Professional Documents
Culture Documents
Neutral Start Switch Malfunction
Neutral Start Switch Malfunction
Neutral Start Switch Malfunction
CIRCUIT DESCRIPTION
The neutral start switch detects the shift lever range and sends signals to the Engine & ECT ECU.
The Engine & ECT ECU receives signals (NSW, R, 2 and L) from the neutral start switch. When the signal
is not sent to the Engine & ECT ECU from the neutral start switch, the Engine & ECT ECU judges that the
shift lever is in D range.
WIRING DIAGRAM
Neutral Start To Combination Meter Engine & ECT ECU
Switch
4 A C 18
L 3 L L C C L
ED4 E6 L
8 R−L
R−L 4
ED2 3 19
2 2 Y Y A A Y E6 2
ED4
J3
D Junction
J8
Junction Connector Connector
Junction
Connector B B−W 1 E E B−W 8 15
5 6 B−W B−W
D ED2 J8 J7 BG5 E6 NSW
J8 E
B−W
To Starter
Relay Center J/B
Ignition Switch
R−L 3 ST 4
B−W 6 ST2 AM2 10 B
1A 1N
GAUGE Center J/B
2 3
B−Y 2 IG1 AM1 4 1N 1
1B 1N
Battery
D04795
INSPECTION PROCEDURE
PREPARATION:
ON
Turn the ignition switch ON.
CHECK:
Measure voltage between terminals NSW, 2, L and R of the En-
gine & ECT ECU and body ground when the shift lever is shifted
to the following ranges.
OK:
2 L
NSW NSW−Body R−Body 2−Body L−Body
Range ground ground ground ground
D04723
P, N 0V 0V 0V 0V
R 9 − 14 V* 0V 0V 0V
D 9 − 14 V 0V 0V 0V
2 9 − 14 V 0V 9 − 14 V 0V
L 9 − 14 V 0V 0V 9 − 14 V
HINT:
*: The voltage will drop slightly due to lighting up the back up
light.
NG
PREPARATION:
(a) Jack up the vehicle.
(b) Remove the neutral start switch.
CHECK:
Check continuity between each terminal shown below when the
shift lever is moved to each range.
OK:
Shift Range Terminal No. to continuity Terminal No. to continuity
Q07657
P 4−7 5−6
R 4−8 −
N 4 − 10 5−6
D 4−9 −
2 2−4 −
L 3−4 −
OK
Repair or replace harness and connector between battery and neutral start switch, neutral start
switch and Engine & ECT ECU (See page IN−30).