Professional Documents
Culture Documents
Pressure Vessel Inspection
Pressure Vessel Inspection
Pressure Vessel Inspection
Location Of Inpection :
Inspection work Ordered : Annual Certificate of Air Compressor : Visual , Function Test,
Inspection Type
Pressure Test,UT
Procedure & Rev :WI/SCTS-102 ,SOP/SCTS-05 Acceptance Standard : ASME BPVC SEC VIII ,DIV 1,2
Ispection Date : 13/07/2021 Inspection Due Date : 12/07/2022
Inspected Equipment Details
Equipment Name & Type : Air Compressor / Air receiver Serial No : N21602750
Pressure Switch (Cuton /cutoff) : 7 / 10 Bar Design Tempereture Range : -10 to 100 °C
The above mentioned equipment was pressure tested and No Leak Found
Result of Inspection
Refer : Appendix A
Inspected by : Approved by
This report is granted subject to the condition that is understood and agreed that nothing herein contained shall be deemed to relieve an y designer, manufacturer, seller, supplier,
repairer or operator of any warranty, express or implied, and Spectex calibration & Testing services liability shall be limited to the acts or omissions of its employees, agents and
subcontractors. Under no circumstances whatsoever shall Spectex calibration & Testing services be liable for any injury or damage to any person or occurring by reason of
negligent operation or any defect in materials, machinery, equipment or other items other than such defects ascertainable by normally accep ted standards and only those items
actually inspected by Spectex calibration & Testing services and which are covered by this report. This report shall not be reproduced except in full without the approval of the
Inspection Body and the client.
INSPECTION CHECKLIST
Report No : SCTS/INS/009-02/2021
1 Manufacturers Instruction ×
2 Previous Certificate ×
5 Corrosion ×
7 Shell Thickness ×
8 Support / Structural ×
9 Pipe Connections ×
10 Fitting ×
11 Hydrotest ×
12 Drain valves ×
13 Attachment ×
14 Welded Joint ×
15 General Condition ×
16 HouseKeeping× ×
Recommendation / comments