Professional Documents
Culture Documents
Safety-Walk™ Cushion Matting 5270 - 5270E: Technical Data
Safety-Walk™ Cushion Matting 5270 - 5270E: Technical Data
Safety-Walk™ Cushion Matting 5270 - 5270E: Technical Data
Technical Data
TD 494 - Issue 3 - Date: July 2003
Supersedes: March 2001
DA. Page 1 / 3
_______________________________________________________________________________________________
B&CS European Laboratory, Eurotech Lab, 95250 Beauchamp, France
Safety-Walk™ Cushion Matting 5270 - 5270E
Technical Data
TD 494 - Issue 3 - Date: July 2003
Supersedes: March 2001
DA. Page 2 / 3
_______________________________________________________________________________________________
B&CS European Laboratory, Eurotech Lab, 95250 Beauchamp, France
Safety-Walk™ Cushion Matting 5270 - 5270E
Technical Data
TD 494 - Issue 3 - Date: July 2003
Supersedes: March 2001
DA. Page 3 / 3
Installation and cleaning instructions:
Applying Matting Edging: (cont’d) Cleaning instructions: Important:
Apply edging to opposite ends of It is important to follow these direc- 1. Make sure both sides of mat and
matting where most people will walk. tions carefully to achieve optimum the floor are completely dry be-
Recommended maximum edge length mat performance. fore replacing the mat on the
is 3.6 meters. floor.
1. Arrange mat on floor so that sides Daily maintenance: 2. The cleanliness of the floor and
to be edged are straight. Trim 1. Shake mat vigorously to remove the bottom side of the mat are
edges with a utility knife (not debris. critical to prevent mat movement.
scissors) and a straight edge if 2. Clean up debris under and around 3. The frequency of cleaning is
necessary. mat and place mat on a clean dry dependent upon where the mat is
2. Cut a piece of edging the same floor. used.
length as the edge of mat. 3. Damp mop solid top surface of 4. Periodically inspect both sides of
3. Place edging flat on the floor, mat and return to service. the mat and the area underneath
grooved side up. the mat for grease, water or other
4. Apply two beads of adhesive Periodic maintenance: debris and residues which could
liberally to the top of edging 1. Remove debris (see daily main- affect mat performance.
groove. tenance). 5. Do not store mat folded up.
5. Place edge of mat on top of 2. For difficult to remove oil, 6. Do not use chlorinated solvents
edging groove containing adhe- grease, and/or debris, spray or or cleaners for cleaning.
sive. Gently work mat snugly mop on a general purpose cleaner 7. Do not submerge the mat in
into the corner of edging groove or non-chlorinated degreaser solutions containing high concen-
to ensure a good fit. prior to cleaning. trations of alcohol (> 40 %).
6. Place a weight, such as a 3. Scrub solid top surface with a 8. Do not dry mat over objects
board,along the full length of deckbrush. which might cause the mat to de-
edging to maintain pressure on 4. Rinse off. form
the bond. Allow to dry undis- 5. Allow to dry before placing back
turbed for at least 8 hours before in service.
placing it into service.
_______________________________________________________________________________________________
B&CS European Laboratory, Eurotech Lab, 95250 Beauchamp, France