Professional Documents
Culture Documents
Combined Height/Lining Laser: Operating Manual
Combined Height/Lining Laser: Operating Manual
KHR
Combined Height/Lining Laser
EL-T7127
Operating manual
Edition September 2006
Content Page
General .........................................................................Fehler! Textmarke nicht definiert.
Application.....................................................................Fehler! Textmarke nicht definiert.
KHR- Laser- preparing measuring run ................................................................................ 3
Start laser measuring run .................................................................................................... 6
Stop of laser measuring run ..........................................Fehler! Textmarke nicht definiert.
Start further section .......................................................Fehler! Textmarke nicht definiert.
Inspection and processing of the results .......................Fehler! Textmarke nicht definiert.
Storing of the ascertained data .....................................Fehler! Textmarke nicht definiert.
Preparation of working mode ........................................Fehler! Textmarke nicht definiert.
Stop of working mode....................................................Fehler! Textmarke nicht definiert.
2 SDG 7_4_1
General
The possible application „Recording of a KHR- Laser measurement“ is part of the
program WIN ALC.
Operating the vehicle-borne computer is to be seen in the WIN ALC - operating manual/
SDG 7.1.6, 7.2.2, 7.3.2
Application
In order to comment expected displacement- or lifting values or - if required - also
to change them a straight section is recorded by the combined height and lining
laser.
The laser measuring run can be extended to several sections.
The recording sections are put together by the processing mode.
Consecutively functions, such as key assignments, are described which refer only to the
laser-measuring-run-program and are therefore not contained in the above cited
description.
Symbols respectively their function are described with a temporary text display by locating
the mouse pointer on the symbol. Additionally the function of this symbol is described on
the lower bar, left side.
or
put symbol on inexplicit section of the menu in order to open the
respective auxiliary file for explanation.
SDG 7_4_1 3
After filling out the board and confirmation of the input the display of the measuring run will
be opened in form of a table and layout with detailed informations.
SDG 7_4_1 5
Display Stand-by
6 SDG 7_4_1
Start the section of measuring run with control key F5 or in menu bar
„KHR-measuring“-„start“ or symbol.
The measuring-run starts with the encoder impulse during the machine’s drive.
SDG 7_4_1 7
During the measuring marking points can be set with control key „F2“.
Move the laser vehicle ahead to the next point and adjust the laser
beam. Start additional measuring - section.
Display of the recorded displacement- and lifting values (yellow) and of the
measurement values of the new section.
The entered displacement- and lifting values will be built up or cut back linear within
the individual points. This corresponds to the addition of a straight line to the
recorded displacement- and lifting value. These straight lines result in a “frequency
polygon”.
10 SDG 7_4_1
Analysing display:
Field Displacement:
Recorded track position and frequency polygon.
For this purpose the operating with displacement/lifting correction - file is chosen.
The last used file is preselected. (Otherwise the selection of an other file is possible with
„Browse“).