Professional Documents
Culture Documents
Polyester Resin Anchoring Grout
Polyester Resin Anchoring Grout
Polyester Resin Anchoring Grout
FEATURES Mixing
Ÿ High strength Both Part A and Part B components should be thoroughly stirred
Ÿ Tough, shrink-free & strong anchoring system before being mixed together. The entire contents of the Part A
Ÿ Vibration resistant should be poured in a mixing vessel and add Part B. Mix
Ÿ Resistance to heavy loads thoroughly using a mechanical mixer to achieve a smooth
Ÿ Corrosion resistant homogenous mix. Part mixing should be avoided.
Ÿ Can be placed wet and damp condition
Below is a table that indicates approx. weight of EP
PHYSICAL PROPERTIES 310 grout required in grams for 100mm hole depth
EP 310 @ 27 ± 1ºC
Hole Diameter Bar Diameter In
Pot life 50 minutes (mm) (mm)
12 16 20 25 32 40
Mixed material density Approx. 1.90 g/cc 20 48 .. .. .. .. ..
Full cure 7 days 25 95 76 .. .. .. ..
32 152 133 114 .. .. ..
Compressive strength 38 .. 228 190 143 .. ..
BS 6319 Part-2 45 .. .. 285 247 190 ..
8 Hours > 40 N/mm² 50 .. .. .. 342 285 171
1 day > 55 N/mm² 62 .. .. .. .. 532 428
7 day > 75 N/mm²
Pull Out Strength > 25 N/mm² Placing of Grout
The mixed grout should be poured into the prepared hole well
VOC Content 401.58 g/l within the gel time of the grout. Anchor bolt/ reinforcement rod
should be pressed into the hole to the required depth
PACK SIZE immediately after the grout is poured. Slight twisting action is
1 kg recommended for full contact of grout and maximum bond. The
Part A 250 g bar should be left undisturbed in the required position until the
Part B 750 g resin is set completely.
4 kg Cleaning
Part A 1 kg EP 310 can be removed from tools and equipment by using RTC
Part B 3 kg 100 immediately after use. Any hardened material will need to be
removed mechanically.
YIELD
Approx. 2.1 litres per 4 kg pack STORAGE AND SHELF LIFE
EP 310 has a shelf life of 6 months if kept in a dry, clean store
APPLICATON INSTRUCTIONS: between 5ºC and 30ºC in the original unopened containers. The
Hole preparation: product should be protected from frost, away from direct
Drill the correct size of hole in the concrete base and clean it sunlight and sources of heat.
thoroughly. Optimum performance can be achieved by rough
sided dust free holes. Cast hole should preferably be inverse
dovetail configuration for better anchorage.
EP 310
Polyester resin anchoring grout
DISPOSAL/SPILLAGE
Spillage of any of the product components should be absorbed
onto sand or other inert materials and transferred to a suitable
disposable vessel. Disposal of such spillage or empty packaging
should be in accordance with local waste disposal authority
regulations.