Professional Documents
Culture Documents
Worksheets: Pruebas y Ajustes
Worksheets: Pruebas y Ajustes
Bienvenido: cr080x0006886x02
Producto: NO SE HA ESCOGIDO NINGUN EQUIPO
Modelo: NO SE HA ESCOGIDO NINGUN EQUIPO
Configuración: NO SE HA ESCOGIDO NINGUN EQUIPO
Pruebas y Ajustes
784C, 785C and 785C HAA Off-Highway Truck/Tractors Hydraulic System
Número de medio -SENR1498-03 Fecha de publicación -01/09/2004 Fecha de actualización -21/09/2004
i02199288
Worksheets
SMCS - 5102-081
Table 1
Hoist Test
Flash File
ECM Flash File
Date
Table 2
Visual Checks
Oil Filter
Air in Oil
Examination
Water in Oil
Table 3
Test Specification Actual Value
>
Hoist 65 °C (150 °F)
Oil Temperature <
121 °C (250 °F)
RAISE 14 to 16 Seconds 1.
Hoist Time ____________________________________
@ High Idle 2.
____________________________________
3.
____________________________________
Average
1.
____________________________________
LOWER 2.
Hoist Time 15 to 17 Seconds ____________________________________
@ High Idle 3.
____________________________________
Average
1.
____________________________________
FLOAT 2.
Hoist Time 15 to 17 Seconds ____________________________________
@ High Idle 3.
____________________________________
Average
Pilot Pressure
Low Idle
Parking Brake 4700 ± 200 kPa (680 ± 30 psi)
High Idle
Retraction
RAISE
Front Tap
Pressure 17225 ± 345 kPa (2500 ± 50
Rear Tap
@ High Idle psi)
LOWER
Front Tap
Pressure 3450 + 350 - 0 kPa (500 + 50 -
Rear Tap
@ High Idle 0 psi)
HOLD
Front Tap
Maximum
790 ± 20 kPa (115 ± 3 psi) Rear Tap
Pressure
FLOAT
Front Tap
Maximum
790 ± 20 kPa (115 ± 3 psi) Rear Tap
Pressure
SNUB
Front Tap
Maximum
790 ± 20 kPa (115 ± 3 psi) Rear Tap
Pressure
( 1 ) Refer to the Hydraulic System Testing and Adjusting, "Hoist Cylinder Performance - Test" for the specifications of
time.
Run the engine at high idle and record the observed data into the charts that are provided.
The rod for the body position sensor must be disconnected from the body, and the body position
sensor must be rotated to the RAISE position before the LOWER relief pressure can be tested.