Professional Documents
Culture Documents
Standard Operation Procedure
Standard Operation Procedure
3. Run in the table feed and work and wheel spindles for about 10
minutes(Note : to run the wheel spindle, repeat turning on and off several
times, then increase the speed gradually.)
4. Condition the wheelhead for advancing and move the wheel to the dresser
position. Slightly apply the wheel to dress er and turn on coolant. Turn off
coolant after dressing.
6. When carrying out dressing or work grinding, condition the wheelhead for
advancing in order to prevent erroneous operation.
7. Set the table reversing stroke larry timer as applied the wheel to the
work, in sufficient setting many hit the wheel against the table lock and
wheelhead and this very dengerous.
8. Turn on workhead.
11. To grind the same work again only condition the wheelhead for advancing
with wheelhead ADV, however it will hit on the work if advancing form the
position as it is. So try to advance the wheelhead after a slight retract.
Then, start the table to carry out grounding. After that, repeat the above
steps.