Professional Documents
Culture Documents
4-Channel Motor Driver For DVD Player Am5954A
4-Channel Motor Driver For DVD Player Am5954A
4-Channel Motor Driver For DVD Player Am5954A
The AM5954A is a four-channel BTL driver IC for · Level Shift Circuit On Chip
driving the motors and actuators in products for DVD- · Internal Standby Mode
player drivers. Two of the channels use current feed- · Built-in Thermal Shutdown Circuit
back to minimize the current phase shift caused by the
influence of load inductance. This IC is an improved
Applications
version of AZ5954.
www.DataSheet4U.com
HSOP-28
1
Data Sheet
M28 Package
(HSOP-28)
VINFC 1 28 STBY
CFCerr1 2 27 BIAS
CFCerr2 3 26 VINTK
VINSL+ 4 25 CTKerr1
VINSL- 5 24 CTKerr2
VOSL 6 23 VINLD
VNFFC 7 22 GND
FIN FIN
(GND) (GND)
VCC 8 21 PVCC2
PVCC1 9 20 VNFTK
PGND 10 19 PGND
VOSL- 11 18 VOLD-
VOSL+ 12 17 VOLD+
VOFC- 13 16 VOTK-
VOFC+ 14 15 VOTK+
2
Data Sheet
Note 1: The indicated polarities for the output pin are for when all inputs are (+).
The output H bridge power supply pins are PVCC2 for the focus, tracking channel, PVCC1 for the loading
channel, and VCC for the pre-block and sled channel.
Always ensure that VCC ≥ PVCC.
3
Data Sheet
THERMAL STAND-
SHUT DOWN BY
1 28
VINFC STBY
10K 20K
2 27
CFCerr1 BIAS
7.5K
3 26
CFCerr2 VINTK
20k 10k
4 7.5k 25
VINSL+ CTKerr1
7.5k
5 24
VINSL- CTKerr2
7.5k
6 23
VOSL VINLD
7 22
VNFFC 2 GND
2
10K
VCC 10K
8 21
VCC PVCC2
25K PVCC2
9 PVCC1 20
PVCC1 15k
VNFTK
10 19
PGND PGND
11 18
VOSL- VOLD-
SLED LOADING
12 DRIVER DRIVER 17
VOSL+ VOLD+
13 16
VOFC- VOTK-
ACUATOR ACTUATOR
14 DRIVER DRIVER 15
VOFC+ VOTK+
4
Data Sheet
AM5954A -
BCD Semiconductor's Pb-free products, as designated with "E1" suffix in the part number, are RoHS compliant.
Note 2: Stresses greater than those listed under "Absolute Maximum Ratings" may cause permanent damage to the
device. These are stress ratings only, and functional operation of the device at these or any other conditions beyond
those indicated under "Recommended Operating Conditions" is not implied. Exposure to "Absolute Maximum
Ratings" for extended periods may affect device reliability.
Note 3: The power dissipation is reduced by 13.6mW for each increase in temperature of 1oC over 25oC.
5
Data Sheet
6
Data Sheet
100µH
RL2
RD
-
100pF V2 100µF
RL4 A IO2
16V +
VO4 VO2
VST VBIAS VIN2 VIN4
- + - +
28 27 26 25 24 23 22 21 20 19 18 17 16 15
AM5954A
1 2 3 4 5 6 7 8 9 10 11 12 13 14
VIN1 VIN3 - + - +
A ICC VO3 VO1
V VOP
+
100µF RL3 A IO1
100pF 16V
V1 RD -
RL1
100µH
7
Data Sheet
4 VCC=PVCC1=12V 12 VCC=PVCC1=12V
PVCC2=5V PVCC2=5V
3
8
BIAS=2.5V BIAS=2.5V
Output Voltage: VO (V)
0 0
-1
-4
RL=4Ω+100µH
-2 RL=20Ω
RL=8Ω+100µH -8
-3 RL=12Ω
RL=12Ω+100µH
RL=8Ω
-4 RL=20Ω+100µH -12
-5
-0.4 -0.2 0.0 0.2 0.4 -1.2 -0.8 -0.4 0.0 0.4 0.8 1.2
Figure 5. Driver I/O Characteristics Figure 6. Driver I/O Characteristics (Sled, Note 4)
(Focus and Tracking, Note 4)
5
4
VCC=PVCC=5V VCC=5V
Op Amp Output Voltage: OP OUT (V)
3 BIAS=2.5V 4
Output Voltage: VO (V)
1 3
0
-
-1 2
RL=4Ω +
OP IN
-2 RL=8Ω OP OUT
V
RL=12Ω 1
-3
RL=20Ω
-4
0
-1.0 -0.5 0.0 0.5 1.0 0 1 2 3 4 5
Figure 7. Driver I/O Characteristics (Loading, Note 4) Figure 8. Op Amp I/O Characteristics (Note 4)
8
Data Sheet
60 180
10K
10µ
g
40 90
2.5V
V IN
Phase: θ (deg)
20K
Gain: g (dB)
100µ
20 0
0 -90
θ
VCC=12V
-20 PVCC=5V -180
2.0
1.6
Power Dissipation (W)
1.2
0.8
0.4
0.0
0 50 100 150
O
Ambient Temperature ( C)
9
Data Sheet
DSP µ-COM
TRACKING
VCENTER
STANDBY
LOADING
FOCUS
SLED
TRACKING COIL
LOADING
5V MOTOR
Rd
M
28 27 26 25 24 23 22 21 20 19 18 17 16 15
AM5954A
1 2 3 4 5 6 7 8 9 10 11 12 13 14
5V or 12V
M
5V or 12V Rd
SLED
MOTOR
FOCUS COIL
10
Data Sheet
11
Data Sheet
17.890(0.704) 0.204(0.008)
18.190(0.716) 0.360(0.014)
0.400(0.016)
10.000(0.394) 1.270(0.050)
10.650(0.419)
7.400(0.291)
7.600(0.300)
0o ~ 8 o
0.230(0.009) 0.100(0.004)
0.470(0.019) 0.300(0.012)
2.180(0.086) 2.280(0.090)
2.330(0.092) 2.630(0.104)
12
http://www.bcdsemi.com
IMPORTANT NOTICE
BCD Semiconductor Manufacturing Limited reserves the right to make changes without further notice to any products or specifi-
cations herein. BCD Semiconductor Manufacturing Limited does not assume any responsibility for use of any its products for any
particular purpose, nor does BCD Semiconductor Manufacturing Limited assume any liability arising out of the application or use
of any its products or circuits. BCD Semiconductor Manufacturing Limited does not convey any license under its patent rights or
other rights nor the rights of others.
MAIN SITE
BCD Semiconductor Manufacturing Limited BCD Semiconductor Manufacturing Limited
- Wafer Fab - IC Design Group
Shanghai SIM-BCD Semiconductor Manufacturing Limited Advanced Analog Circuits (Shanghai) Corporation
800, Yi Shan Road, Shanghai 200233, China 8F, Zone B, 900, Yi Shan Road, Shanghai 200233, China
Tel: +86-21-6485 1491, Fax: +86-21-5450 0008 Tel: +86-21-6495 9539, Fax: +86-21-6485 9673