Professional Documents
Culture Documents
Separating The Front and Back Half of The Monitor
Separating The Front and Back Half of The Monitor
N O TE Hold on to the display when loosening the screws so the display does not fall off.
2 Pull off the front housing. Do not pull the display off completely, only tilt it to the front, because
otherwise the flex panel adapter could be damaged.
111
5 Repair and Disassembly Separating the Front and Back Half of the monitor
Reassembly Note: Make sure the metal sheet on the back of the display is inserted into the noses of the
monitor rear housing when reassembling the two halves.
3 Unscrew the screws holding the flex panel adapter cable and pull off the flex cable carefully towards
you.
Black Spacer is
attached to main
board with one
screw
112
Exchanging the Backlight Tubes 5 Repair and Disassembly
Reassembly Note: Cables must be re-inserted into the plastic cable holder with a slight strain on them
towards the backlight tube. The cable holder functions as a strain relief.
2 Unplug the cables from the backlight inverter board
Old Version
New Version (Backwards Compatible)
Please note that due to its dimensions, the new version of the backlight inverter board is not fixed in a
straight position.
113
5 Repair and Disassembly Exchanging the Backlight Tubes
3 Unscrew the screws securing the backlight tubes and slide out the backlight tubes.
114
Removing the Flex Panel Adapter 5 Repair and Disassembly
3 Remove the two screws securing the power switch and the LED board and pull out this part of the
flex panel adapter cable.
N O TE The screws securing this board are self-cutting - turn in opposite direction first when re-inserting them
.
115
5 Repair and Disassembly Removing the Flex Panel Adapter
4 Remove one screw and then remove the touch controller board.
5 Unscrew the screw holding the metal sheet under touch controller board and remove the metal
sheet.
6 Slip a screwdriver under the end of the flex panel adapter cable and lift upwards to remove the
connector to the display.
116
Removing the Flex Panel Adapter 5 Repair and Disassembly
7 Unscrew the three screws and remove the flex panel adapter cable.
117
5 Repair and Disassembly Removing the Touchscreen
N O TE You must replace the touch panel and the touch controller board together in order for the monitor to
function correctly.
Reassembly Note: Plug the touch sensor cable into the touch controller board first, then re-insert the
touch board
118
Removing the Touchscreen 5 Repair and Disassembly
3 Remove the two screws securing the power switch and the LED board and pull out the board. The
board and the screws are part of the flex panel adapter cable.
N O TE The screws securing this board are self-cutting - turn in opposite direction first when re-inserting them
.
4 Remove the eight screws and carefully lift off the display assembly by releasing the two snaps in the
monitor bezel.
Snaps
CAUTION We recommend that this procedure is performed in a dust free environment. The display assembly may
be hard to remove from the touch panel due to the gasket (adhesive strips) holding the two together.
119
5 Repair and Disassembly Removing the Touchscreen
N O TE You must replace the touch panel and the touch controller board together in order for the monitor to
function correctly.
120