Professional Documents
Culture Documents
Pacific Paint (Boysen) Philippines, Inc., - Two-Component Epoxy Based Coatings - BOYSEN - Sup - ® - Sup - Epoxy Enamel
Pacific Paint (Boysen) Philippines, Inc., - Two-Component Epoxy Based Coatings - BOYSEN - Sup - ® - Sup - Epoxy Enamel
AVAILABLE COLORS:
B-2100 White with Curing Agent B-2101
B-2130 Silver Gray with Curing Agent B-2103
B-2132 Gray with Curing Agent B-2103
B-2140 Royal Blue with Curing Agent B-2103
B-2151 Dark Green with Curing Agent B-2103
B-2171 International Red with Curing Agent B-2103
B-2190 Black with Curing Agent B-2103
SURFACE PREPARATION:
Concrete Flooring:
Remove oil and grease by detergent cleaning. For smooth surfaces, acid etch to improve adhesion. Do
this by mixing one (1) part muriatic acid to one (1) part water. Apply over masonry and let stand for 2-3
minutes. Rinse with water to remove residual acid. If possible, rinse by pressure washing.
Finished acid etched texture should be similar to that of 40-60 grit sandpaper. Make sure that the
surfaces to be painted are clean and dry.
Metal:
Wipe the surface with rag soaked in paint thinner to remove dust, dirt, grease, oil, wax and other foreign
matter. For new G.I. sheets, etch the surface by applying 10% BOYSEN® Metal Etching Solution #71
(dilute 1 part of B-71 to 9 parts water).
If repainting on surfaces with alkyd or lacquer-based coatings, scrape off all paint film to bare substrate.
Remove oil and grease by detergent cleaning followed by scuff sanding. To remove rust, wire brush or
scrape affected areas and apply BOYSEN® Metal Etching Solution #71 over rusted portions. Let it stay
for 10 – 15 minutes. Be sure to wash off surface thoroughly with water, letting it dry before applying paint.
Primer should be applied immediately upon drying of the surface before rust sets in.
PAINTING SCHEDULE:
Concrete Flooring:
Mix three (3) parts of BOYSEN® Epoxy Primer White #2200 to one (1) part of its catalyst.
Allow twenty (20) minutes induction time. Thin 1:1 with Epoxy Reducer #55. Apply as primer coating on
bare concrete floors. Let dry overnight. Mix BOYSEN® Epoxy Enamel with its catalyst as with the
procedure of the BOYSEN® Epoxy Primer. Paint 2-3 coats of this mixture over well-primed surface. Allow
8 hours to overnight before recoating.
Metal:
Prime base metal with BOYSEN® Epoxy Red Oxide Primer #2277 or BOYSEN® Epoxy Primer Gray
#2230. Let dry 8 hours to overnight. Topcoat with 2-3 coats of BOYSEN® Epoxy Enamel. Let dry
overnight before recoating.
NOTE:
Foot traffic abrasion resistance fully develops after three (3) days of curing. For heavy duty application,
allow seven (7) days of drying.
Application of topcoat should be done within 7 days after priming to ensure good intercoat adhesion,
otherwise re-application of primer is needed.
Choose Color
For technical reasons connected with color reproduction and paint manufacturing, these patterns may not
exactly match the paint color.
B-2100 White B-2130 Silver B-2132 Gray B-2140 Royal Blue B-2151 Dark B-2171
Gray Green International Red
B-2190 Black