Professional Documents
Culture Documents
Nitotile EPW Grout: Constructive Solutions
Nitotile EPW Grout: Constructive Solutions
Nitotile EPW Grout is hygienic, stain-resistant, 3 component Nitotile EPW Grout is resistant to spillage of following chemicals
epoxy resin-based grout with a high degree of resistance to commonly encountered in industrial applications. Spillage re-
chemical attack, abrasion and impact. The cured grout does not sistance was tested for 24 hours exposure as per ASTM D1308.
transfer taints to food products, prevents the entry of bacteria - Water, Sea water
or dirt and is easily maintained in a sterile condition. - Alkali Solutions
It is designed for grouting glazed tiles, mosaic, vitrified and fully - Aqueous solutions of salts
vitrified tiles, ceramic tiles, industrial tiles, granites, marbles & - Soft drinks
other natural stones, etc. for both interior and exterior.
- Fruit juices
Advantages - Carbonated beverages
- Motor oils and lubricants
Resistant to mild chemicals and acids
- Cosmetics and toiletries.
Solvent free - can be used in confi ned areas
- Pharmaceutical products
Good resistance to abrasion and impact - Dairy products
Preparation
Hygienic - suitable for use in Laboratories, Hospitals and
Health centers Before application of the grout, remove debris in grout joints
and lightly sponge the tile surface to remove dust and dirt. Do
Suitable for joint width of 1mm - 12mm
not clean tiles with acid cleaners. In case acid cleaners were
Note : Wet areas like showers, swimming pools, fountains etc used to clean the tiles, ensure to wash the area with plenty of
should not be used for atleast 2 weeks following completion water before commencing grouting.
of grouting. Substrate temperature must be between 16°C and 32°C.
page 1 of 4
Nitotile EPW Grout
Application Limitations
Whilst the risk of tainting food is very low, it is still important to Nitotile EPW Grout should not be used when the temperature
physically segregate adjacent food preparation areas which are is below 5°C and falling. The product should not be exposed
to be operating during the grouting process. Ensure adequate to moving water during application. If any doubts arise con-
ventilation in working areas. cerning temperature or substrate conditions, consult your local
Fosroc office.
Using a hard rubber grout float, compact the grout into the joints
ensuring that they are completely filled. Work in small areas and
Estimating
remove as much excess from the tile surface as possible. Strike
of excess materials diagonally to the grout lines. Supply
Plug open-ended joints with the stiffer mix to prevent any
Nitotile EPW Grout is supplied in 1 kg & 5 kg packing.
slumping of the grout joints from occuring.
Storage
Shelf life
Technical support
Precautions
Health and safety
Additional information
Important note :
Fosroc products are guaranteed against defective materials and manufacture
and are sold subject to its standard terms and conditions of sale, copies
of which may be obtained on request. Whilst Fosroc endeavours to ensure
that any advice, recommendation specification or information it may give
is accurate and correct, it cannot, because it has no direct or continuous
Fosroc Chemicals control over where or how its products are applied, accept any liability
(India) Pvt. Ltd. either directly or indirectly arising from the use of its products whether
Head Office or not in accordance with any advice, specification, recommendation or
Embassy Point, No. 150, information given by it.
2nd Floor, Infantry Road,
Bangalore 560 001,
Karnataka
telephone fax e-mail
+91 80-42521900 +91 80-22281510 enquiry.india@fosroc.com
Regional Offices
www.fosroc.com
page 4 of 4 INDIA/2020/0909/A