbook of Advanced Cardiac Life


Support, 1994.

Graphic 69312 Version 1.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 21/41


7/9/2020 Arterial blood gases - UpToDate

Femoral artery anatomy

Schematic representation of the relationship of the common femoral artery to


the femoral vein and femoral nerve.

Graphic 75120 Version 1.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 22/41


7/9/2020 Arterial blood gases - UpToDate

Femoral artery puncture

Technique of femoral artery puncture. The femoral artery can be palpated just
below the midpoint of the inguinal ligament. The needle should be inserted at a 90
degree angle toward the pulsation for a single sampling of arterial blood. For
catheter placement, the needle should be inserted at a 45 degree angle in a
cephalad direction (as shown).

Adapted from the American Heart Association. Textbook of Advanced Cardiac Life
Support 1994.

Graphic 50204 Version 2.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 23/41


7/9/2020 Arterial blood gases - UpToDate

Axillary artery anatomy

The axillary artery is palpated within the axilla when the arm is abducted and externally
rotated.

Adapted from American Heart Association. Textbook of Advanced Cardiac Life Support, 1994.

Graphic 55334 Version 4.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 24/41


7/9/2020 Arterial blood gases - UpToDate

Axillary artery puncture

Technique of axillary artery puncture. The arm should be hyperabducted and


externally rotated. The needle should be inserted into the artery as high as
possible within the axilla.

Adapted from American Heart Association. Textbook of Advanced Cardiac Life


Support, 1994.

Graphic 67106 Version 1.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 25/41


7/9/2020 Arterial blood gases - UpToDate

Anatomy of dorsalis pedis artery

The dorsalis pedis artery is located lateral to the extensor hallucis longus
tendon.

Redrawn from American Heart Association. Textbook of Advanced Cardiac Life


Support, 1994.

Graphic 54240 Version 4.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 26/41


7/9/2020 Arterial blood gases - UpToDate

Modified Allen test

The patient's hand is initially held high while the fist is clenched and both radial
and ulnar arteries are compressed (A); this allows the blood to drain from the
hand. The hand is then lowered (B) and the fist is opened (C). After pressure is
released over the ulnar artery (D), color should return to the hand within six
seconds, indicating a patent ulnar artery and an intact superficial palmar arch.

Redrawn from American Heart Association. Textbook of Advanced Cardiac Life


Support, 1994.

Graphic 70306 Version 1.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 27/41


7/9/2020 Arterial blood gases - UpToDate

The Allen test

In the Allen test, the patient is instructed to make a fist, which will empty the
blood from the hand and fingers (A). The examiner's thumbs are then pressed
down across the thenar and hypothenar eminences to the wrist to occlude the
radial and ulnar arteries. The patient then opens the hand, making sure not to
overextend the fingers. The pressure on the ulnar artery is then released while
the radial artery is still compressed (B). The hand does not fill with blood. Note
the paleness of the hand on the right compared with the hand on left, indicating
occlusion of the ulnar artery distal to the wrist (abnormal test result). If there is
prompt return of color to the hand (indicating a normal test result), the test is
repeated except this time pressure on the radial artery is released while the
ulnar artery remains compressed.

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 28/41


7/9/2020 Arterial blood gases - UpToDate

Reproduced with permission from: Olin JW, Lie JT, Thromboagiitis (Buerger's
disease). In: Current management of hypertensive and vascular disease, Cookie JP,
Frohlich ED, (Eds), Mosby-Year Book, St Louis 1992. p.265. Copyright © Elsevier
Science.

Graphic 79685 Version 5.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 29/41


7/9/2020 Arterial blood gases - UpToDate

Components of a typical arterial blood gas kit

Image displays a typical arterial blood gas kit: arterial blood gas syringe, protective needle,
syringe cap, iodine and alcohol preparation swabs, gauze, patient label, biohazard ice bag,
and adhesive bandage.

Reproduced with permission. Copyright © 2016 A-1 Medical Integration.

Graphic 103744 Version 2.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 30/41


7/9/2020 Arterial blood gases - UpToDate

The effect of temperature on blood gas measurements

Temperature
pH PCO 2 PO 2
ºC ºF

20 68 7.65 19 27

30 86 7.50 30 51

35 95 7.43 37 70

36 97 7.41 38 75

37 98 7.40 40 80

38 100 7.39 42 85

40 104 7.36 45 97

Adapted from: Shapiro, Peruzzi, Kozelowski-Templin: Clinical Application of Blood Gases, ed 5. St. Louis, Mosby-Year
Book, 1994, p. 128.

Graphic 59630 Version 2.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 31/41


7/9/2020 Arterial blood gases - UpToDate

Etiologies and mechanism of hypercapnia

Respiratory pathway affecting carbon dioxide elimination


Central nervous system
"Won't breathe"

Peripheral nervous system


Respiratory muscles

"Can't breathe"
Chest wall and pleura

Upper airway

Lungs Abnormal gas exchange: "Can't breathe enough"

Schematic figure representing the respiratory pathway, along which a variety of diseases can affect carbon dioxide
elimination and result in hypercapnia. Note that gas exchange abnormalities alone are relatively uncommon causes
of hypercapnia, but gas exchange problems in the setting of reduced mechanical capability of the ventilatory pump
are very common explanations for acute and chronic hypercapnia.

Mechanism and etiologies of hypercapnia


Mechanism Etiologies

Decreased minute ventilation (global hypoventilation; extra pulmonary causes)

Decreased central Sedative overdose (eg, narcotic or benzodiazepine, some anesthetics, tricyclic
respiratory drive antidepressants)
Encephalitis
Stroke
Central and obstructive sleep apnea
Obesity hypoventilation
Congenital central alveolar hypoventilation
Brainstem disease
Metabolic alkalosis
Hypothyroidism*
Hypothermia
Starvation

Decreased Primary spinal Thoracic cage disorders Metabolic disorders Δ


respiratory cord/lower motor Kyphoscoliosis Hypophosphatemia
neuromuscular or neuron/muscle Thoracoplasty Hypomagnesemia
thoracic cage disorders
Flail Chest Hypothyroidism
function Cervical spine injury
Ankylosing Hyperthyroidism
or disease (eg,
spondylitis
trauma Toxins, poisoning,
Pectus excavatum
syringomyelia) ¶ drugs
Fibrothorax
Amyotrophic lateral Tetanus
sclerosis Dinoflagellate
Poliomyelitis poisoning
Guillain-Barré Shellfish poisoning
syndrome (red tide)
Phrenic nerve injury Ciguatera poisoning
Critical illness Botulism
polymyoneuropathy Organophosphates
Myasthenia gravis Succinylcholine and
Muscular dystrophy neuromuscular

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 32/41


7/9/2020 Arterial blood gases - UpToDate

Polymyositis blockade
Tetanus Procainamide
Transverse myelitis
(eg, multiple
sclerosis)
Tick paralysis
Acute intermittent
porphyria
Eaton Lambert
syndrome
Neuralgic
amyotrophy
Periodic paralysis
Glycogen storage
and mitochondrial
diseases
Respiratory muscle
fatigue

Increased dead space (gas exchange abnormalities; pulmonary parenchymal causes or airway disorders)

Anatomic Short shallow breathing

Physiologic Pulmonary embolism (usually severe)


Pulmonary vascular disease (usually severe)
Dynamic hyperinflation (eg, upper and lower airway disorders including chronic
obstructive pulmonary disease, severe asthma)
Endstage interstitial lung disease

Increased carbon dioxide production

Fever
Thyrotoxicosis
Increased catabolism (sepsis, steroids)
Overfeeding
Metabolic acidosis
Exercise

Multifactorial

Upper airway disorders ◊


Severe laryngeal or tracheal disorders
(stenosis/tumors/angioedema/tracheomalacia)
Vocal cord paralysis
Epiglottitis
Foreign body aspiration
Retropharyngeal disorders
Obstructive goiter

Decreased mechanical ventilation can also cause hypercapnic respiratory acidosis (eg, permissive hypercapnia).
Importantly, any factor that limits the mechanical function of the ventilatory pump (such as airway obstruction or
weak muscles), when combined with a gas exchange abnormality (increased physiological dead space), may lead
to hypercapnia. For further details regarding the mechanisms that underlie these pathologies, please refer to the
UpToDate topic on mechanisms, causes, and effects of hypercapnia.

* Hyperthyroidism is also a rare cause of respiratory muscle weakness.


¶ Injury or disease process needs to be between cervical spine level 3 and 5 (C3 to 5) for clinically significant
diaphragmatic paresis/paralysis to occur.
Δ Hypermagnesemia, hypokalemia, and hypercalcemia can also cause respiratory muscle weakness and contribute to
hypercapnia.
◊ Upper airway disorders are rare causes of hypercapnia. They either diminish total ventilation or lead to dynamic
hyperinflation and reduced tidal volume, while simultaneously causing increased work of breathing and carbon dioxide
production.

Graphic 103091 Version 3.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 33/41


7/9/2020 Arterial blood gases - UpToDate

Compensations to acute respiratory acidosis and


alkalosis

Combined significance bands for plasma pH and concentrations of H+ and HCO3-


in acute respiratory acidosis and alkalosis in humans. In uncomplicated acute
respiratory acid-base disorders, values for the H+ and HCO3- concentrations
will, with an estimated 95 percent probability, fall within the band. Values lying
outside the band indicate the presence of a complicating metabolic acid-base
disturbance.

Arbus GS, Herbert LA, Levesque PR, et al. N Engl J Med 1969; 280:117. By permission
from the New England Journal of Medicine.

Graphic 58687 Version 5.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 34/41


7/9/2020 Arterial blood gases - UpToDate

Respiratory pathway affecting carbon dioxide


elimination

Schematic figure representing the respiratory pathway, along which a variety of


diseases can affect carbon dioxide elimination and result in hypercapnia. Note
that gas exchange abnormalities alone are relatively uncommon causes of
hypercapnia, but gas exchange problems in the setting of reduced mechanical
capability of the ventilatory pump are very common explanations for acute and
chronic hypercapnia.

Graphic 103093 Version 1.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 35/41


7/9/2020 Arterial blood gases - UpToDate

Causes of respiratory alkalosis

Central nervous system Pain


Hyperventilation syndrome
Anxiety and panic disorders
Psychosis
Fever
Intracranial pathology (eg, stroke, meningitis encephalitis, tumors, traumatic
injury)
Drug withdrawal

Drugs and toxins Overdoses of salicylate, methylxanthine, catecholamines, nicotine


Progesterone and medroxyprogesterone
Doxapram
Toxic shock

Pulmonary Hypoxemia
Pneumothorax
Pneumonia
Pulmonary edema
Pulmonary embolism
Aspiration
Interstitial lung disease

Miscellaneous High altitude


Right-to-left shunts
Pregnancy
Hyperthyroidism
Severe anemia
Hyperventilation on mechanical ventilation
Recovery phase metabolic acidosis
Chronic liver disease
Prolonged paralysis

Graphic 103740 Version 1.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 36/41


7/9/2020 Arterial blood gases - UpToDate

Respiratory system anatomy: Ventilation control

Schematic figure representing the respiratory pathway, along which a variety of


diseases can affect carbon dioxide elimination and result in hypocapnia.

Graphic 103743 Version 1.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 37/41


7/9/2020 Arterial blood gases - UpToDate

Major causes of metabolic acidosis according to mechanism and anion gap

Mechanism of
Increased AG Normal AG
acidosis

Increased acid production Lactic acidosis

Ketoacidosis
Diabetes mellitus
Starvation
Alcohol associated

Ingestions
Methanol
Ethylene glycol
Aspirin
Toluene (if early or if Toluene ingestion (if late and if renal function is preserved;
kidney function is due to excretion of sodium and potassium hippurate in the
impaired) urine)
Diethylene glycol
Propylene glycol

D-lactic acidosis A component of non-AG metabolic acidosis may coexist


due to urinary excretion of D-lactate as Na and K salts
(which represents potential HCO 3 )

Pyroglutamic acid (5-


oxoproline)

Loss of bicarbonate or Diarrhea or other intestinal losses (eg, tube drainage)


bicarbonate precursors
Type 2 (proximal) RTA

Posttreatment of ketoacidosis

Carbonic anhydrase inhibitors

Ureteral diversion (eg, ileal loop)

Decreased renal acid Chronic kidney disease Chronic kidney disease and tubular dysfunction (but
excretion relatively preserved glomerular filtration rate)

Type 1 (distal) RTA

Type 4 RTA (hypoaldosteronism)

AG: anion gap; RTA: renal tubular acidosis.

Graphic 77464 Version 12.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 38/41


7/9/2020 Arterial blood gases - UpToDate

Major causes of metabolic alkalosis

Gastrointestinal hydrogen loss


Vomiting or nasogastric suction

Congenital chloride diarrhea (congenital chloridorrhea)

Renal hydrogen loss


Primary mineralocorticoid excess (primary hyperaldosteronism, Cushing syndrome [usually associated with
ectopic ACTH] exogenous mineralocorticoids)

Mineralocorticoid excess-like states

Licorice ingestion

Liddle syndrome

Apparent mineralocorticoid excess

Loop or thiazide diuretics

Bartter or Gitelman syndrome

Status post chronic hypercarbia

Severe hypokalemia causing both intracellular hydrogen shift and renal hydrogen
excretion
Villous adenoma (may manifest metabolic alkalosis, metabolic acidosis, or both)

Laxative abuse (may manifest metabolic alkalosis, metabolic acidosis, or both)

Alkali administration with reduced renal function


Calcium-alkali syndrome*

Bicarbonate ingestion/infusion with impaired renal function

Contraction alkalosis

* Formerly called the milk-alkali syndrome. Now more commonly generated by ingestion of calcium carbonate rather than
the historic combination of milk, cream, and "sippy powders" (NaHCO 3 and alkaline calcium and bismuth salts).

Graphic 57489 Version 5.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 39/41


7/9/2020 Arterial blood gases - UpToDate

Medications and chemicals that may cause acquired methemoglobinemia

Medications
Amino salicylic acid (also called p-aminosalicylic acid or 4-aminosalicylic acid)

Clofazimine

Chloroquine

Dapsone

Local anesthetics, topical sprays and creams including benzocaine (in teething rings and ointments), lidocaine,
and prilocaine

Menadione

Metoclopramide

Methylene blue*

Nitroglycerin

Phenacetin

Phenazopyridine

Primaquine

Rasburicase

Quinones

Sulfonamides

Chemicals and environmental substances


Acetanilide (used in varnishes, rubber, and dyes)

Anilines and aniline dyes (eg, diaper and laundry marking inks, leather dyes, red wax crayons)

Antifreeze

Benzene derivatives (used as solvents)

Chlorates and chromates (used in chemical and industrial synthesis)

Hydrogen peroxide (used as a disinfectant and cleaner)

Naphthalene (used in mothballs)

Naphthoquinone (used in chemical synthesis)

Nitrates and nitrites (eg, amyl nitrite, farryl nitrite, sodium nitrite, nitrate- and nitrite-containing foods, nitric
oxide, well water)

Nitrobenzene (used as a solvent)

Paraquat (used in herbicides)

Resorcinol (used in resin melting and wood extraction)

Inherited disorders (extremely rare)


Cytochrome b5-reductase deficiency

Hemoglobin M disease

Refer to UpToDate topics on methemoglobinemia for additional details regarding these medications and chemicals,
as well as citations with supporting evidence for their role in causing methemoglobinemia and information on
congenital methemoglobinemia syndromes.

G6PD: glucose-6-phosphate dehydrogenase.


* While methylene blue is a recognized treatment for methemoglobinemia, it also has oxidant potential and may worsen
the clinical status of individuals with G6PD deficiency because it induces acute hemolysis that can further decrease oxygen
delivery to the tissues. In high doses, methylene blue can paradoxically increase methemoglobinemia.

Graphic 51406 Version 7.0

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 40/41


7/9/2020 Arterial blood gases - UpToDate

Contributor Disclosures
Arthur C Theodore, MD Grant/Research/Clinical Trial Support: Genentech [Scleroderma, Interstitial lung
disease]. Scott Manaker, MD, PhD Consultant/Advisory Boards: Expert witness in workers' compensation
and in medical negligence matters [General pulmonary and critical care medicine]. Equity Ownership/Stock
Options (Spouse): Johnson & Johnson; Pfizer. Other Financial Interest: National Board for Respiratory Care
[Director]. Geraldine Finlay, MD Consultant/Advisory Boards: LAM Board of directors, LAM scientific grant
review committee for The LAM Foundation.

Contributor disclosures are reviewed for conflicts of interest by the editorial group. When found, these are
addressed by vetting through a multi-level review process, and through requirements for references to be
provided to support the content. Appropriately referenced content is required of all authors and must conform
to UpToDate standards of evidence.

Conflict of interest policy

https://www.uptodate.com/contents/arterial-blood-gases/print?search=respiratory acidosis&source=search_result&selectedTitle=5~150&usage… 41/41

You might also like